[Rmpr 165] [From the U.S. Government Publishing Office, www.gpo.gov] RMPR 165 Supplementary Service Regulation 49 * * Automotive Repair Services Effective June 14, 1945 UNITED STATES OF AMERICA OFFICE OF PRICE ADMINISTRATION WASHINGTON 25. D. 0. OFFICE OF PRICE ADMINISTRATION RMPR 165 SUPP. SERVICE REG. 49 MAY 15, 1945 (Document Nb. 44744) Part. 1499—Commodities and Services I RMPR 165,1 Supp. Service Reg. 49) AUTOMOTIVE REPAIR SERVICES A statement of the considerations involved in the issuance of this regulation, issued simultaneously herewith, has been filed with the Division of the Federal Register. § 1499.682 Maximum prices for specific automotive repair services. The provisions of RMPR 165 are modified to the extent set forth below as far as automotive repair services are concerned. (a) Charge based on customer’s hourly rate. Your maximum price for each automotive repair service listed in Appendix A of this regulation shall not exceed: (1) A charge for labor resulting from multiplication of your customer’s hourly rate established under RMPR 165 or any applicable supplementary service regulation by the hours or fractions of hours which are specified in Appendix A, plus (2) A charge for parts and. materials not to exceed your maximum prices therefor. If you have not already established a customer’s hourly rate for pricing any service listed in Appendix A, you must establish such a rate under section 5 of RMPR 165. (b) Fixed charge. If, however, your maximum price under RMPR 165 for any service listed in Appendix A, is a “fixed charge,” you may not charge more for that service than your fixed charge or the price determined under the preceding paragraph, whichever is lower. A “fixed charge” means a charge which is not computed by means of a customer’s hourly rate. (c) Lower prices. Prices lower than those established by this regulation may be charged at any time. (d) Overlapping operations; discounts. The practice of charging not more than once for overlapping operations, which has applied to pricing by use of manuals or labor schedules, also applies to pricing under this regulation. If you perform an operation listed in Appendix A which contains a step included in another operation which you perform, follow this rule, unless otherwise indicated in Appendix A—Use Ap- 19 F.R. 7439, 9107, 9411, 11173, 12040, 12969. pendix Afto compute your price for the longer operation; and price under RMPR 165 that part of the shorter operation which has not already been taken into account. For example—Assume that the longer operation consists of three steps (A, B, and C) and that the shorter operation consists of two steps (B and D). One step (B) is common to both operations. Compute your price for the longer operation (ABC) by using the time set forth in Appendix A. Price under RMPR 165 that part (D) of the shorter operation (BD) which you have not already taken into account. You have already taken into account the step (B) common to both operations in computing your price for the longer operation. You must maintain your customary allowances, discounts, or other price differentials. (e) Sales slips or receipts. Regardless of any request therefor, you must give to any person purchasing a service listed in Appendix A a sales slip or receipt showing: (1) Your name and address, (2) The date, (3) A brief description of each service supplied, (4) The number for that service given in Appendix A, (5) Your customer’s hourly rate, (6) The number of hours charged for (indicating overtime hours if charged for at overtime rates), (7) The prices charged for parts and materials, and (8) The total charge. (f) Services not listed in Appendix A., The following rules shall govern services not listed in Appendix A: (1) Maximum prices. Your maximum price for any service not listed in Appendix A shall continue to be your maximum price for that service as established by RMPR 165 or any applicable supplementary service regulation. (2) Availability to customers of flat rate manual or labor schedule. If you use a flat rate manual or labor schedule in pricing any service not listed in Appendix A, you must on request make such manual or schedule available to your customer for his inspection. (3) Sales slips or receipts. If your cutomer requests a sales slip or receipt for any service not listed in Appendix A, you must give him a sales slip or receipt showing: (i) Your name and address, (ii) The date, (iii) A brief description of each service for which a separate charge is made, (iv) (a) If customer’s hourly rate alone is used in pricing the service, your customer’s hourly rate and the number of hours for which a charge is made (indicating overtime hours if charged for at overtime rates). (b) If flat rate manual or labor schedule is used in pricing the service, the name of the manual or schedule, the number or other identification of the service as it appears in the manual or schedule, your customer’s hourly rate, and the number of hours for which a charge is made (indicating overtime hours if charged for at overtime rates). (b) If fixed charge is used in pricing the service, the fixed charge. (v) The prices charged for parts and materials, (vi) Any other charge (and indication of its nature), and (vii) . The total charge. (g) Availability of this regulation to customers. A copy of this regulation shall be kept available at your place of business for inspection by your customers. This regulation shall become effective June 14,1945. Issued this 15th day of May 1945. Chester Bowles, Administrator. Appendix A—Automotive Repair Services Important! So that you will properly determine your maximum prices, it is important that you understand the terms defined below. These terms as used in Appendix A shall have the meanings indicated, unless the context clearly otherwise requires. All other terms used in Appendix A shall have their customary trade meanings. “Automotive repair services” means the repair operations listed in Appendix A when performed on any automobile listed there which is primarily designed for transporting persons, except ambulances and hearses. “Remove” means to take off or to take out a part or parts. “Install” means to put back the same part or parts. “Replace” means to remove a part or parts and to put in or attach a different part or parts. “Overhaul” means to tear down an assembly, to inspect all its parts, and to rebuild the assembly, replacing parts where necessary. GPO—OP A 10901—p. 3 INDEX Pages 7-16, Inclusive: Buick Cadillac and La Salle Chevrolet Chrysler De Soto Dodge Ford and Mercury * Hudson and Terraplane Pages 17-29, Inclusive: • Lincoln K Series and Lincoln Zephyr Nash and Lafayette Oldsmobile Packard Plymouth Pontiac Studebaker Willys GPO—OPA 10901—p. ö Car make and model GPO—OPA 10901 Operation Buick Cadillac and La Salle Chevrolet Chrysler De Soto Dodge . Ford and Mercury 1 Hudson and Terraplane Year Model 1 Hours J Year Model 1 Hours Year Model I Hours 1 Year Model I Hours Year Model 1 Hours Year Model ! Hours J Year Model Hours Year Model Hours j Engine 1. Remove carbon, grind and reface valves, and tune up engine. S 1936-37 1938-39 1940 1941-42 1941-42 ngle carburetor All 5.5 6.0 6.5 6.5 6.7 1936 1936 1936-37 1936-37 1936-42 1938 1939-40 1938-40 50 6.6 8.8 15.1 17.2 9.2 10.2 10.2 25.6 1936-42 All 4.5 1936-37 1936-37 1938-39 1938-39 1940-42 1940-42 Doesi Ieri 5004 Six 6.7 8.8 7.0 9.4 7.2 9.6 rys-No. rine 1936-37 1938-39 1940-42 All 7.5 7.8 8.0 Ì936-37 1938-39 1940-42 All 6.5 6.9 8.0 1936-42 1936-42 All 6-cyl* inder engines. All V-8 engines. 5.2 6.6 1936-38 1936-38 1939 1939 1939 1940-42 1940-42 Six 5.7 6.5 6.0 5.7 7.1 5.5 6.7 All 60,70,75 V-12 Eight All All Eight - All 1. Six All All 92-93 40.. V-16 Eight........ Six (except 92-93) Eight....... Six..... Eight....... 408.50,60,70, 90. V-8 (except 193865,75; 1939 75; 1940 75). 65,75 Six. Eight rot include Ch ?ime Schedule maior en 75...; tune-up. Does include minor tnne-un onera- Vrl6 tion No. 5002. 2. Piston assembly, replace one. No honing or lapping included. Does not include reconditioning . cylinder bore. 1936-38 1939-40 1941 1942 All 4.8 4.4 5.0 4.4 1936 1936 1936-37 1937 1938-42 1936-37 1938-40 1938-40 Cover pisfc Doe mov from aligr 50 2.1 2.5 2.9 2.5 2.5 2.6 3.4 4.3 and ily. reton ude 1936-39 1940-42 All 5.5 5.1 1940-42 1940-42 Indue Six A— 4.0 4.3 1936-38 1937 1939-42 All 3.5 4.7 4.0 1936-39 1940-42 All 3.5 4.0 1936-42 1936-42 Inclu pum gask All 6-cylin-d e r e n • gines. All 8-cylin-der engines. All 60 H. P. engines, des cleaning p and replac ets. 4.9 6.3 5.8 oil ing 1936-42 1936-42 4.0 4.6 All 60. All i Eight. All All All All 65,70,75,80,85 50,60 Includes replacing piston pin and connecting rod if necessary. es removing carbon.- All Includes replacing piston nin and connecting rod V-8 V-16 if ne cessary. V-16 right side. V-16 left side. replacing rod n assembly oi not include al of rings or pis rod. Doesincl ing rods. 3. Piston assembly, replace each additional one when done in . connection withOperation No. 2. No ho • ning or lapping included. Does not includes reconditioning cylinder bores. 1936-42 All .0.8. 1936-42 Inclue piste nect AU..., O.7 ach on- 1936-42 All 0.9 Includ piste nect es replacing e >n, rings and c mg rod. ach on- es replacing e o; rings' and ing rod. 4. Pistons (rings, and piston). Replace all. Does not include reconditioning cylinder bores. 