[Federal Register Volume 81, Number 248 (Tuesday, December 27, 2016)]
[Rules and Regulations]
[Pages 94956-94958]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 2016-30278]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2016-8850; Directorate Identifier 2016-NM-031-AD; 
Amendment 39-18755; AD 2016-25-29]
RIN 2120-AA64


Airworthiness Directives; The Boeing Company Airplanes

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Final rule.

-----------------------------------------------------------------------

SUMMARY: We are adopting a new airworthiness directive (AD) for certain 
The Boeing Company Model 767-200 and -300 series airplanes. This AD was 
prompted by a report of a fire in the bilge area of the cargo 
compartment that burned through the insulation blankets that were 
intended to prevent smoke from migrating behind the cargo compartment 
sidewall liners and upward into the main cabin. This AD requires 
replacing the cargo compartment insulation blankets on the left and 
right sides with new insulation blankets that incorporate fire stops. 
We are issuing this AD to address the unsafe condition on these 
products.

DATES: This AD is effective January 31, 2017.
    The Director of the Federal Register approved the incorporation by 
reference of a certain publication listed in this AD as of January 31, 
2017.

ADDRESSES: For service information identified in this final rule, 
contact Boeing Commercial Airplanes, Attention: Contractual & Data 
Services (C&DS), 2600 Westminster Blvd., MC 110-SK57, Seal Beach, CA 
90740-5600; telephone 562-797-1717; Internet https://www.myboeingfleet.com. You may view this referenced service information 
at the FAA, Transport Airplane Directorate, 1601 Lind Avenue SW., 
Renton, WA. For information on the availability of this material at the 
FAA, call 425-227-1221. It is also available on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2016-
8850.

Examining the AD Docket

    You may examine the AD docket on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2016-
8850; or in person at the Docket Management Facility between 9 a.m. and 
5 p.m., Monday through Friday, except Federal holidays. The AD docket 
contains this AD, the regulatory evaluation, any comments received, and 
other information. The address for the Docket Office (phone: 800-647-
5527) is Docket Management Facility, U.S. Department of Transportation, 
Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 
New Jersey Avenue SE., Washington, DC 20590.

FOR FURTHER INFORMATION CONTACT: Francis Smith, Aerospace Engineer,

[[Page 94957]]

Cabin Safety & Environmental Control Systems, ANM-150S, FAA, Seattle 
Aircraft Certification Office, 1601 Lind Avenue SW., Renton, WA 98057-
3356; phone: 425-917-6596; fax: 425-917-6590; email: 
[email protected].

SUPPLEMENTARY INFORMATION: 

Discussion

    We issued a notice of proposed rulemaking (NPRM) to amend 14 CFR 
part 39 by adding an AD that would apply to certain The Boeing Company 
Model 767-200 and -300 series airplanes. The NPRM published in the 
Federal Register on August 30, 2016 (81 FR 59549) (``the NPRM''). The 
NPRM was prompted by a report of a fire in the bilge area of the cargo 
compartment that burned through the insulation blankets that were 
intended to prevent smoke from migrating behind the cargo compartment 
sidewall liners and upward into the main cabin. The NPRM proposed to 
require replacing the cargo compartment insulation blankets on the left 
and right sides with new insulation blankets that incorporate fire 
stops. We are issuing this AD to prevent a fire in the bilge area of 
the cargo compartment burning through the insulation blankets and 
consequently allowing smoke to migrate behind the cargo compartment 
sidewall liners and upward into the main cabin.

Comments

    We gave the public the opportunity to participate in developing 
this AD. The following presents the comments received on the NPRM and 
the FAA's response to each comment.

Support for the NPRM

    Boeing and United Airlines expressed support for the NPRM.

Effect of Winglets on Accomplishment of the Proposed Actions

    Aviation Partners Boeing stated that the installation of winglets 
per Supplemental Type Certificate (STC) ST01920SE does not affect the 
accomplishment of the manufacturer's service instructions.
    We agree with the commenter that STC ST01920SE does not affect the 
accomplishment of the manufacturer's service instructions. Therefore, 
the installation of STC ST01920SE does not affect the ability to 
accomplish the actions required by this AD. We have not changed this AD 
in this regard.

