[Federal Register Volume 77, Number 145 (Friday, July 27, 2012)]
[Rules and Regulations]
[Pages 44113-44116]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 2012-17955]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2012-0675; Directorate Identifier 2012-NM-120-AD; 
Amendment 39-17131; AD 2012-13-51]
RIN 2120-AA64


Airworthiness Directives; Gulfstream Aerospace LP (Type 
Certificate Previously Held by Israel Aircraft Industries, Ltd.) 
Airplanes

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Final rule; request for comments.

-----------------------------------------------------------------------

SUMMARY: We are adopting a new airworthiness directive (AD) for certain 
Gulfstream Aerospace LP (Type Certificate previously held by Israel 
Aircraft Industries, Ltd.) Model Gulfstream G150 airplanes. This 
emergency AD was sent previously to all known U.S. owners and operators 
of these airplanes. This AD requires a one-time detailed or borescope 
inspection of the left- and right-hand inboard vent holes for debris or 
obstructions, and repair if necessary. This AD was prompted by a report 
indicating that an inboard vent tube hole was completely covered with 
sealant, which blocked airflow through the vent. Under these 
conditions, the rise of internal pressure during pressure fueling or 
due to thermal expansion is sufficient to damage the wing. We are 
issuing this AD to detect and correct compromised integrity of the wing 
structure.

DATES: This AD is effective August 13, 2012 to all persons except those 
persons to whom it was made immediately effective by emergency AD 2012-
13-51, issued on June 26, 2012, which contained the requirements of 
this amendment.
    The Director of the Federal Register approved the incorporation by 
reference of a certain publication identified in the AD as of August 
13, 2012.
    We must receive comments on this AD by September 10, 2012.

ADDRESSES: You may send comments, using the procedures found in 14 CFR 
11.43 and 11.45, by any of the following methods:
     Federal eRulemaking Portal: Go to http://www.regulations.gov. Follow the instructions for submitting comments.
     Fax: 202-493-2251.
     Mail: U.S. Department of Transportation, Docket 
Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New 
Jersey Avenue SE., Washington, DC 20590.
     Hand Delivery: Deliver to Mail address above between 9 
a.m. and 5 p.m., Monday through Friday, except Federal holidays.
    For service information identified in this AD, contact Gulfstream 
Aerospace Corporation, P.O. Box 2206, Mail Station D-25, Savannah, 
Georgia 31402-2206; telephone 800-810-4853; fax 912-965-3520; email 
[email protected]; Internet http://www.gulfstream.com/product_support/technical_pubs/pubs/index.htm.

Examining the AD Docket

    You may examine the AD docket on the Internet at http://www.regulations.gov; or in person at the Docket Operations Office 
between 9 a.m. and 5 p.m., Monday through Friday, except Federal 
holidays. The AD docket contains this AD, the regulatory

[[Page 44114]]

evaluation, any comments received, and other information. The street 
address for the Docket Operations Office (phone: 800-647-5527) is in 
the ADDRESSES section. Comments will be available in the AD docket 
shortly after receipt.

FOR FURTHER INFORMATION CONTACT: Tom Groves, Aerospace Engineer, 
International Branch, ANM-116, Transport Airplane Directorate, FAA, 
1601 Lind Avenue SW., Renton, Washington 98057-3356; phone: 425-227-
1503; fax: 425-227-1149; email: [email protected].

SUPPLEMENTARY INFORMATION:

Discussion

    On June 26, 2012, we issued emergency AD 2012-13-51, which requires 
a one-time detailed or borescope inspection of the left- and right-hand 
inboard vent holes for debris or obstructions, and repair if necessary. 
Emergency AD 2012-13-51 also requires reporting positive inspection 
findings to the manufacturer. This action was prompted by a report from 
the Civil Aviation Authority of Israel (CAAI), which is the 
airworthiness authority for Israel, indicating that an unsafe condition 
may exist on Gulfstream Aerospace LP Model Gulfstream G150 airplanes. 
The CAAI advises that fasteners protruding from the lower wing surface 
were discovered during a post-flight inspection. Investigation revealed 
structural damage to (and separation of) ribs from wing planks.
    Further inspection showed that the inboard vent tube hole was 
completely covered with sealant, which blocked airflow through the 
vent. This condition was also found on some airplanes in production. 
Under these conditions, the rise of internal pressure during pressure 
fueling or due to thermal expansion is sufficient to damage the wing. 
This condition, if not detected and corrected, could compromise the 
integrity of the wing structure.

Relevant Service Information

    Gulfstream Aerospace LP has issued Gulfstream G150 Alert Service 
Bulletin 150-28A-146, dated June 22, 2012. The service information 
describes procedures for a one-time detailed or borescope inspection of 
the left- and right-hand inboard vent holes for debris and 
obstructions. The service information specifies to contact the 
manufacturer if any debris or obstruction is found. The CAAI mandated 
this service bulletin and issued Emergency Airworthiness Directive 28-
12-06-18, dated June 24, 2012 (referred to after this as ``the MCAI''), 
to ensure the continued airworthiness of these airplanes in Israel.