1936-42 1936-42 1936-42 Incluí bon, and ing 0.2 h each pin All 6-cylin-d e r e n • gines. All 60 H. P. engines. All V-8 engines. es removing '< cleaning oi) j pump, and al connecting ro r. to be added oversize pis itted. 6.4 8.1 8.6 jar-jan gn* ds. for ton 1936-42 1936-42 7.4 8.7 1 Eight . Ri Piston rings, standard, r eplace all. Does not- include reconditioning cylinder bores. 1936-38 1939-40 1941 1942 Inclu carb All 8.0 7.6 8.2 7.6 ng 1936 1936-42 1936-37 1936-37 1938-40 50 5.6 7.2 9.2 11.1 13.0 1936-39 1940-42 All. 8.3 7.9 1936-42 1936-42 1936-42 Includ bon, and All 6-cylin-der engines. All 60 H. P. engines. All V-8 engines. s cleaning c cleaning oil p >il pump. 6.1 ■7.5 8.0 aran 1936-42 1936-42 Six 6.5 6.9 All All. V-8...L V-12... All All V-16 des removi 3D. V-16........ Car make and model. GPO—OPA 10901—p . 8 Operation Buick Cadillac and La Salle Chevrolet Chrysler De Soto Dodge Ford and Mercury Hudson and Terraplane Year Model Hours j Year Model i Hours j Year Model I Hours j Year Model Hours | Year Model I Hours I Year Model j Hours Year Model j Hours : Year Model j Hours j Engine 6. Piston rings and connecting rod bearings, replace ^11. Does not include reconditioning cylinder bores. 1936 1936-37 1936-37 1937 1938 1939 1938-39 1940-42 1940-42 Six 5,5 -7.9 7.6 6.7 5.5 5.9 7.6 6.2 7.8 1936-37 1938 1939 1940-42 AU 6.6 7.8 6.6 6.2 1936-39 1940-42 All 5.0 6.2 1936-42 1936-42 1936-39 All 6-cyl-inder engines. All 60 H. P. engines. AU V-8 engines. 7.3 8.3 8.8 C-8, C-ll, C-14, C-15. C-9, C-10, C-11,C-17. Six Six.. Six... All. AU.... All AU.; Eight Six. Eight.’; 7. Connecting rod, replace one. Includes removing and installing or replacing piston pin. 1936-38 1939-40 1941 1942 All 4.6 4.2 4.8 4.2 1936-39 1940-42 All .... 5.3 4.9 1936 1936-37 1936-37 1938-39 1938-39 1940-42 1940-42 Six 2.7 3.5 3.3 2.7 3.3 3.3 3.5 1936 1937 1938 1939-42 All....: 2.7 3.9 2.7 3.2 1936-39 1940-42 All 2.7 3,2 1936-42 Includ Six.......... 3.5 All All... All All C-8, C-14, C-15, C-16. C-9, C-10, e-u, c-i7. Six All All. es removing and Includes aliening rod All installing cylinder head. AU 1936-42 Eight..;.*..; 2.0 Eight Six Eight 8. Connecting rod, replace each additional one when done in connection w i t h Operation No. 7. 1936-42 All# 0.6 1936 1936-42 1936-37 1938-40 Opera plac asse clud 50 0.7 0.6 0.9 0.6 reton In- 1936-42 AU , 0.5 1936-37 1938-42 All 0.5 1936-42 AU.;..;..... 0.5 V-8 AU 0.7 V-12 or V-16. V-16 ;ion calls for ing rod and pis tnbly only, es aligning rod 9. Connecting rods, replace all. Includes removing and installing, or replacing, piston pins. 1936-38 1939-40 1941 1942 All 8.8 8.4 9.0 8.4 1936 1936-42 1936-37 1936-37 1938-40 Opera nlac 50 3.7 5.3 6.4 7.2 9.1 reton 1936-39 1940-42 All 7.5 7.1 19^5 1936-37 1936-37 1938 1938-39 1939 1940-42 1940-42 Six.... 6.0 7.9 7.3 6.0 7.3 6.4 6.5 7.5 1936 1937 1938 1939-42 All 6.0 7.2 6.0 6.5 1936-39 1940-42 AU... 6.0 6.5 All V-8 AU C-8, C-14, C-15. C-9, C-10, C-ll,C-16, C-17. Six All AU All . V-12 Includes aliening rods All X AU V-16 V-16........ lion calls for me rod and nis and tuning engine. All..... assemblies only? Includes aligning rods. Eight Six Six........... Eight. 10. Connectingrods,, piston rings, and piston pins, replace all. Does not include reconditioning cylinder bores. 1936-38 1939-40 1941 1942 All All 10.4 10.‘0 10.6 10.0 See C pèration No. S All AU 11. Main bearings, adjust all. 1936-38 1939-40 1941 1942 4.0 3.6 4.2 3.6 All 1.9 1936-40 1936-40 Six... 3.2 4.2 All ..... AU Eight m connection with Operation No. 9. All 12. Main bearings, replace all. 1936 1936-42 1936-37 1936-37 1938-40 50 4.8 4.1 6.5 7.3 6.9 1936-42 1936-42 Includ and not inte? (pou AU 6-cylinder engines. All 60 H. P. engines. All V-8 engines. es cleaning oil oil pump. D ipply to beari Tai with bl( red). 3.7 4.2 4.7 >an oes ngs )ck 1936-42 1936-42 Does in Six.1........ 6.0 8.0 IO V* | * * V-8 V-12. lot include rei g crank shaft. V-16 V-16 Car make and model GPO—OPA 10901—p. 9 Operation Buick Cadillac and La Salle Chevrolet Chrysler De Soto Dodge Ford and Mercury Hudson and Terraplane Year Model Hours J Year Model Hours j Year Model Hours Year Model 1 Hours j Year Model | Hours Year Model Hours Year Model j Hours Year Model 1 Hours | Engine 13. Main bearings, connecting rod bearings, and crank shaft, replace all. 1936-39 1936-38 1939 1940-41 1940-41 1942 1942 Incluc in: Six Eight.. 13.0 14.5 13.5 12.5 13.7 11.1 13.1 rad 1936-37 1938 1939 1940-41 1942 All 13.0 13.7 13.3 12.5 10.7 1936-38 1939 1940-41 1942 AU 12.0 11.4 12.5 13.1 1936-42 1936-42 AU 6-cylin-der engines All V-8 en-eines. 5.8 6.3 - A All... AIL - Eight. All All. Six. All— All Eight. All Includes removing and installine eneine. ' " Includes removing and installing engine, clean- Six. Includes removine and. Eight es removing stalling engine. in stalling engine. ing pun oil pan and P- oil 14. Connecting rod bearings, replace all. 1936 1936-42 1938-40 50 2.6 3.1 4.9 1936 1936-37 1936-37 1938 1938-39 1939 1940-42 1940-42 Incluc in Six 3.8 5.5 4.7 3.8 4.7 4.2 3.1 4.5 1936 1937 1938 1939 1940-42 Incluc in All ,3.8 5.0 3.8 4.2 3.1 1936-38 1939 1940-42 All. 3.8 3.2 3.1 1936-42 1936-39 All 6-cylin-der engines. All 60 H. P. engines. All V-8 engines. 3.9 4.3 4.8 V-8 C-8, C-14, C-15. C-9, C-10, C-ll,C-16, C-17. Six AU All All— All All V-16 All- es removing stalling oil pan md Includes removing and installine oil nan. Eight....... Six.—. Six. Eieht es removing and stalling oil pan. Fuel 15. Fuel pump, replace. 1936-39 40 0.4 1936 1937-38 1939-40 1936-40 1941-42 Opera ing pum V-8 0.5 1.0 1.2 0.5 0.5 lac-um 1936-42 All 0.4 1936-42 All 0.9 1936-37 1938-42 All 0.8 0.9 1936-37 1938 1939-42 All 0.6 1.6 0.9 1936-42 All 0.3 1936-37 1938-39 1938-39 1940-42 All 0.3 0.5 1.1 0.6 V-8 All All 89,90,93 V-8 . All All except 89,90,93. All V-12. V-16.. V-8... ion covers rep fuel fmd vacu P- Oiling 16. Oil pump, and/ or oil pump gasket, replace. 1936-37 1938 1939-40 1941 1942 All 2.1 1.9 1.5 2.1 1.5 1936 1936 1937 1937 1938-42 1936-37 1936-37 1938-40 1939 1940 60,70,75..... 1.8 1.3 1.8 1.3 1.3 2.8 2.6 1.7 1936-39 1940-42 All 1.6 1.2 1936 1936-37 1937 1937 1938-40 1941-42 Incluc tion C-7, C-8 1.3 1.0 4.2 6.2 to Í 0.7 ?ni- 1936 1937 1937 1938 1939 1940-42 Incluc tion All 1;2 4.2 6.2 1.2 1.0 0.9 1936-38 1939 1940-42 Incluc tión All 1.0 0.7 0.9 'ni- 1936-37 1938-39 1938-39 1940-42 All 0.4 0.6 Ì.1 0.5 Al! ... 50.... All C-9. C-10, C-ll. C-17 C-14. C-15. C-16, pressed steel mountings. C-14, C-15. C-16, cast iron mountings. All.. All with first type engine mounting. All with second type engine mounting. All All „ 89,90,98 JAH ... 65, 70, 75, 50.60 V-8, except 198950,1940 50,52 .. V-12 V-16..; All All ■ except 89,90,98. All f All AU......V.. es resetting i timing. V-16 50 1.5 1,5 All 50,52. All es resetting i timing. ?ni- All— es resetting i timing Cooling system 17. Water pump, and/or water pump gasket, replace one. 1936-37 1938-40 1941 1942 All 1.4 1.2 0.8 0.9 1936-38 1939-40 1941-42 1936-37 1936-40 V-8 ........ 0.6 0.8 0.6 1.8 1.0 1936-42 All 0.7 1936 1936-37 1937 1938-39 1940 1941-42 1941-42 C-7, C-8— C-9, C-10, C-ll, C-15, C-16. C-17 C-14 All All 1.8 1.1 2.0 1.1 1.5 1.5 1.0 1936 1936 1937-39 1940-42 8-1 1.5 1.1 1.1 1.0 1936-37 1938 1939-40 1941-42 All 1.5 1.0 1.4 1.3 1936-42 1936 1937-42 All 6-cylinder engines. All 60 H. P. engine®. All V-8 engine. All V-8 engines. 0.6 0.8 0.8 1.0 1936-42 — All 0.8 Al! .- V-8.......— S-2 All..;..— All- AIL. All .. V-8 All 4... All V-12 All V-16 « Eight Six. Covers replacing one pump only. Car make and model Operation Buick Cadillac and La Salle Chevrolet Chrysler De Soto Dodge Ford and Mercury Hudson and Terraplane Year Model 1 Hours j Year Model 1 U 1 Hours j Year Model J Hours J Year Model 1 Hours J Year Model Hours I Year Model Hours Year Model 1 Hours J Year Model ■ ! Hours I Cooling system 18. Water pump,, overhaul. Includes removing and installing. 1936 1937 1938-40 1941 1942 All All 1.9 1.3 1.6 1.2 1.3 1936 1936-38 1939-40 1941-42 1936-37 1936-37 1938-40 50 1.6 1.2 1.4 1.2 2.8 2.0 1.6 1936 1936-37 1937 1938-39 1940 1941-42 1941-42 C-7, C-8.... C-9, C-10, C-11,C-15 C-16, C-17. C-14 2.8 2.1 3.0 2.1 2.5 2.5 2.0 1936 1936 1937-39 1940-42 S-l 2.5 2.1 2.1 2-0 •1936-37 1938 1939 1940 1941-42 All.. 2.5 2.0 2.5 2.4 2.3 1936-42 1936 All 6-cylin-der engines. All V-8 en-eines. 0.9 1.1 1.1 1.3 1936-42 All 1.9 V-8 (except 1936 50). V-8 S-2 AIL AH All All All All All AB V-8 All V-12 All V-16. AU Eight 1937-42 All V-8 engines. V-I6 Six Ignition and electrical 19. Distributor breaker points, clean and adjust, or replace. Includes retimingignition. 1936-42 All.... 0.5 1936-42 1936-37 1938-40 V-8. 0.8 1.5 1.0 1936-42 All 0.5 1936-39 1940-42 All 0.6 0.7 1936-42 AU 0.6 1936-42 AU 0.6 « 1936-38 1939 1939 1940-42 1940-42 All 0.6 0.6 1.3 0.5 1.1 V-12 or V-16 V-16 AU 89,90,98..... 92,93,95,97.. Six.. Eicht ..... Including setting tin with fly-wheel mar ling cs. 20. Distributorunit, overhaul. Includes removing and installing. Also includes Operation No. 19. 1936-42 Inclut All es retiming ig tion. 1.3 ni- 1936-42 1936-37 1938-40 V-8 V-12 or V-16. V-16.. 1.3 2.1 1.5 1936-42 All 1.2 1936-42 AU 1.7 1936-42 All 1.7 1936-42 AU 1.7 1936-42 All. ;.. 