Conclusion

    We reviewed the relevant data, considered the comments received, 
and determined that air safety and the public interest require adopting 
this AD as proposed, except for minor editorial changes. We have 
determined that these minor changes:
     Are consistent with the intent that was proposed in the 
NPRM for correcting the unsafe condition; and
     Do not add any additional burden upon the public than was 
already proposed in the NPRM.
    We also determined that these changes will not increase the 
economic burden on any operator or increase the scope of this AD.

Related Service Information Under 1 CFR part 51

    We reviewed Boeing Special Attention Service Bulletin 767-25-0550, 
dated January 30, 2015. The service information describes procedures 
for replacing the cargo compartment insulation blankets on the left and 
right sides between stringers 29 and 33 with new insulation blankets 
that incorporate fire stops. This service information is reasonably 
available because the interested parties have access to it through 
their normal course of business or by the means identified in the 
ADDRESSES section.

Costs of Compliance

    We estimate that this AD affects 26 airplanes of U.S. registry.
    We estimate the following costs to comply with this AD:

                                                 Estimated Costs
----------------------------------------------------------------------------------------------------------------
          Action              Labor cost       Parts cost        Cost per  product       Cost on U.S. operators
----------------------------------------------------------------------------------------------------------------
Replacement..............  Up to 54 work-             (\1\)  Up to $4,590.............  Up to $119,340.
                            hours x $85 per
                            hour = $4,590.
----------------------------------------------------------------------------------------------------------------
\1\ We have received no definitive data that will enable us to provide parts cost estimates for the actions
  specified in this AD.

    According to the manufacturer, some of the costs of this AD may be 
covered under warranty, thereby reducing the cost impact on affected 
individuals. We do not control warranty coverage for affected 
individuals. As a result, we have included all available costs in our 
cost estimate.

Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to 
issue rules on aviation safety. Subtitle I, section 106, describes the 
authority of the FAA Administrator. Subtitle VII: Aviation Programs, 
describes in more detail the scope of the Agency's authority.
    We are issuing this rulemaking under the authority described in 
Subtitle VII, Part A, Subpart III, Section 44701: ``General 
requirements.'' Under that section, Congress charges the FAA with 
promoting safe flight of civil aircraft in air commerce by prescribing 
regulations for practices, methods, and procedures the Administrator 
finds necessary for safety in air commerce. This regulation is within 
the scope of that authority because it addresses an unsafe condition 
that is likely to exist or develop on products identified in this 
rulemaking action.

Regulatory Findings

    This AD will not have federalism implications under Executive Order 
13132. This AD will not have a substantial direct effect on the States, 
on the relationship between the national government and the States, or 
on the distribution of power and responsibilities among the various 
levels of government.
    For the reasons discussed above, I certify that this AD:
    (1) Is not a ``significant regulatory action'' under Executive 
Order 12866,
    (2) Is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979),
    (3) Will not affect intrastate aviation in Alaska, and
    (4) Will not have a significant economic impact, positive or 
negative, on a substantial number of small entities under the criteria 
of the Regulatory Flexibility Act.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

    Accordingly, under the authority delegated to me by the 
Administrator, the FAA amends 14 CFR part 39 as follows:

[[Page 94958]]

PART 39--AIRWORTHINESS DIRECTIVES

0
1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

0
2. The FAA amends Sec.  39.13 by adding the following new airworthiness 
directive (AD):

2016-25-29 The Boeing Company: Amendment 39-18755; Docket No. FAA-
2016-8850; Directorate Identifier 2016-NM-031-AD.

(a) Effective Date

    This AD is effective January 31, 2017.

(b) Affected ADs

    None.

(c) Applicability

    This AD applies to The Boeing Company Model 767-200 and -300 
series airplanes, certificated in any category, as identified in 
Boeing Special Attention Service Bulletin 767-25-0550, dated January 
30, 2015.

(d) Subject

    Air Transport Association (ATA) of America Code 25; Equipment/
furnishings.

(e) Unsafe Condition

    This AD was prompted by a report of a fire in the bilge area of 
the cargo compartment that burned through the insulation blankets 
that were intended to prevent smoke from migrating behind the cargo 
compartment sidewall liners and upward into the main cabin. We are 
issuing this AD to prevent a fire in the bilge area of the cargo 
compartment burning through the insulation blankets and consequently 
allowing smoke to migrate behind the cargo compartment sidewall 
liners and upward into the main cabin.

