[Federal Register Volume 81, Number 1 (Monday, January 4, 2016)]
[Proposed Rules]
[Pages 27-28]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 2015-32962]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2015-5193; Directorate Identifier 2015-NE-35-AD]
RIN 2120-AA64


Airworthiness Directives; Technify Motors GmbH Reciprocating 
Engines

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Notice of proposed rulemaking (NPRM).

-----------------------------------------------------------------------

SUMMARY: We propose to adopt a new airworthiness directive (AD) for 
certain Technify Motors GmbH (type certificate previously held by 
Thielert Aircraft Engines GmbH) TAE 125-02-99 and TAE 125-02-114 
reciprocating engines. This proposed AD was prompted by reports of in-
flight shutdowns (IFSDs) on TAE 125-02 engines. This proposed AD would 
require removal of affected fuel feed pumps. We are proposing this AD 
to prevent failure of the fuel feed pump, which could result in damage 
to the engine and damage to the airplane.

DATES: We must receive comments on this proposed AD by March 4, 2016.

ADDRESSES: You may send comments by any of the following methods:
     Federal eRulemaking Portal: Go to http://www.regulations.gov. Follow the instructions for submitting comments.
     Mail: Docket Management Facility, U.S. Department of 
Transportation, 1200 New Jersey Avenue SE., West Building Ground Floor, 
Room W12-140, Washington, DC 20590-0001.
     Hand Delivery: Deliver to Mail address above between 9 
a.m. and 5 p.m., Monday through Friday, except Federal holidays.
     Fax: 202-493-2251.
    For service information identified in this proposed AD, contact 
Technify Motors GmbH, Platanenstrasse 14, D-09356 Sankt Egidien, 
Germany, phone: +49-37204-696-0; fax: +49-37204-696-2912; email: 
[email protected]. You may view this service information at 
the FAA, Engine & Propeller Directorate, 12 New England Executive Park, 
Burlington, MA. For information on the availability of this material at 
the FAA, call 781-238-7125.

Examining the AD Docket

    You may examine the AD docket on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2015-
5193; or in person at the Docket Operations office between 9 a.m. and 5 
p.m., Monday through Friday, except Federal holidays. The AD docket 
contains this proposed AD, the mandatory continuing airworthiness 
information (MCAI), the regulatory evaluation, any comments received, 
and other information. The address for the Docket Office (phone: 800-
647-5527) is in the ADDRESSES section. Comments will be available in 
the AD docket shortly after receipt.

FOR FURTHER INFORMATION CONTACT: Philip Haberlen, Aerospace Engineer, 
Engine Certification Office, FAA, Engine & Propeller Directorate, 12 
New England Executive Park, Burlington, MA 01803; phone: 781-238-7770; 
fax: 781-238-7199; email: [email protected].

SUPPLEMENTARY INFORMATION: 

Comments Invited

    We invite you to send any written relevant data, views, or 
arguments about this proposed AD. Send your comments to an address 
listed under the ADDRESSES section. Include ``Docket No. FAA-2015-5193; 
Directorate Identifier 2015-NE-35-AD'' at the beginning of your 
comments. We specifically invite comments on the overall regulatory, 
economic, environmental, and energy aspects of this proposed AD. We 
will consider all comments received by the closing date and may amend 
this proposed AD based on those comments.
    We will post all comments we receive, without change, to http://www.regulations.gov, including any personal information you provide. We 
will also post a report summarizing each substantive verbal contact 
with FAA personnel concerning this proposed AD.

Discussion

    The European Aviation Safety Agency (EASA), which is the Technical 
Agent for the Member States of the European Community, has issued EASA 
AD 2015-0189, dated September 21, 2015 (referred to hereinafter as 
``the MCAI''), to correct an unsafe condition for the specified 
products. The MCAI states:

    In-flight shut down occurrences have been reported on aeroplanes 
equipped with TAE 125-02 engines. The initial results of the 
investigations showed that a defective fuel feed pump was the 
probable cause of the engine failure.

    You may obtain further information by examining the MCAI in the AD 
docket on the Internet at http://www.regulations.gov by searching for 
and locating Docket No. FAA-2015-5193.

Related Service Information

    Technify Motors GmbH has issued Operation & Maintenance Manual, CD-
135/CD-155, OM-02-02, Issue 4, Revision No. 5, dated September 18, 
2015. The service information describes procedures for removing and 
replacing the fuel feed pump.

FAA's Determination and Requirements of This Proposed AD

    This product has been approved by the aviation authority of 
Germany, and is approved for operation in the United States. Pursuant 
to our bilateral agreement with the European Community, EASA has 
notified us of the unsafe condition described in the MCAI and service 
information referenced above. We are proposing this AD because we 
evaluated all information provided by EASA and determined the unsafe 
condition exists

[[Page 28]]

and is likely to exist or develop on other products of the same type 
design. This proposed AD would require removal of affected fuel feed 
pumps.

Costs of Compliance

    We estimate that this proposed AD affects 190 engines installed on 
airplanes of U.S. registry. We also estimate that it would take about 
0.5 hours per engine to comply with this proposed AD. The average labor 
rate is $85 per hour. Pro-rated cost of life limit reduction would be 
about $160 per part. Based on these figures, we estimate the cost of 
the proposed AD on U.S. operators to be $38,475.

Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to 
issue rules on aviation safety. Subtitle I, section 106, describes the 
authority of the FAA Administrator. ``Subtitle VII: Aviation 
Programs,'' describes in more detail the scope of the Agency's 
authority.
    We are issuing this rulemaking under the authority described in 
``Subtitle VII, Part A, Subpart III, Section 44701: General 
requirements.'' Under that section, Congress charges the FAA with 
promoting safe flight of civil aircraft in air commerce by prescribing 
regulations for practices, methods, and procedures the Administrator 
finds necessary for safety in air commerce. This regulation is within 
the scope of that authority because it addresses an unsafe condition 
that is likely to exist or develop on products identified in this 
rulemaking action.

Regulatory Findings

    We determined that this proposed AD would not have federalism 
implications under Executive Order 13132. This proposed AD would not 
have a substantial direct effect on the States, on the relationship 
between the national Government and the States, or on the distribution 
of power and responsibilities among the various levels of government.
    For the reasons discussed above, I certify this proposed 
regulation:
    (1) Is not a ``significant regulatory action'' under Executive 
Order 12866,
    (2) Is not a ``significant rule'' under the DOT Regulatory Policies 
and Procedures (44 FR 11034, February 26, 1979),
    (3) Will not affect intrastate aviation in Alaska to the extent 
that it justifies making a regulatory distinction, and
    (4) Will not have a significant economic impact, positive or 
negative, on a substantial number of small entities under the criteria 
of the Regulatory Flexibility Act.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

The Proposed Amendment

    Accordingly, under the authority delegated to me by the 
Administrator, the FAA proposes to amend 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0
1. The authority citation for part 39 continues to read as follows:

    Authority:  49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

0
2. The FAA amends Sec.  39.13 by adding the following new airworthiness 
directive (AD):

Technify Motors GmbH (Type Certificate previously held by Thielert 
Aircraft Engines GmbH): Docket No. FAA-2015-5193; Directorate 
Identifier 2015-NE-35-AD.

(a) Comments Due Date

    We must receive comments by March 4, 2016.

(b) Affected ADs

    None.

(c) Applicability

    This AD applies to all Technify Motors GmbH (type certificate 
previously held by Thielert Aircraft Engines GmbH) TAE 125-02-99 and 
TAE 125-02-114 reciprocating engines with a fuel feed pump, part 
number (P/N) 05-7312-K0073xx, or P/N 05-7312-K0133xx, where ``xx'' 
can be any number, installed.

(d) Reason

    This AD was prompted by reports of in-flight shutdowns (IFSDs) 
on TAE 125-02 engines. We are issuing this AD to prevent failure of 
the fuel feed pump, which could result in damage to the engine and 
damage to the airplane.

(e) Actions and Compliance

    Comply with this AD within the compliance times specified, 
unless already done. Remove from service each affected fuel feed 
pump before it exceeds 600 operating hours (OH) time in service 
(TIS) or within 110 OH after the effective date of this AD, 
whichever occurs later.

(f) Installation Prohibition

    After the effective date of this AD, do not install onto any 
engine, any fuel feed pump, P/N 05-7312-K0073xx or P/N 05-7312-
K0133xx, where ``xx'' can be any number, if the fuel feed pump has 
600 hours or more TIS. If TIS of a fuel feed pump is unknown or has 
exceeded 600 hours TIS, then the fuel feed pump is not eligible for 
installation. Rebuilt, overhauled, or repaired fuel feed pumps and/
or fuel feed pumps that lack a serial number, are not eligible for 
installation.

(g) Alternative Methods of Compliance (AMOCs)

    The Manager, Engine Certification Office, FAA, may approve AMOCs 
for this AD. Use the procedures found in 14 CFR 39.19 to make your 
request. You may email your request to: [email protected].

(h) Related Information

    (1) For more information about this AD, contact Philip Haberlen, 
Aerospace Engineer, Engine Certification Office, FAA, Engine & 
Propeller Directorate, 12 New England Executive Park, Burlington, MA 
01803; phone: 781-238-7770; fax: 781-238-7199; email: 
[email protected].
    (2) Refer to MCAI European Aviation Safety Agency AD 2015-0189, 
dated September 21, 2015, for more information. You may examine the 
MCAI in the AD docket on the Internet at http://www.regulations.gov 
by searching for and locating it in Docket No. FAA-2015-5193.
    (3) For service information identified in this proposed AD, 
contact Technify Motors GmbH, Platanenstrasse 14, D-09356 Sankt 
Egidien, Germany; phone: +49-37204-696-0; fax: +49-37204-696-2912; 
email: [email protected].
    (4) You may view this service information at the FAA, Engine & 
Propeller Directorate, 12 New England Executive Park, Burlington, 
MA. For information on the availability of this material at the FAA, 
call 781-238-7125.

    Issued in Burlington, Massachusetts, on December 18, 2015.
Ann C. Mollica,
Acting Directorate Manager, Engine & Propeller Directorate, Aircraft 
Certification Service.
[FR Doc. 2015-32962 Filed 12-31-15; 8:45 am]
 BILLING CODE 4910-13-P