1.0 21. Ignition coil, replace one.' 1936-42 All 0.3 193'6-42 1936-40 V-8.. 0.5 0.4 1936-42 AIL- 0.3 1936-39 1940-42 All 0.6 0.5 1936-39 1940-42 All 0.6 0.5 1936-42 All 0.5 1936-42 1936-42 AU 6-cylin-der engines. All V-8 engines. 0.2 0.4 1936-39 1940-42 AU ... All 0.5 0.3 V-12 or V-16 (Coil less Electrolock.) All... All 22. Condenser, replace one. 1936-42 All 0.3 1936-42 1936-40 V-8.... V-12 or V-16 0.3 0.4 1936-42 AU.. 0.3 1936-39 1940-42 All.......... 0.5 0.4 1936-39 1940-42 All 0.5 0.4 1936-42 All .'... '0.4 1936-38 1939... 1939... 1940-42 1940-42 All 0.2 0.2 1.1 0.2 0.5 AU All 4 89,90,98 92,93,95,97.. Six Eight 23. Starting motor, replace. 1936-42 AU 0.4 1936-37 1938-42 1938-40 AH 0.5 0.5 0.7 1936-40 1941-42 AB :.. 0.4 0.6 1936-37 1938-42 1938-39 1940-42 All Ì.2 1.2 0.8 1.0 1936-39 1940-42 All 1.2 1.3 193,6-37 1938-42 All ..... 1.0 1.2 1936-39 1940-42 All 0.8 0.6 V-8 AB Six... AU .... AIL All . . V-16........ Eight....... Eight....... 24. Generator, adjust charging rate. 1936-39 1940-42 AH 0.3 0.4 1936-42 All 0.5 1938-39 1940-42 All 0.3 0.4 1936-37 All 0.3 1936 S-2 0.3 1936-38 All 0.3 - 1936-42 All 0.3 All All 25. Generator, replace. 1936-41 1942 All 0.4 0.5 1936-42 1936-37 1938... 1939-40 V-8...:.?... 0.4 1.4 0.8 0.4 1936-42 AU 0,4 1936-42 AU.. 0.7 1936-42 All 0.7 1936-42 All 0.7 1936-42 AU. 0.6 1936-42 All . 0.8 All... V-12 or V-16. V-16... V-16.. Clutch 26. Clutch, adjust at pedal. 1936-42 All 0.2 1936-42 AU 0.5 1936-42 All 0.5 1936-42 All 0.5 1936-42 All 0.5 1936-42 All 0.3 - 27. Clutch disc, discs orclutch driven plate, renew facings. Includes removing and installing disc, discs’ or plate. 1936 1936 1936 1936-37 1937-42 1938-40 50.... 3.5 4.0 6.5 6.5 4.0 4.4 1936-42 All—. 0.9 1936-42 All 0.9 1936-42 All no 60 When done in connection with Operation No. 28. Does not include removing and installing clutch disc. When done in connection with Operation No. 28. Does not in-, elude removing and installing clutch disc.' 70,75 tion with Operation No. 28. Does not include removing and installing clutch disc. V-12 or V-16. V-8. V-16 o î o ►ö o co ï o Car make and model GPO—OPA 10901— p.11 Operation Clutch 28. Clutch disc, discs, or clutch driven plate, replace all. Year Buick Model ' ! Hours ! Cad Year 1936... 1936... 1936... 1936-37 1937-42 1938-40 llac and La Sa Model 50 60. lie CO Ö . O w 2.7 3.2 5.7 5.7 3.2 3.6 Year Chevrolet Model 1 . i i Hours Year 1936 1936-38 1937-39 1938, 1938 1939 1939 1939 1940 1940 1941 1940 1940 1941 1941-42 Chrysler Model C-7, C-8 ... C-9, C-10, C-ll, C-15, C-17, C-20.' C-14, C-16, C-18, C-19, C-22 no overdrive. Six with overdrive. C-19 with overdrive. Six with overdrive. Hight, n o overdrive. Eight with overdrive. Six, no overdrive. Six with overdrive. Six, no overdrive. Eight, ho overdrive. Eight with overdrive. Eight with fluid drive, and overdrive. All with fluid drive and Vaca-m a t i c transmission. CO 9 O 4.0 6.0 3.6 4.7 6.8 5.8 4.3 6.2 2.4 3.1 2.2 2.9 3.1 2.9 3.1 Year 1936 1936 1937-39 1938 1939 1940 1940 1941-42 1940-42 De Soto Model . S-l - th 8 o M 3.0 5.2 3.0 4.7 5.8 2.4 3.1 2.2 3.1 Year 1936-38 1939-40 1941-42 1941-42 Dodge Model All. r.. m Ö o » 3.0 2.4 2.2 3.0 Fo Year rd and Mercur Model 1 Hours I 1 Huds Year on and Terfap Model 1 Hours S J S-2 All... 70,75 V-12 or V-16 V-8 Standard.... All with overdrive. All with overdrive. Standard.— All with overdrive. Standard- All with fluid drive and. Sim-plimatic transmission. All without fluid drive All with fluid drive. V-16 29. Clutch release bearing, replace. (Continued on next page.) 1936-37 1938 1938 1939 1940-42 All- 4.6 4.0 4.7 4.5 4.1 1936 1936 1937-39 1939-42 Standard.... Master .3.6 2.6 2.6 2.9 1936 1936-38 1937 1938 1938 1938-39 1939 1939 1939 1940-41 1940-41 C-7, C-8.... C-9, C-10, C-ll, C-15, C-17, C-20. C-14, C-16.. C-18. C-19.. Six with overdrive. Eight with overdrive. Eight i no overdrive.' Six no overdrive. Six with overdrive. C-25, C-26, C-28, C-30. without overdrive. C-25, C-26, C-30 with overdrive. 3.2 5.7 3.8 Ji. 2 4.3 6.4 3.2 2.3 6.0 1.8 2.0 1936 1936 1937-38 1938 1939 > 1939 1940-42 1940 1941-42 S-l 3.2 5.3 3.2 4.3 2.3 6.0 1.8 2.0 2.3 1936-38 1939 1940-42 All 2.7 2.4 1.8 1936-39 1936-39 1940 1940 1941-42 1941-42 1942 1942 All without Electric Hand. All with Electric Hand. All without overdrive. AU with overdrive^ All without overdrive. All with overdrive. All with Drive Mas- All with Drive Master and overdrive. 4.0 5.2 3.6 4.1 3.6 3.9 4.2 4.7 All (standard transmission). All (selfshifting transmission). All S-2 All AH conventional gearshift. All vacuum. gearshift. Standard.... All... All with overdrive. Standard.... All with overdrive. Standard.... All with overdrive. ’All with Simplimatic transmission. All * Car make and model Operation Buick Cadillac and La Salle Chevrolet Chrysler De Soto Dodge Ford and Mercury Hudson and Terraplane co co CO CO CO CO ft CO Year Model ä o M Year Model 5 O m Year Model 5 o M Year Model Ö o W Year Model 3 á Year Model 5 o W Year Model 5 . O W Year Model s o • w Clutch 29. Clutch release, 1941-42 C-28, C-34, C-36, C-37 with Vaca-matic transmission. 2.3 etc.—Con. 30. Clutch, overhaul completely. 1936-37 All. 6.1 1936 50 3.5 1936 Standard- - 4.2 1936 C-7, C-8 5.0 1936 S-l 4.6 1936-38 All 4.2 1936-38' All without 4.7 1938 All (standard transmission). All (selfshifting transmission). AU 1936 60.... 4.8 1936 Master.. 3.2 1936-38 C-9, C-10, 7.0 1936 S-2 6.5 1939 All.... 3.6 Electric Includes removing and installing clutch assembly. 1938 1939 6.2 6.0 1936 1937-42 1936-37 1938-40 70,75........ V-8 V-12orV-16. V-16 5.7 4.8 5.7 5.8 1937-39 1939-42 All conven-tionalgear-shift. All vacuum gearshift. 3.2 3.5 1937-39 1938 C-ll, C-15, C-17, C-20. C-14. C-16, C-18. C-19, C-22. No overdrive. Six with 4.6 5.7 1937-39 1938 1939 1940-42 1940 Standard.—. All with overdrive. All with overdrive. Standard.... All with 4 6 5.7 6.8 3.6 4.3 1940-42 1941-42 All without fluid drive. All with fluid drive. 3.8 4.1 1936-38 1939 1939 Hand. All with Electric Hand. AU without Electric Hand. All with Elec- 6.1 4.5 5.2 1940-42 40,50 &1 overdrive. trie Hand. 1940-42 60,70,80,90.. 5.6 1938 1939 1939 1939 1940-41 1940 1940 1941 1941 1941-42 C-19 with overdrive. Six with overdrive. Eight, no overdrive. Eight with overdrive. C-25, C-28, C-26 without fluid drive. C-25, C-26 with overdrive. C-30 with fluid drive and overdrive. C-28, C-30 with fluid drive and stand a r d transmission. C-28, C-34. C-36, C-37 with fluid drive and vacamatic transmission. 7.8 6.8 5.3 7.2 3.6 4.1 4.3 4.3 4.1 4.7 1941-42 All with fluid drive and Sim-plimatie transmission. 4.7 1940 1940 1941-42 1941-42 1942 1942 AH Without overdrive. All with overdrive. All without overdrive. All with overdrive. All with Drive Master. All with Drive Mas ter and overdrive. 3.9 4.4 3.7 4.2 4.5 5.0 GPO—OPA 10902—p. 13 GPO—OPA 10901—p. 13 Gar make and model Operation Buick Cadillac and La Salle Chevrolet Chrysler De Soto Dodge Ford and Mercury Hudson and Terraplane Year Model J Hours Year Model [ Hours Year. Model | Hours Year Model Hours J Year Model [ Hours J Year Model 1 Hours 1 Year Model [ Hours Year Model Hours 31 Transmission Transmission, overhaul. Includes removing and installing. 1936-37 1938 1939 1939 1940-42 Applie tra: Includ univ on 1 All All 40,60 80,90 All ..... s to Synchro-A ismission only es overhau ersal joint, exc 139 40,60. 6.9 6.3 5.9 6.8 6.4 esh ing ept 1936 1936 1936 1936-37 1937 1938-42 Applie tra 1941-42 Applie trai 50 60. 70,75 V-12orV-16 V-8 All s to stand nsmission only V-8 s to Hydra-M ismission only 4.4 4.7 8.3 8.3 5.3 5.1 ard 13.3 itic 1936 1937-39 1939-42 Inclu u All All with conventional gearshift. All with vacuum gearshift des overhau1 niversal joint. 5.2 4.2 4.7 ing 1936 1936 1937-39 1939 1940-41 1941-42 C-7, C-8—-. C-9, C-10— C-14, C-16, C-18, C-19, C-22. Eight C-25, C-26, (convential type) C-28, C-30. C-28, C-34, C-36.C-37 with Vac-a m atic transmission. 5.5 7.0 6.0 6-7 4.2 5.5 1936-39 1936-38 1939 1940-42 1940 1941-42 Standard.... À11 with overdrive All with dverdrive ' Standard All with overdrive. With Simpli-matic transmission. 6.0 7.5 9.0 4.2 5.9 5.5 1936-38 1939 1940-42 Where equi pow 0.5 All ..... All All.. — transmission pped with vacu er gear shift 5.5 5.2 4.2 is um add Where move chas. 1936-42 1936-42 Add 0. nece - oil J haul Where 'move 1936-42 Incli elute Where move sis, 1 pan 1936-42 1936-42 Inclu clut purr oil p necessary to engine fr is: All 6-cylin-der engines All V-8 engines 7 in all cases wt ssary to rem an. Includes o’ ing clutch. unnecessary to engine from cha All des overhau :h. unnecessary to engine from c ut where engin must be remove All 6-cylin-der engines All 60 H. P. engines. All V-8 engines. des overhau :h, cleaning p and repla< an gaskets. re-om 6.3 6.4 ere ove «r- re- ssis: 5.5 ing re- las-oil d: 8.2 9.0 9.5 ing oil ing 1936-39 1936-39 1940 1940 1941-42 1941-42 1942 1942 All without Electric Hand. All with Electric Hand. All without overdrive. All with overdrive. All without overdrive. A11 w i t h overdrive. All with Drive Master. All wi-th Drive Master and overdrive. 6.0 7.2 5.5 6.5 4.8 5.8 5.6 6.6 32 Universals Universal, front or single, overhaul. Includes removing and installing. 1936-37 1938 1939 1939 1940-42 All All... 80,90 40,60 All 3.6 3.3 3.3 3.5 3.2 1936-42 All. 0.8 1936 1936 1937-39 1939-41 Standard..