(f) Compliance

    Comply with this AD within the compliance times specified, 
unless already done.

(g) Insulation Blanket Replacement

    Within 36 months after the effective date of this AD: Replace 
the cargo compartment insulation blankets on the left and right 
sides between stringers 29 and 33 with new insulation blankets that 
incorporate fire stops, in accordance with the Accomplishment 
Instructions of Boeing Special Attention Service Bulletin 767-25-
0550, dated January 30, 2015. For Groups 1 through 4, Configurations 
1 and 2, airplanes identified in Boeing Special Attention Service 
Bulletin 767-25-0550, dated January 30, 2015, no action is required 
by this AD.

(h) Alternative Methods of Compliance (AMOCs)

    (1) The Manager, Seattle Aircraft Certification Office (ACO), 
FAA, has the authority to approve AMOCs for this AD, if requested 
using the procedures found in 14 CFR 39.19. In accordance with 14 
CFR 39.19, send your request to your principal inspector or local 
Flight Standards District Office, as appropriate. If sending 
information directly to the manager of the ACO, send it to the 
attention of the person identified in paragraph (i) of this AD. 
Information may be emailed to: [email protected].
    (2) Before using any approved AMOC, notify your appropriate 
principal inspector, or lacking a principal inspector, the manager 
of the local flight standards district office/certificate holding 
district office.
    (3) An AMOC that provides an acceptable level of safety may be 
used for any repair, modification, or alteration required by this AD 
if it is approved by the Boeing Commercial Airplanes Organization 
Designation Authorization (ODA) that has been authorized by the 
Manager, Seattle ACO, to make those findings. To be approved, the 
repair method, modification deviation, or alteration deviation must 
meet the certification basis of the airplane, and the approval must 
specifically refer to this AD.
    (4) For service information that contains steps that are labeled 
as Required for Compliance (RC), the provisions of paragraphs 
(h)(4)(i) and (h)(4)(ii) of this AD apply.
    (i) The steps labeled as RC, including substeps under an RC step 
and any figures identified in an RC step, must be done to comply 
with the AD. An AMOC is required for any deviations to RC steps, 
including substeps and identified figures.
    (ii) Steps not labeled as RC may be deviated from using accepted 
methods in accordance with the operator's maintenance or inspection 
program without obtaining approval of an AMOC, provided the RC 
steps, including substeps and identified figures, can still be done 
as specified, and the airplane can be put back in an airworthy 
condition.

(i) Related Information

    For more information about this AD, contact Francis Smith, 
Aerospace Engineer, Cabin Safety & Environmental Control Systems, 
ANM-150S, FAA, Seattle ACO, 1601 Lind Avenue SW., Renton, WA 98057-
3356; phone: 425-917-6596; fax: 425-917-6590; email: 
[email protected].

(j) Material Incorporated by Reference

    (1) The Director of the Federal Register approved the 
incorporation by reference (IBR) of the service information listed 
in this paragraph under 5 U.S.C. 552(a) and 1 CFR part 51.
    (2) You must use this service information as applicable to do 
the actions required by this AD, unless the AD specifies otherwise.
    (i) Boeing Special Attention Service Bulletin 767-25-0550, dated 
January 30, 2015.
    (ii) Reserved.
    (3) For service information identified in this AD, contact 
Boeing Commercial Airplanes, Attention: Contractual & Data Services 
(C&DS), 2600 Westminster Blvd., MC 110-SK57, Seal Beach, CA 90740-
5600; telephone 562-797-1717; Internet https://www.myboeingfleet.com.
    (4) You may view this service information at FAA, Transport 
Airplane Directorate, 1601 Lind Avenue SW., Renton, WA. For 
information on the availability of this material at the FAA, call 
425-227-1221.
    (5) You may view this service information that is incorporated 
by reference at the National Archives and Records Administration 
(NARA). For information on the availability of this material at 
NARA, call 202-741-6030, or go to: http://www.archives.gov/federal-register/cfr/ibr-locations.html.

    Issued in Renton, Washington, on December 9, 2016.
Dionne Palermo,
Acting Manager, Transport Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 2016-30278 Filed 12-23-16; 8:45 am]
 BILLING CODE 4910-13-P