— Master — All with conventional gearshift. All with vacuum gear-shift. 2.5 1.5 1.5 1.6 1936-42 AH'. 1.2 1936-42 All. 1.2 1936-42 'All 1.2 1936-42 All 3.0 33 Universal, rear, * 1936-42 All 0.8 1936-42 All 1.2 1936-42 All. 1.2 1936-42 All. 1.2 overhaul. Includes removing and installing. 34 Rear axle Rear axle assembly, overhaul. Includes removing and installing. 1936-38 AU_ 6.8 1936-42 All 5.1 1936-42 All .. 7.2 1936-42 All... 7.2 1936-42 All. 7.2 1936-42 All 6.6 Overha carr semi 1936-42 uling differed er and gear set ly only. All dial as- 4.3 1939 1939-42 1940-42 40,60 80,90.. 40,50,60,70.. 7.0 6.9 6.6 O ■ ® ' - Car make and model Operation Buick Cadillac and LaSalle Chevrolet, Chrysler De Soto J* Dodge Ford and Mercury Hudson and Terraplane Year Model Hours 1 Year Model j Hours | Yía¿ - Model' Hours j Year Model Hours j Year Model j Hours Year Model | Hours Year Model j Hours ' Year Model Hours j Rear axle 35. Rear axle shaft, replace one, where not necessary to remove differential assembly. Does not" include replacing broken axle shaft where necessary to re-m o v e rear axle housing cover and opposite axle shaft. 1936 1936 1937-42 90. All except 90. AU J— 1.1 0.9 0.9 1936-37 1936-42 Indue brak 90. All except 1936-37 90. es bleeding e lines. 0.9 1.2 •ear 1936-42 All. 1.0 1936-42 All 1.3 1936-42 All 1.3 1936-37 1938-42 All... AU.;..—.— 1.0 1.3 1936-42 1936-42 All except models with fullfloating rear axle. All models with fullfloating rear axles, if necessary to disassemble. 5.0 5.6 1936-42 All 0.8 Wheels 36. Rear wheel bearing, replace one. 1936 1936 1937-42 90-.. - All except 90. All 0.7 1.1 1.1 1936-42 Inoltre brat All es bleeding e. 1.0 one 1936-42 All 1.2 1936-42 All.......... 1.3 1936-42 All. 1.3 1936-37 1938-42 All - All. 1.0 1.3 1936-42 Add bear in re All 0.4 for instal ing cup or sle ar hub. 0.7 ing eve 1936-42 All 0.8 37. Front wheel bear- 1936-42 All 0.6 1936-37 90 1.2 1936-42 All. 0.4 ings, inner and outer, replace one side. 1936-42 All except 1936-37 90. 0.9 38. Front wheel bearings, adjust. In-cludesremoving and installing wheels, cleaning and repacking bearings, both sides. 1936-42 All 0.5 1936-42 All. 0.5 1936-42 All.... 0.7 1936-42 All. 0.7 1936-37 1938-42 All All., 0.6 0.7 1936-42 All 0.5 1936-42 AU 0.4 39. Wheels, changing from front to rear, rear to front, or from one side to the other. Time shown per wheel. All models.. 0.1 All models. . 0.1 — All models.. 0.1 All models.. 0.1 All models.. 0.1 All models.. 0.1 All models.. 0.1 All models.. 0.1 Front axle and steering, । 40. King pin and/or king pin bushings or bearings, replace all, both sides. 1936-42 Indue casti All ; es adjusting ;r and toe-in. 2.1 for 1936-42 All..... 2.5 41. Steering knuckles, rebush both sides and replace king pins if necessary. 1936-42| All | 3.5 Includes adjusting for caster and top-in, and replacing thrust bearings if necessary.. 1936-42 Indue cast in. All es adjusting »r, camber and 4.4 for toe- SLA susp. (Incl. adj’g caster, camber & toe-in.) 1936-42| All .| 2.5 I—Beam suspension 1936-371 All 1 3.0 1938-421 All 1 2.5 Includes adjusting for ; toe-in. 1936-42 Indue anch whe All es adjusting br ors and align sis. 3.6 ake ing 1936-42 Indue anch whee All es adjusting br ors and align 4s. 3.6 ake ing 1936-42 Indue anch whee All..., es adjusting br ors and align >ls. 3.6 ake ing o TJ o I o g T GPO—OPA 10901—p. 13 Car make and model Operation Buick Cadillac and La Salle Chevrolet Chrysler De Soto Dodge . Ford and Mercury Hudson and Terraplane year Model ì Hours 1 Year Model J Hours 1 Year Model Hours Year 1 Model Hours Year Model ! Hours Year Model ! Hours Year Model 1 Hours Year Model J Hours j Front axle and steering 42. Steering tie rod 1936-40 80,90 1.2 1936-37 50.60 1.2 1936-42 All with SLA 1.3 1936-42 All 1.4 1936-42 All b.4 1936-42 All 1.4 1936-42 All 1.6 ' ■ Tie rods only and/or tie rod ends, replace both sides and align wheels. 1936-41 Indue 40,50,60,70.. es adjusting toe-in. 1.1 for 1936-37 1938-42 Indue All except 50, 60. All .... es adjusting toe-in. 1.7 1.2 for 1936-42 suspension. All with I-Beam and enclosed knee suspension. 1.1 » 1936-42 Indue toe-i Tie rc 1936-39 1940-42 Indue Alli es adjusting n. d end assemb only A1L..1 AU es' adjusting . toe-in. 1.0 for Ues 0.8 1.2 for 43. Steering drag link ball sockets, replace all. .... 1936-42 All 0.6 44. Steering knuckle assembly, replace one. 1936-42 AIL... 1.4 1Ô36-42 All SLA 1.4 1936-42 All 2.1 1936-42 All 2.1 1936-38 All 1.9 1936-42 All 1.5 Indue caste es adjusting r and toe-in. for Includes adjusting caster, camber and in. 1936-421 All I-Beam Includes adj’g. for toe for teje- 1.2 -in. Include anche whee brake « adjusting br r bolts, align s and bleec lines. ake ing ing Include anche whee brake s adjusting br >r bolts, align s and bleec lines. ake ing ing 1939-42 Include anehc whee brake AIL. s adjusting br r bolts, align s and bleec lines. 2.1 ake ing ing 1 . Includes' adjusting toe-in. 1 for Brakes 45. Service brakes, minor adjustment only. 1936-42 Indue cylir ,nece All..... es filling mas ifier with fluie ssary. 0.5 ter if 1936-42 Indue eylir nece All. es filling mas der with fluie ssary. 0.5 ter if 1936-39 1940-42 Indue cylir nece All... All es filling mas ider with fluie ssary. 0.7 0.5 ter if 1936-42 Adjus AIL. ing brake s cams only. 0.5 hoe 1936-42 Adjus All. ing brake s cams only. 0.5 we 1936-42 Adjus AIL. ing brake s ams only. 0.5 hoe 1936-42 All 0.5 1936-42 Includ cylir nece All es filling me ider with flui ssary. 0.8 ister d if 46. Service brakes, 1936-42 All 1.8 1936-42 AIL. 2.2 1936-39 All. 2.2 1936-42 All 2.0 1936-42 All 2.0 1936-42 All '2.0 1936-42 All with rod 1.2 1936-42 All 1.6 all four, adjust completely, free and tighten linkage, fill master cylinder, and bleed lines. Indue adju bear es repacking sting front wl Ings. md leel 1940-42 All 2.0 1936-42 . or cable control. All with hydra u 1 ic control. 1.0 47. Service brakes, bleed hydraulic system, all four wheels, and add fluid. 1936-42 All 0.7 1936-42 All 0.5 1936-42 All 0.7 1936-42 All 0.5 1936-42 All. 0.5 1936-42 All 0.5 All with hydraulic control. 0.8 1936-42 All 0.6 48. Service brakes, reline all four and adjust. Includes removing and installing shoes. 1936 1936 1937-42 Indue blee 90..... All except 90. All.... es adding fluid ding brake lin 4.2 : 3.8 3.8 Mid es. 1936 1936-42 90. All except 1936 90. 6.1 3.8 1936-39 1940-42 All .L... AIL... 3.4 3.2 1936-42 Indue \ and lines AIL... es adding f bleeding br 4.3 uid ake 1936-42 Indue and line AIL.. les adding f bleeding br 4.3 uid ake 1936-42 Indue and line All. es adding f bleeding br 4.3 uid ake ------ -------------- 1936-40 1941-42 AIL AIL 4.4 4.2 49. Brake shoes, re-( place all four 'and adjust brakes completely. 1936 1936 1937-42 Indue blee 90.. - All except 90. All. les adding fluid ding brake lin : 3.2 2.8 2.8 md es. 1936-42 All except 1936 90. 2.8 1936-39 1940-42 AIL All 2.4 2.2 1936-42 Indue and not men AIL... es bleeding 1 adding fluid, complete adj t. 3.1 nes ’ but ust- 1936-42 Indue and riot men All. es bleeding 1 adding fluid, complete adj t. 3.1 nes but ust- 1936-42 Indue and not men All es bleeding 1 adding fluid, complete adj t. 3.1 nes hut ust- 1936-42 1936-42 All with rod or cable control. All with hydraulic control. 2.0 1.8 1936-40 1941-42 All AU 4.0 3.8 50. Brake hydraulic master cylinder, overhaul. . Includes re-' moving and installing. 1936-37 1938-42 All * All 2.0 1.7 1936-42 Indue All les bleeding lit 1.6 es. 1936-42 — AIL 2.0 1936-38 1939 1940 1940 1941-42 Indue AIL. All Six..—..... Eight All .... les bleeding lin 1.9 2.6 3.2 1.7 2.8 es. 1936-38 1939 1940 1941-42 Indue A1L..1 All. AIL All ..... es bleeding lin 1.9 2.6 3.2 2.8 CS. 1936-38 1939 1940 1941-42 Indue All All All All es bleeding lin 1.9 2.6 3.2 2.8 es. Indue All with hydraulic control. es bleeding li: 1.4 íes. 1936-42 All 2.8 GPO—OPA 10901—p .16 Car make and model Operation Buick Cadillac and La Salle Chevrolet Chrysler De Soto Dodge Ford and Mercury Hudson and Terraplane Year . Model Hours j Year Model Hours j Year Model Hours । Year Model Hours j Year Model Hours Year Model I Hours Year Model Hours Year Model o W 0.2 Brakes >1. Brake pedal, adjust for proper clearance. .... 1936-42 All 0.2 1936-42 All.. 0.3 1936-42 All —- 0.3 1936-42 All 0.3 All with hy-d r a u 1 i c control. 0.3 1936-42 All Springs 52. Front spring, replace one. 1936-42 Coil spring All 0.6 1936-42 All 1.0 Ct. 1936-42 1936-42 il spring SLA suspension All.. Leaf spring All 0.6 1.0 1936-42 1936-37 1936-37 All of coil type. Leaf type-Right..... All of leaf type-Left. 0.7 2.7 3.0 1936 1936 1936-42 S-2 right.. S-2 left All except S-2. 2.7 3.0 0.7 1936-38 1939-42 All All 1.5 0.7 1936-42 All 4 1.2 X 1936-38 1939 1939 G 1940-42 eaf spring All 92.93,95,97 — 89,90,98 oil spring AIL. 1.6 1.6 0.8 0.7 53. Rear spring, rc-• place one. 1936-37 1938-39 1940-41 AIL: All.. All 1.1 0.5 0.7 1936 1937 1936 1937 1938-42 50,60... 50. All except 50,60 All except 50. All... 1.4 1.4 1.6 1.6 1.4 1936-42 All 1.0 1936-40 1941-42 All. All 1.5 1.2 1936-39 1940-42 All All 1.5 1.2 1936^40 1941-42 All... AIL 1.5 1.2 1936-42 All 2. Ò 1936-42 All 1.5 54. Rear spring cen-ter bolt, replace one. 1936-37 All 0.9 1936-42 Does mov sprii All not include ing and instal ig. 0.8 re-ing 1936-42 All 0.9 1936-40 1941-42 AIL. All 1.6 1.3 1936-39 1940-42 All.. AIL-..:..— 1.6 1.3 1936-40 1941-42 All All 1.6 1.3 • Major engine operations 55. Engine assembly, remove, replace, and tune. Includes removing any parts and accessories such as electrical and fuel equipment, mani-■ folds, fan, etc., and transferring to a stripped engine assembly.' 1941 1942 All All J 6. 5 14.0 - 1936-38 1939 1940-42 All All All 8.5 9.0 10.0 1936-38 1936-38 1939 1939-40 1940-41 1940-41 1942 1942 Indue pain all r driv Six.. Eight Six ..... Eight Six.. Eight Six.... Eight es cleaning ting.- Add 0.7 nodels with o’ e. 12.4 16.7 12.0 15.5 14.9 18.5 13.9 17.5 md on /er- 1936-38 1938 1939 1939 1940-41 1942 Inclu All except 1938 with overdrive. All with overdrive. All without overdrive. All with overdrive. All AIL.. des cleaning ai painting. 12.4 13.1 12.0 12.7 14.9 13.9 ad 1936-38 1939 1940-41 1942 Inclu AIL. AIL. All All des cleaning a painting. 11.8 12.2 14.9 16.2 id 1936-39 1936-39 1940-41 1940-41 1942 1942 1942 1942 Six Eight . Six... Eight ....... Six without Drive- Master. , Six with Drive-Master. Eight without Drive-Master. Eight with Drive-Master. 10.6 12.1 9.0 10.1 9.0 9.8 10.1 10.9 56. Cylinder block and piston as-sembly (or other partial engine assembly as noted under make of car). remove and replace.; Includes tuning engine. Cylino with, pins 1936-38 1939 1940 1940 1941 1942 er crànkcase fi pistons, rings. All All 40,60,80,90.. 50.70 All All,. tted and 29.0 27.5 27.2 29.2 29.2 24.2 Cy cran. 1936 1936 1936 1937-42 1938-40 1941-42 Inclue cleai time and inder block ant cease with pisto 50 60. 70,75 .All V-8 A11V-16 All with Hydra-Matic transmission. es grinding'va ling and adjus r contact poi spark plugs. ns 31.2 33.9 35.9 32.4 49.0 35.8 ves, ing nts, 1936-38 1939 1940-42 All. All All 14. 5 15.0 16.0 1936-38 1936-38 1939 1939-41 1940-41 1942 1942 Indue pain all driv Six — _ Eight.. Six... Eight-. Six. —. Six.. Eight: es cleaning ting. Add 0.7 nodels with o e. 25.0 27.5 24.6 26.3 22.4 20.6 24.5 and on /er- 1936 1936 1937 1938 1938 1939 1939 1940-41 1942 S-l S-2 All All without overdrive. All with overdrive. All without overdrive. All with overdrive. AIL... ...... All 24.5 24.0 24.5 25.0 25.7 24.6 25.3 22.4 20.6 1936-38 1939-41 1942 Inclu AIL. All AIL. des cleaning a painting. 23.0 22.4 23.0 nd Reco All New cylinder assembly All 6-cylinder engines. All V-8engines. nditioned cylino assembly V-8 engines. 6.8 7.9 er 7.0 1936-39 1936-39 1940-41 1940-41 1942 1942 1942 1942 Six. - Eight Six... Eight Six without Drive-: Master. S ill w i t h -Drive-Master. Eight -without Drive-Master. Eight with Drive-Master. 14.1 17.8 15. 5 18.6 15.5 16.3 18.6 19.4 Car make and model GPO—OPA 10901—p. 17 Operation Lincoln K Series and Lincoln Zephyr Nash and Lafayette Oldsmobile Packard Plymouth Pontiac Studebaker Willys Year Model i Hours J Year Model Hours. 1 Year Model 1 Hours J Year Series Hours Year Model J Hours Year Model 1 Hours Year Model 1 Hours Year Model Hours j Engine ? L Remove carbon, 1936-37 Zephyr 9.1 1936-37 10,40,40A... 5.0 1936 Six. w— 5.2 1937-40 120C, 1601, 1936-37 All 6.5 1936 Six —. 4.0 1936-37 Dictator 7.0 1936 All...' 4.3 grind and reface valves. 1938-42 All Zephyr. K series 8.1 11.4 1936-37 1936-37 20 80 6.0 7.0 1936-37 1937 Eight.. Six 6.7 5.7 1941-42 1701, 1801... 1901, 1951, 6.0 1938-39 1940-42 All All. 6.9 7.5 1936 1937-39 Eight--—.. Six 5.2 4.8' 1936-42 1938 President Stud. Six.... 8.5 7.0 1937-42 All..— — 5.S and tune up 1938 10 with vac- 6.8 1938 Six... 5.2 2001........ 6.5 1937-39 Eight 6.0 1938-42 Commander 7.0 engine. uum shift. 1938 Eight 6.2 1940 *1801 7.0 1940 Six.. 4.9 1939-40 Champion.. 6.9 1938-40 10. 5.9 1939 Six... 5.6 1941-42 *1901, *1951, 1940 Eight 6.1 1941-42 Champion.. 7.0 1938-40 1938-40 1941-42 1941 1941 1942 1942 20.. 80 40 60 80.. 60 80— 6.4 7.6 6.7 6.4 7.6 5.7 6.9 1939 1940 1940 1941 1941 1942 1942 Eight....... Six. Eight Six... Eight Six Eight 7.0 5.9 6.9 5.3 6.3 5.0 6.0 1941-42 1937-40 1941-42 1941-42 1940 1941-42 1941-42 1940 1940 1941 1941 1941 1941 1939 *2001 #1901, #1951, #2001 U5C, 1600, 1700, 1800... 1900, 2000-... **1900, **2000 *1800 *1900, *2000.. #1900, #2000.. 1803,1807 *1803, *1807.. 1903, 1907, 2003. 2006... **1903, **1907, ’*2003, **2006 '1903, *1907, *2003, *2006 #1903, #1907, #2003, #2006.. 1703. •With air conditioning. **With fender wells #With Elec-tromatic clutch 7.5 6.8 5.5 5.9 6.1 6.5 6.9 6.2 6.5 7.5 7.0 7.2 8.0 7.3 7.0 1941-42 1941-42 Six., Eight—— % 4.7 5.9 .2. Piston assembly, replace one. 1936-42 Zephyr. All K series. 7.0 6.5 1936-40 1936-40 10,40,40A... 20 5.0 6.6 1936 1936-37 Six.......... Eight 3.2 3.7 1937-42 120C, 1601, 1701, 1801, 1936-39 1940-42 All All. 3.5 4.0 1936-38 1936-39 Six — Eight 4.0 4.4 1936-37 1936-40 Dictator.— President 2.8 3.3 1936-42 All 2.0 No honing or lapping . included. Does not include reconditioning cylinder bore. Indue and re es cleaning oil placing gasket pan 1936-40 1941-42 1941-42 1941-42 80 40 60 80 7.2 5.4 5.0 6.5 1937 1938 1938 1939-42 1939-42 Six....... Six.... Eight Six. Eight 3.5 3.2 3.5 3.7 4.4 1941-42 1942 1942 1937-42 1941-42 1940-42 1941-42 1939 1901, 1951... #1901. #1951, #2001 2001 4.. #2001 ... 115C, 1600, 1700, 1800, 1900, 2000... #1900,#2000.. 1803, 1807, 1903, 2003, 2006 #1903, #1907, #2003, #2006. 1703 #With Elec-tromatic clutch 3.0 3.3 3.3 3.6 2.8 3.1 3.6 3.9 5.6 Include s removing car bon. 1939 1940 1940 1940 1941-42 1941-42 Six. — Six... 28—• 29 Six.. Eight 3.8 3.9 4.4 5.0 3.7 4.8 1938 1938-40 1939-40 1941-42 1941-42 Studebaker Six. Commander Champion.. Champion & Commander. President 2.8 2.8 3.0 3.1 3.6 Car make and model GPO—OPA 10901—p. 18 Operation Lincoln K Series and Lincoln Zephyr Nash and Lafayette Oldsmobile Packard Plymouth Pontiac Studebaker Willys • Year Model 1 Hours j Year Model 1 Hours Year Model ! smou Year Series Hours j Year Model j Hours j Year Model j Hours . Year Model Hours Year Model I Hours j Engine 3. Piston assembly, replace each additional one when done in connection with Operation No. 2. No honing or lapping included. Does not include reconditioning cylinder bores. 1937-42 1939 120C, 1601, 1701, 1801, 1803, 1807, 1901, 1903, 1951, 2001, 2003, 2006, 2008, 115C, 1600, 1700, 1800‘, 1900, 2000—.— 1703 0.5 0.8 1936-42 All 0.8 1936-42 All 0.5 4. Pistons, rings, and piston pins, replace all. Does not include reconditioning cylinder bores. 1936-42 AD... Zephyr K series..... 11.0 12.5 1936-42 Indue nect AU es aligning ng rods. 5.5 con- 5. Piston rings, standard, re-placeaU. Does not include 1936-42 Zephyr „ K series es removing cleaning oU oil pump. 10.0 1936-40 1936-37 1936-37 1938-40 10,40,40A... 20 80. 20 7.4 See 1937-42 il20C, 1601, 1701, 1801, 1901, • 1951, 2001 See Operation No. 6 1936-38 Six 5.6 1936-37 Dictator.... 6.2 1936-42 All 4.5 All... Incluc 11.0 3ar-oan 8.3 8.7 8.7 7.8 1936-39 1939 1940 Eight Six Six 6.8 5.4 5.5 1936-40 1938 President... Studebaker Six. 8.0 6.2 Indue nect es aligning c ing rods. on- reconditioning cylinder bores. and 1938-40 1941-42 1941-42 1941-42 80 40 60 80 9.1 8.6 8.9 9.2 1941-42 1940-42 1941-42 1937-42 1941-42 #1901, #1951, #2001..—... 1803, 1807, 1903, 1907, 2003, 2006... #1903, #1907, #2003, #2006, #2008 115C, 1600, 1700, 1800, 1900, 2000... #1900, #2000.. #With Elec-tromatic clutch 8.1 8.4 8.7 6.8 7.1 1940 1940 1941-42 1941-42 Inclue bon, plug com ings 28 29 Six. Eight....... es removing cleaning sp s, and replac eecting re>d b if necessary. 6.8 7.4 5.3 7.2 car-ark ing ear- 1938-40 1939-40 1941-42 1941-42 Commander Champion.. Champion and Commander. President... 6.2 6.4 6.5 8.2 6. Piston rings and connecting rod bearings, replace all. Does not include reconditioning cylinder bores. 1936-42 All... Zephyr. Kseries 12.4 13.4 J. 1936 1936-37 1937 1938 1938 1939-42 Six........— Eight Six...— Six.. Eight Six— Eight.. es removing and cleaning si s. 5.0 6.4 5.2 5.0 6.1 5.5 1936-39 1940-42 All AU >- 5.0 6.2 1936-38 1936-39 1939 1940 1940 1940 Six Eight Six.... Six. 28 29., 5.6 6.8 5.4 5.5 6.8 7.4 1939-42 Indue bon Plug 7,0 car-ark 1941-42 1941-42 Indud ande Six Eight es removing car leaning spark p 5.3 7.2 jon ugs. 7. Connecting rod, replace one. Includes removing and Installing or replacing piston pin. 1936-37 1936-37 1936-37 1938-39 1938-42 10,40,40A... ‘20. 80 10 .20,60 2.6 4.0 5.4 3.3 4.4 1936 1936 1937 1937 1938 Six Eight Six Eight...—.. Six 2.9 1.6 3.2 3.4 2.9 * 1936-39 1940-42 AU.... AU 2.7 3.2 1936-38 1936-39 1939 1940 1940 Six Eight .Six ..... Six 28 3.7 4.1 3.5 3.6 4.1 -- 1936-42 AU 3.0 1938-40 1940 1941-42 1941-42 Indue inst repl ket; stall rem 80 10 40 80........... es removing dling oil pan, acing oil pan removing and ing cylinder he oving carbon. 6.0 3.8 5.6 5.9 and and gas-in- :ad; 1938 1939-42 1939-42 Eight Six........— Eight 3.2 3.4 4.1 1940 1941-42 1941-42 29 Six Eight 4.7 3.4 4.5 — Car make and model GPO—OPA 10901—p. 19 Operation Lincoln K Series and Lincoln Zephyr .Nash and Lafayette Oldsmobile Packard Plymouth Pontiac Studebaker Willys Year Model Hours I Year Model ! Hours j Year Model I Hours Year Series Hours Year Model | Hours Year Model 1 Hours Year Model • 1 Hours j Year Model Hours j Engine 8. Connecting rod, replace each additional one when done in connection with Operation No. 7. 1936-40 1941-42 All 0.8 0.6 1936-42 All 0.3 1936-39 1940-42 All 0.5 0.7 1936-42 All..., 0.5 All All -* 9. Connecting rods, replace all. Includes. removing and installing, or replacing, piston pins. 1936 1936 1937 1937 1938 1938 1939-42 1939-42 Six 4.4 3.7 4.6 5.5 4.4 5.3 4.9 6.2 1936-39 1940-42 All 6.0 6.5 1936-38 1936-39 1939 1940 1940 1940 1941-42 1941-42 Six..... 6.2 7.6 6.0 6.1 7.6 8.2 5.9 8.0 1936-42 AH.. 5.0 and 8 Eight Six ... Eight Six Eight Six... Eight AH— Eight Six Six... 28 29 Six. Eight 10. Connecting rods, piston rings, and piston pins, replace all. Does not include reconditioning cylinder bores. • 1936 1936 1937 1937 1938 1938 1939-42 1939-42 Six Eight Six Eight....... Six Eight — Six Eight 5.6 5.3 5.8 7.1 5.6 6.9 6.1 7.8 11. Main bearings, adjust all. 1936-42 All 3.5 12. Main bearings, replace all. 1936-42 Incl pan ar not a integri (poure Zephyr udes cleaning d oil pump. D pply to beari il with bl Kl) 5.0 oil oes ngs ock 1936-38 1936-38 1939-42 1939-42 Six. Eight. Six. Eight 2-9 3.3 3.4 4.4 1937-42 1940-42 1937-42 120C, 1601, 1701, 1801, 1901, 1951, 2001—- 1803, 1807, 1903, 2003, 2006 115C, 1600, 1700, 1800, 1900, 2000... Includes removing and installing oil pan. 3.5 5.4 3.0 1936-38 1936-39 1939-42 1940 1940 1941-42 Six Eight Six 28 , 29 Eight 4.1 4.5 3.9 4.5 5.2 5.2 13. Main bearings, connecting rod bearings, and crankshaft, replace all. 1936-42 All... Inclut inst ing pun: Zephyr K series es removing illing engine, c oil pan and P- 10.5 34.0 md ean- oil 1936-39 1936-39 1937-39 1937-39 1940-42 1940-42 1940-42 1940-42 Six, Syncro-Mesh transmission. Eight, S.-M. tr. Six, Automatic tr. Eight, Automatic tr. - Six, Syncro-Mesh tr. Eight, Syncro • Mesh tr. Six, Hydra-Matic tr. Eight, Hydra-Matic tr. 12.0 13.0 13.0 14.0 11.2 12.5 12.7 14.0 1937-42 1937-42 1940-42 120C, 1601, 1701, 1801, 1901, 1951, 2001 115C, 1600, 1700, 1800, 1900, 2000.. 1803, 1807, 1903, 1907, 2003, 2006, 2007 16.6 16.0 17.9 Repl nectin 1936-38 1939 1940-42 Replai ned • cran mot engi 1936-38 1939 1940-41 1942 ice main and cc g rad bearings o All All—- All :e main and ng rodbearinge '1803, 1807, 1900, 1901, 1903, 1951, 2000, 2001, 2003, 2006, 2008 0.4 0.5 1936-42 All 0.7 1936-42 All 0.4 1936-37 1938 1938-42 1938-42 1939-42 All 0.5 0.5 0.5 0.4 0.6 1936-42 All ft 5 K series All Studebaker Six. Commander President-. -Champion... All. 1703 Clutch 26. Clutch, adjust at pedal. 1936-42 All... 0.9 0.3 1941-42 40 0.3 \. ' 1 .... 1937-42 115C, 120C; 1600; 1601, 1700, 1701, 1703, 1800, 1801, 1803, 1807, 1900, 1901, 1903, 1951, 2000, 2001, 2003, 2006 0.2 1936-42 All 0.5 1936-42 All 0.3 K series.... - Car make and model GPO—OPA 10901—p. 23 Operation Lincoln K Series and Lincoln Zephyr Nash and Lafayette Oldsmobile Packard Plymouth Pontiac Studebaker WUlys Year Model ! Hours Yéar Model 1 Hours Year Model Hours Year Series Hours Year Model I Hours Year Model | Hours Year Model CO 3 e » Year -Model | Hours Clutch 27. Clutch disc, discs, or clutch-driven plate, renew facings. Includes removing and installing disc, discs or plate. To th Ope the 1936-40 1941-42 e time shown ration No. 28 following: All. All for add 0.5 0.7 1936-38 1939 1940-42 • All 3.9 3.3 3.1 • 1936 1937-38 1938 1939-42 All 4.2 37 4.1 2.8 Cari 1936 1936 1937 1937 1938 1939-40 1939-42 1941-42 Ca 1938 1939 1939-40 1940 1941-42 1941-42 1940-42 without overdri Dictator President Dictator President AH Commander and President. Champion. Commander and President. with ot>erdrit>( AU President and Commander. Champion.. President. — Champion.. President... Commander >e ' 3.5 3.8 3.8 4.0 3.5 3.5 2.9 3.4 3.8 3.8 3.9 3.6 3.2 3.9 3.8 1936-42 AH 0.5 • All All. All with conventional gear shift. All with safety shift. All 28. Clutch disc, discs, or clutch driven plate, replace all. 1936-40 1938 To ab nece and pane nece and supr pane 1941-42 1941-42 All except 1938 with vacuum shift. All with vacuum shift. jve add 1.0 wl ssar-y to rem replace front fl is. Add 2.0 wh ssary to rem replace rear mo ort and front fl Is. 40 60,80. 2.8 4.3 ere ove oor ere ave tor oor 2.7 2.9 1936-38 1937-39 1939-40 1941-42 All with Syncro-Mesh transmission. Ail with Au-tomatic transmission. All with Syn-cro-Mesh transmission. All with Syncro-Mesh ' transmission. 2.1 3.1 2.0 1.9 1936-38 1939 1940-42 All 3.0 2.4 2.2 1936 1937-38 1938 1939-42 All.... 3.5 3.0 3.4 2.1 Càr 1936 1936 1937 1937 1938 1939-40 1939-42 1941-42 Car 1938 1939 1939-40 1940 1941-42 1941-42 1940-42 s without overd Dictator.... President... Dictator. President... All Commander & President. Champion.. Commander & President. s with overdrive All President & Comman -der. Champion.. President... Champion.. President... Commander rive: 3.1 3.4 3.4 3.6 3.1 3.1 2.5 3.0 3.4 3.4 3.5 3.2 2.8 3.5 3.4 1936-42 AU 4.5 All. AU AU with conventional gear shift. All with safety shift. AU 29. Clutch release bearing, replace. 1936-40 1938 To ab< nece and pane nece rear and 1941-42 1941 All except 1938 with vacuum shift. All with vacuum shift. ve, add 1.0 wh ssary to rem< replace' front fl Is. Add 2.0 wh ssary to repl motor supp ront floor pan All except 1941 60,80 convertible. 60,80 convertible. 2.3 3.8 ere jve oor ere ace ort els. 2.3 2.6 1936-38 1937-39 1939<) 1941-42 All wi t h Syncro-Mesh trans-mission. All with Automatic trans-mission. All with Syncro-M e s h Trans-mission. All with Syncro-M e s h Trans-mission. 1.7 ? 7 1.6 1.5 1936-38 1939 1940-42 All 2.7 2.4 1.8 1936 1937-38 1938 1939-42 Inclu elute nece AU .. 2.8 2.3 2.7 1.7 ng if 1936-42 AU 3.5 All All All with co nven-tional gear shift. All with safety shift. AU.... des i:eplac h release yok ssary. GPO—OPA 10901—p. 24 Car make and model Operation Lincoln K Series and Lincoln Zephyr Nash and Lafayette Oldsmobile Packard Plymouth Pontiac Studebaker WUlys Year Model [ Hours ; Year Model ! Hours Ì Year Model I Hours Year Series Hours 1 Year Model Hours i Year Model Hours Year Model Hours I Year Model Hours 1 Clutch 30. Clutch, overhaul completely. Includes removing and installing clutch assembly. 1936-42 1938 Add 1 rem fro 2.0 i mov rear and All except 1938 with vacuum shift. All with vacuum shift. .0 if necessary ove and repls nt floor pane necessary to e and repla motor suppt front floor pane 3.7 5.2 to ice Is, re-ce >rt Is. 1936-38 1937-39 1939-40 1941-42 All with S yncro-Mesh trans mission. AU with Au-tomatic transmission. All with Syncro-Mesh transmission. All with Syncro-Mesh transmission. 3.0 4.0 2.9 2.8 1936-38 1939-42 All 4.2 3.6 1936 1937-38 1938 1939-42 All 3.8 3.3 3.7 2.3 1936-42 All .. 5.5 All AU with conventional gear shift All with safety shift. AU Transmission 31. Transmission, overhaul. Includes removing and installing. Where necessary io re* Where transmission is Syncro- Mesh transmis sion 1937 1938-42 1941-42 1939 Trant 1939-42 1941-42 1939 115C, 120C.. 1600, 1601, 1700, 1701, 1800, 1801, 1803, 1900, 1901, 1903, 1907, 1951, 2000, 2001, 2003, 2006, 2008..-. . 4.2 5.0 5.7 5.5 ero 6.8 7.5 7.3 1936-38 1939 1940-42 \\ All 5.5 5.2 4.2 1936 1937-38 1938 1939-42 AU 5.3 4.8 5. Ò 4.1 Cars 1936 1936 1937 1938-40 1941-42 1941-42 1941-42 Car 1936 1936 1937 1938 1939-40 1939-40 1941-42 1941-42 1941-42 without overdr Dictator.... President... AU ve: 4.1 3.9 4.1 3.0 3.0 3.3 2.8 4.5 4.3 4.5 3.9 4.3 4.0 4.0 4.3 3.9 1936 1937-42 All 5.0 6.0 move engine from chassis: 1936-421 Zephyr 1 7.6 All 1 K series....! 13.0 Add 0.9 in all cases where necessary to remove oil 'pan. Includes overhauling clutch. Where unnecessary to remove engine from chassis: detached from clutch housing: All All with conven-tionalgear shift. All with safety shift. All AU 1936-38 1939-40 1941-42 Aula Ma 1937-39 1940-42 All All AU malic and Uy dr lie transmissior 3.5 4.2 4.1 a- 7.7 11.0 All 1936-40 1941-42 All 6.0 5.5 is itch 7.0 AU. Where transmission integral with clt housing: 1936-40| All Exceptions: Champion.. .Commander. President... ; with overdrive Dictator..’.. President... AU 1938 All with #1900, #1901, #1903, #1951, #2000, #2001, #2003,#2006, #2008 1703. vacuum ’ shift. 1941 All convertible models. 7.6 re-apule 1936-42 All Where remo chast gine remo 1936-42 All Inclu clut pum oil I Zephyr K series unnecessary ve engine f is but where oil pan must ved: Zephyr K series des overhaul ch, cleaning P and replae an gaskets. 5.5 5.5 to om en- • be 9.5 8.5 ing oil ing AU Champion.. Commander and President. Champion.. Commander. President... Where mov port shov add 0.3 to appropriate time shown above. necessary to e rear engine s add 1.0 to ti tn above. #With Elec-tromatic clutch. mission and A Drive 1700, 1701, 1800, 1801, 1803, 1807, 1900, 1901, 1903, 1951, 2000, 2001, 2003, 2006, 2008 #1900, #1901, #1903, #1951, #2000, #2001, #2003, #2006, #2008 ' 1703 Vnitersals 32. Universal, front or single, overhaul. Includes removing and installing. 1936-42 AU Zephyr 3.0 4.8 On ca rs with saline at 1936 1937-38 1939 1939-42 AH .. 0.7 1.1 1.1 0.9 1937-42 115C, 120C, 1600, 1601, 1700, 1701, 1703, 1800, 1801, 1803, 1807, 1900, 1901, 1903, 1907, 1951, 2000, 2001, 2003,2006... 1.0 1936-42 All 1.2 1937-42 All.. 0.9 K series. front end of propeller 1936 1937 1938-40 1941-42 AU with Au-tomatic transmission. All except 1939 with Automatic transmission. 0.8 0.8 0.6 snaji. 1936-401 All | 1941-421 60,80 J On cars without spline front end of prope shaft. 936-401 All 1.4 1.2 at 1er 1.7 President All.... All Car make and model GPO—OPA 10901—p. 25 Operation Lincoln K Series and Lincoln Zephyr Nash and Lafayette Oldsmobile Packard Plymouth Pontiac Studebaker WUlys Year Model J Hours 1 Year Model 1 Hours | Year Model | Hours Year Series 1 Hours 1 Year Model | Hours Year Model 1 Hours j Year Model [ Hours 1 Year Model I Hours j Universals 33. Universal, rear, overhaul. Includes removing and installing. On ca rs with solini at 1936 1937-38 1939 1939-42 All 0.7 0.9 0.9 0.7 Same as Operation 32. 1936-42 All 1.2 1937-42 All 0.9 1936 1937 1938-40 1941-42 Pin beating type AU 0.7 0.7 0.7 0.6 front end of propeller shaft. All .. All with Au-tomatic transmission. All except 1939 with Automatic transmission. President -.. AU 1936-40 1941-42 All- 60,80 il AU On cars without spline at front end of propeller shaft. 1936-40 AU 1.4 Rear axle 34. Rear axle assembly, overhaul. Includes removing and installing. 1936-37 1936-37 1938-42 1938-42 All Zephyr without overdrive. Zephyr with overdrive. Zephyr without overdrive. Zephyr with overdrive. K series 7.0 9.0 4.5 6.5 7.6 1936-42 AU... 7.2 35. Rear axle shaft, replace one, where not necessary to remove differential assembly. Does not include replacing broken axle shaft where necessary to remove rear axle housing cover and opposite * axle shaft. Wheels 36. Rear wheel bearing, replace one. 37. Front wheel bearings, inner and outer, replace one side. 38. Front wheel bearings, adjust. Includes removing and installing wheels, cleaning and repacking bearings, both sides. Models without fuU-float- 1936 1937-42 AIL. '. ... 1.1 0.8 1937 1938-42 115C, 120C-. 1600, 1601, 1602, 1700, 1701, 1702, 1703, 1705, 1800, 1801, 1802, 1803, 1805, 1807, 18C8. 1900, 1901, 1903, 1905, 1907, 1908, 1951, 2000, 2001, 2003, 2004, 2006, 2008.. 1.0 1.1 1936-42 1936-42 AU 1.3 1.3 1936 1937-42 1936 1937-42 1936-42 1936-42 AU 0.9 0.8 1.1 O.8 0.6 0.5 » 1936-42 1939-42 All except Champion. Champion.. 1.2 1.1 1936-42 1936-42 1936-42 All 0.8 0.8 0.5 * ' — All AU All All 1936-42 All... Model rear 1936-42 AU... 1936-42 Add bear in re Zephyr K series with full-floa axles. Zephyr K series All 5.0 0.8 ing . 5.6 5.6 All 1936-42 1936-42 All 0.6 0.5 1937-42 1937-42 All but V-12 and 1937 1500 series All but V-12 and 1937 1500 series... 0.6 0.5 All 1936-42 1936-42 AU. 0.3 0.3 ing cup or sie ar hub. eve AU 1936-42 All... 0.5 0.7 1936-42 A]1 0.5 All 1936-39 1940-42 All. 0.6 0.7 AU AU K series h ♦ AU GPO—OPA 10901—p. 2« Operation Car make and model Lincoln K Series and Lincoln Zephyr Nash and Lafayette Oldsmobile Packard Plymouth Pontiac & Studebaker Willys Year Model Hours I Year Model ! Hours Year Model 1 Hours i Year Series Hours j Year Model j Hours Year Model I Hours Year Model j Hours j Year * Model Hours Wheels 39. Wheels, changing from front to rear, rear to front, or from one side to the other. Time shown per •wheel. ....... All models.. 0.1 Ail models.. di All models.. 0.1 All models.. 0.1 » All models.. 0.1 All models.. 0.1 All models.. 0.1 All models.. I 0.1 iVoni axle and steering 40. King pin and/ or king pin bushings or bearings, replace all, both sides. 1936-42 All... Zephyr 2.5 3.0 1941-42 60.80 2.0 1936-42 All 2.1 1937-42 Inclu toe 115C, 120C, 1600, 1601, 1700, 1701, 1703, 1800, 1801, 1803, 1807, 1900, 1901, 1903, 1907, 1951, 2000, 2001, 2003, 2004, 2006, 2008. des adjusting or 4.1 • 1936 All 2.2 <1936 1937-42 All . 3.0 2.O' K series..... Includes adjusting for Includes adjusting Enclosed knee suspen- All toe-in for c toe-i aster, camber n. and 7,193-4 Inc 51071 2 AILr.. ludes adjusting for toe-in. . 2.0 41. Steering knuckles. re-bush both sides, and-replace king pins,, if necessary. 1936-39 1940-42 All 2.8 3.4 1936-42 Inclut cast» toe-i All 3.5 for and 1936-42 Inclut and and All 3.6 eels ake 1937-39 1940-42 Inc All 3.4 2.0 1936-38 1939-40 1939-40 1941-42 1941-42 All 2.7 2.4 2.7 2.5 2.8 1936 1937-42 All 4.0 3.0 "1.0 All except 40. es adjusting sr, camber n. es aligning wh adjusting br ors. All ludes adjustin: for toe-in. Champion. ; Commander and President. ) Champion.. Commander and Presi-■ dent. All 42. Steering tie rod. • and/or tie rod ends, replace both sides and align wheels. 1936-42 All... Zephyr K series..... 1.6 2.0 1936-42 All 1.3 Tie rods onto 1936 1937-38 1939-12 All All 0.8 1.3 1.2 1936-42 All 1936-42 f. 1936-38 1939-42 Each 1936-42 All >ne lie rod end AIL... All additional tie r end All.......... 1.4 1.0 0.8 'd 0.2 All 43. Steering drag link ball sockets, replace all. 1936-42 All... Zephyr K series...... 0.6 1.3 44. Steering knuckle assembly, replace one. 1936-42 All .. Includ töe-: Zephyr 1.5 2.0 for 1936-39 1940-42 1941-42 All 1.1 1.3 1.5 1936-42 All.... 1.4 1937-42 1941-42 115C, 120C, 1600, 1601, 1700, 1701, .1703, 1800, 1801, 1803, ' 1807, 1900, 1901, 1903, 1907, 2004, 2008..’ 1951, 2000, 2001; 2003, 2006. 2.0 1.5 1936-38 1939-42 Includ anch whet brak All 1.9 2.1 ake ing ing 1937-42 All 1.3 1936-37 1936-37 1938 1938-40 1939-40 1941-42 1941-42 3A, 5A 1.2 1.3 12 1.2 1.0 1.1 1.3 1936-42 All 1.0 K series es adjusting n. All except 40. 40 All es adjusting br or bolts, align *ls, and bleed e lines. 4A.6A, 2C, 3C. Studebaker Six. Commander & President. Champion.. Champion. ‘ Commander & President. GPO—OPA 10901—p. 27 Operation Car make and model Lincoln K Series and Lincoln Zephyr Nash and Lafayette Oldsmobile Packard ft Plymouth Pontiac Studebaker Willys Year Model Hours Year Model I Hours Year Model J Hours 1 Year Series 1 Hours 1 Year Model 1 Hours Year Model Hours Year Model 1 Hours Year Model 1 Hours 1 Brakes 45, Service brakes, minor adjust-, ment only. 1936-42 All... 0.5 0,8 All UR 1QM-49 All 0 k 1937-42 All but V-12 and 1937 , 1500 series 0.6 1936-42 All 0.5 1939-42 AU 0.5 1936-42 All 0.6 1936-38 1939-42 All 1.0 0.5 K series r- 'Includes adjusting brake pedal and checking fluid level- Adiustine brake shoe Includes filling master All lien raster cylinder cam s only. cylinder. 46. Service brakes, all four, adjust completely, free and tighten linkage, fill master cylinder, and bleed lines. 1936-42 1936-42 All... Zephyr with rod or cable control. Zephyr with hydraulic • control. K series...... 1.2 1.0 2.7 1936-42 Inclue repa bear inch AIL... es adjusting eking front wl ings. Does ide bleeding lii 1.6 md leel not íes. ' 1936-42 All 1.7 1937-42 All but V-12 and 1937 1500 se- 1.7 1936-42 All 2.0 1936-41 AU„ 1.6 1936-42 All 2.3 1936-38 1939-42 AIL. E5 1.0 Does not include bleeding lines and filling master evlinder. All 47. Service brakes, bleed hydraulic system, all four wheels, ' and add fluid. All with hydraulic control. 0.8 1936-42 1941-42 All except 1941-4240. 40 0.9 0.7 1936-42 All 0.7 1937-42 All but V-12 and 1937 1500 set .0.7 1936-42 All 0.5 1936-42 All, 0.7 1936-42 AU 0.7 1939-42 All 1.5 48. Service brakes, reline all four and adjust. Includes removing and instaling shoes. 1936-42 Inclu blee mas adjt All... 4.0 ng, ing md lai. 1936 1937-42 All. 3.6 3.2 1937-42 Inclu fror All but V-12 and 1937 1500 series des re-packir it wheel bearin 3.8 rg gs 1936-42 Inclut ant AIL. es bleeding li adding fluid. 4.3 nes 1936-42 All 3.1 1936-38 1939-40 1939-12 1941-42 AU 4.3 4.3 4.1 4.4 1937-42 All. 4.3 des adjust ding lines, ill ter cylinder sting brake pe All Commander and President. Champion.. Commander and President. 49. Brake shoes, re-' place all four, and adjust brakes completely. 1936-38 1939-42 ah..: Zephyr with rod o r cable control. Zephyr with hydraulic control. K series..... 2.0 1.8 3.5 1936-40 1941-42 Indue ant All 4.1 3.1 nes 1936 1937-42 Inclue parki 2.6 2.2 ng es. 1937-42 Inclu fror All but V-12 and 1937 1500 series. des re-packi it wheel bearir 2.9 ig gs 1936 42 Inclut an AIL es bleeding li d adding fluid 3.1 nes 1936-42 All 2.2 1938 1939-40 1939-42 1941-42 AU 3.0 3.0 2.8 3.1 1936-42 V All 3.5 All AU„ Commander and President. Champion.. Commander and President. es bleeding 1 adding fluid es lubricat ng brake cabl 50. Brake hydraulic master cylinder, overhaul. Includes removing and installing. All with hydraulic control, es bleeding lii 1.4 íes. 1936-42 All . 2.0 all 1936-42 All 1.6 1937-42 All but V-12 and 1937 1500 series. 1.4 1936-38 1939 1940 1941 1942 All 1.9 2.6 3.2 2.1 2.8 1936-42 All 1.6 1936-42 AU 1.4 inclue All All All lines and adjusting brake pedal. Includes bleeding' lines. All 51. Brake pedal, adjust for proper clearance. All with hydraulic control. 0.9 1936-42 All. 0.2 1937-42 All but V-12 and 1937 1500 series. 0.2 1936-42 AU 0.3 1936-42 All 0.2 Springs 52. Front spring, replace one. 1936-42 All... Zephyr 1.5 2.0 1936-39 1936-39 1940 1941-42 1941-42 Leaf spring 10,20,40,40A 80 1.1 1.2 0.6 1.5 1.0 1936-42 All 0.5 1937-42 1941-42 115C, 120C, 1600, 1601, 1602, 1700, 1701, 1703, 1800, 1801, 1803, 1804, 1807, 1900, 1901, 1903, 1904, 1907, 2004, 2008. 1951. 2000, 2001, 2003, 2006, 2020, 2021, 2023. 1.5 0.6 1936-38 1939-42 AIL 1.5 0.7 1936 1937-42 Leaf spring All 0.9 0.5 1936-37 1936-37 1938 1939 1939-40 1940 ' 1941-42 1941-42 3A,5A 1.7 2.1 2.2 2.2 1.4 2.1 1.5 2.2 1936-42 All 1.0 K series....*. AU Coil spring All 4A, 5A. 2C, 3C. AU Commander and President. Champion.. Commander and President. Champion.. Command-e r and President. Coil spring AIL. 40 60,80 Operation Car make and model Lincoln K Series and Lincoln Zephyr Nash and Lafayette Oldsmobile Packard Plymouth Pontiac Studebaker Willys Year Model 1 Hours 1 Year Model | Hours Year Model 1 Hours 1 Year Series 1 Hours J Year Model 1 Hours J Year Model | Hours Year Model Hours Year Model 1 Hours J Springs 63. Rear spring, replace one. 1936-42 All . 2.0 1936-42 Leaf spring AIL. 1.6 1936-38 1939 1940 1941-42 All 1.0 0.9 1.1 1.4 1937-42 115C, 120C, 1600, 1601, 1700, 1701, 1703, 1800, 1801, 1803, 1900, 1901, 1903, 1951, 2000, 2001, 2003, 2006, 2008. 1.4 1936-40 1941-42 All 1.5 1.2 1936-42 All 1.0 1936 1936 1937-38 1939 1939-42 1940-42 Dictator.... President... All 1.1 1.5 1.1 1.1 0.6 0.7 1936-42 All 1.3 All All cou spring All. 1941-42 40 0.5 All Commander and President. Champion.. Commander and President. 54. Rear spring center bolt, replace one.- 1936-38 Rear 1939-42 Rear 1939-42 Rear 1936-38 1939-40 All 0.8 nt, 0.3 nt, 0.2 olt 0.5 0.4 1937-42 All but V-12 and 1937 1500 series. 0.5 1936-40 1941-42 Indue ins All 1.6 1.3 md 1936-42 All 0.8 1938 1939-42 1939 1940-42 All 1.2 0.7 1.2 0.8 1936 1937-42 All 0.8 1.0 'spring damp be upper All spring damp bt lower — spring axle U-t All Champion... Commander and President. Commander and President. All es removing tailing spring. Major engine operations 55. Engine assembly, remove, replace, and tune. Includes removing any parts and accessories such as electrical and fuel equipment, manifolds, fan, etc., and transfer- 1936-40 10, 20, 40, ' 40A, ex- 10.5 1936-39 1940-41 All —. 11.5 12.4 1937-41 115C, 120C, 1600, 1601, 14.5 1936-38 1939 All 11.8 11.2 1936 1937-38 All 11.1 11.0 1936-37 1936-37 Dictator.... President... 10.6 12.0 All with All All 1936-40 1938 cept 1938 10,20 with vacuum shift. 80, except 1938 80 with vacuum shift. 10, 20 with Vacuum 11.0 12.5 1940-41 1942 Syncro-M e s h transmission. All with Hydra-Matic transmission. All w i t.h 14.0 9.2 1939-42 1941-42 1942 1700, 1701, 1800, 1801, 1900, 1901. 1703, 1803, 1807, 1903, 1907, 2004, 2007. 1951, 2001. 2003, 2006. 2000 17.5 12.5 12.0 1940-41 1942 Includ pain All All 14.9 13.5 and 1939-40 1941-42 All All 10.7 10.9 1938 1938-42 1939-42 1938-42 Studebaker Six. Commander Champion.. President... 8.8 8.8 8.7 9.5 es cleaning ting. r i n g t o a stripped engineassembly. 1938 1941-42 1941-42 shift. 80 with vacuum shift. 40, 60 13.0 12.5 13.5 1942 Sy ncro-M e s h transmission. All with Hydra-Matic transmission. 10.8 801 GPO—OPA 10901—p. 28 Car make and model Operation Major engine operations 56. Cylinder block and piston assembly (or other partial engine assembly as noted under make of car), remove and replace. Includes tuning engine. Line L Year New ioaa-42 oln K Series ai incoin Zephyr Model cylinder assemt Zpnhvr I Hours I Ì 3 I 1 I Nas Year ti and Lafayetl Model ,e CO o « Year 1936-39 1936-39 194Ö-41 1940-41 1940-41 1940-41 1942 1942 1942 1942 Indue Oldsmobile Model Six Eight ta S o 23. q 24.5 24.5 25.5 27.0 28.0 21.2 22.2 23.5 24.5 ves. Year Cylino with chan 1939 Packard Series er block (regrou pistons (on ge) 1703 NJ ’S | i g *? Ä 1 Hours j Year 1936-38 1939-41 1942 Infilili Plymouth Model All CO S o M 23.0 22.4 21.0 md Year Partia fittea cran and 1936 1936 1937-38 1937-38 1939-40 1939-40 1941-42 1941-42 Pontiac Model ! engine assert with pistons, r kshaft, camsh valves. Six tn Ö Q n ibly ods, aft, 14.8 15.2 14.7 15.1 14.2 14.8 14.4 14.9 Year 1936-37 1936-37 1938 1938-42 1939-42 1938-42 Studebaker Model Dictator.... President... Studebaker Six. Commander 'Champion.. President... co 3 O M 18.9 23.5 15.6 15.6 15.6 18.5 Year Willys Model 1 j Hours I j ’ Includes washing engine, grinding valves, and All Eight....... Six with Syncro-Mesh transmission. ' Six with Hydra-Matic transmission. Eight with Syncro-Mesh trans-mission. Eight with Hydra-Matic transmission. Six with Syncro-Mesh trans-mission. Six with Hydra-Matic transmission. Eight with Syncro-Mesh t r a n s -mission. Eight with Hydra-Matic-t r a n s -mission. es grinding va All Six 1936-42 assembly " All 10.0 reme iving carbon. es cleaning Eight....... nainting. Six Eight Six Eight GPO—OPA 10901—p. 29 STATEMENT OF THE CONSIDERATIONS INVOLVED IN THE ISSUANCE OF SUPPLEMENTARY SERVICE REGULATION 49 TO RMFR 165 Automotive repair service labor charges are characteristically priced upon the basis of the time required for performance of a given, operation. Repair shops usually price either upon the basis of time used on individual jobs or upon the basis of time-studies for given operations as listed in flat rate manuals or labor schedules. Such shops (with minor exceptions) bill their customers for labor by multiplying their customer’s hourly rate by the actual hours of time or by the hours of time set forth in the manual or schedule. To the extent that “actual” time (as distinguished from time specified in a flat rate manual or labor schedule) has been used as the basis for pricing automotive repair services, adequate compliance with the services regulation has not been secured. In many such cases, consumers have been charged for more time than was usedi The accompanying regulation is calculated to check this practice insofar as many standard operations are concerned, while at the same time recognizing a pricing method long familiar to the automotive repair trade as reflected in the use of flat rate manuals or labor schedules for standard operations. The regulation limits the time for which a customer may be charged for certain common automotive repair services for specified makes of automobiles. The listed operations correspond to those customarily used in the trade, excépt for such minor changes as are required for uniformity. The time allowances follow as closely as possible those determined in the base period by the automobile manufacturers to be generally adequate for the performance of the operations.' These allowances, in the Administrator’s opinion, are representative of the times customarily required to complete the. operations specified, and when ap plied to customer’s hourly rates established for individual repair shops under the services regulation, will result in priées which are generally fair and equitable. In any case where a person has a fixed (dollars-and-cents) charge for an operation listed in the regulation, he must compare that charge with the one resulting from multiplication of his customer’s hourly rate by the time specified in the regulation. He must then charge no more than the lower of the two figures for that operation. If any person supplying a service listed in the regulation has not established a customer’s hourly rate, he must apply to OPA under Section 5 of RMPR 165 for the establishment of such a rate, to be used in determining a price for that service. The regulation also requires persons supplying any of the specific, services listed therein to give their customers informative invoices. A salient feature of this provision, and of the regulation generally, is that a practicable means will for the first time be afforded the customer to ascertain the correctness of charges for automotive repair work. The average customer is unfamiliar with the technicalities of automotive repair work and has little knowledge of the manner in which it is priced. The regulation will help to remedy a condition which has hitherto constituted a marked impediment to price control. It is contemplated that other standard operations will be added to the list which appears in the regulation in order to make it an ever more effective instrument of price control. The regulation requires continuance of a seller’s previous pricing practices as authorized by RMPR 165, For example, , he must adhere to his base period pricing policy, if fie had one, of giving discounts or price differentials; he must re tain his pricing policy as far as multiple operations are concerned; etc. Automotive repair services not listed in the regulation continue to be priced under RMPR 165. With respect to such services the regulation specifies the information to appear on the sales slip or receipt if a customer requests one; and it also provides that if a flat rate manual or labor schedule is used to price the service, the manual or schedule must on request be made available for the customer’s inspection. All provisions of the regulation and their effect upon business practices, cost practices or means or aids to distribution in the industry affected have, been carefully considered. No provisions which might have the effect of requiring, a change in such practices, means, aids or methods established in the automotive repair trade are included in the regulation unless such provisions have been found necessary to achieve effective price control. To the extent that the provisions of this regulation compel or may operate to compel changes in business practices, cost practices or methods, or means or aids to distribution established in the industry such provisions are necessary to prevent circumvention or evasion of RMPR 165 or the Emergency Price Control Act of 1942, as amended. Insofar as the provisions of this regulation use specifications and standards which were not, prior to such use, in general use in the trade or industry affected, or insofar as their use was not lawfully required by another Government agency, it is determined, with respect to such standardization, that no practicable alternative exists for securing effective price control with respect to the services subject to this regulation. Issued Ikis 15th day of May 1945. Chester Bowles, Administrator. GPO—OPA 10901—p. 30