FAA's Determination and Requirements of This AD

    This product has been approved by the aviation authority of another 
country, and is approved for operation in the United States. Pursuant 
to our bilateral agreement with the State of Design Authority, we have 
been notified of the unsafe condition described in the MCAI and service 
information referenced above. We are issuing this AD because we 
evaluated all pertinent information and determined an unsafe condition 
exists and is likely to exist or develop on other products of the same 
type design.
    Since the unsafe condition described is likely to exist or develop 
on other airplanes of the same type design, we issued emergency AD 
2012-13-51 to detect and correct compromised integrity of the wing 
structure. The AD requires a one-time detailed or borescope inspection 
of the left- and right-hand inboard vent holes for debris or 
obstructions, and repair if necessary. The AD also requires reporting 
positive inspection findings to the manufacturer.
    We found that immediate corrective action was required; therefore, 
notice and opportunity for prior public comment thereon were 
impracticable and contrary to the public interest, and good cause 
existed to make the AD effective immediately by individual notices 
issued on June 26, 2012, to all known U.S. owners and operators of 
Gulfstream Aerospace LP (Type Certificate previously held by Israel 
Aircraft Industries, Ltd.) Model Gulfstream G150 airplanes. These 
conditions still exist, and the AD is hereby published in the Federal 
Register as an amendment to section 39.13 of the Federal Aviation 
Regulations (14 CFR 39.13) to make it effective to all persons.

Interim Action

    We consider this AD interim action. We may consider further 
rulemaking when additional information is available.

FAA's Determination of the Effective Date

    An unsafe condition exists that requires the immediate adoption of 
this AD. The FAA has found that the risk to the flying public justifies 
waiving notice and comment prior to adoption of this rule because we 
received a report indicating that an inboard vent tube hole was 
completely covered with sealant, which blocked airflow through the 
vent. Under these conditions, the rise of internal pressure during 
pressure fueling or due to thermal expansion is sufficient to damage 
the wing. We are issuing this AD to detect and correct compromised 
integrity of the wing structure. Therefore, we find that notice and 
opportunity for prior public comment are impracticable and that good 
cause exists for making this amendment effective in less than 30 days.

Comments Invited

    This AD is a final rule that involves requirements affecting flight 
safety and was not preceded by notice and an opportunity for public 
comment. However, we invite you to send any written data, views, or 
arguments about this AD. Send your comments to an address listed under 
the ADDRESSES section. Include the docket number FAA-2012-0675 and 
Directorate Identifier 2012-NM-120-AD at the beginning of your 
comments. We specifically invite comments on the overall regulatory, 
economic, environmental, and energy aspects of this AD. We will 
consider all comments received by the closing date and may amend this 
AD because of those comments.
    We will post all comments we receive, without change, to http://www.regulations.gov, including any personal information you provide. We 
will also post a report summarizing each substantive verbal contact we 
receive about this AD.

Costs of Compliance

    We estimate that this AD affects 58 airplanes of U.S. registry.
    We estimate the following costs to comply with this AD:

                                                 Estimated Costs
----------------------------------------------------------------------------------------------------------------
                                                                                                Cost on U.S.
            Action                  Labor cost          Parts cost      Cost per product          operators
----------------------------------------------------------------------------------------------------------------
Inspection...................  Up to 18 work-hours               $0   Up to $1,530........  Up to $88,740.
                                x $85 per hour = up
                                to $1,530.
----------------------------------------------------------------------------------------------------------------


[[Page 44115]]

    We have received no definitive data that would enable us to provide 
cost estimates for the on-condition actions specified in this AD.

Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to 
issue rules on aviation safety. Subtitle I, section 106, describes the 
authority of the FAA Administrator. Subtitle VII: Aviation Programs 
describes in more detail the scope of the Agency's authority.
    We are issuing this rulemaking under the authority described in 
Subtitle VII, Part A, Subpart III, Section 44701: ``General 
requirements.'' Under that section, Congress charges the FAA with 
promoting safe flight of civil aircraft in air commerce by prescribing 
regulations for practices, methods, and procedures the Administrator 
finds necessary for safety in air commerce. This regulation is within 
the scope of that authority because it addresses an unsafe condition 
that is likely to exist or develop on products identified in this 
rulemaking action.

Regulatory Findings

    This AD will not have federalism implications under Executive Order 
13132. This AD will not have a substantial direct effect on the States, 
on the relationship between the national government and the States, or 
on the distribution of power and responsibilities among the various 
levels of government.
    For the reasons discussed above, I certify that this AD:
    (1) Is not a ``significant regulatory action'' under Executive 
Order 12866,
    (2) Is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979),
    (3) Will not affect intrastate aviation in Alaska, and
    (4) Will not have a significant economic impact, positive or 
negative, on a substantial number of small entities under the criteria 
of the Regulatory Flexibility Act.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

    Accordingly, under the authority delegated to me by the 
Administrator, the FAA amends 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0
1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

0
2. The FAA amends Sec.  39.13 by adding the following new airworthiness 
directive (AD):

2012-13-51 Gulfstream Aerospace LP (Type Certificate Previously Held 
by Israel Aircraft Industries, Ltd.): Amendment 39-17131; Docket No. 
FAA-2012-0675; Directorate Identifier 2012-NM-120-AD.

(a) Effective Date

    This AD is effective August 13, 2012 to all persons except those 
persons to whom it was made immediately effective by emergency AD 
2012-13-51, issued on June 26, 2012, which contained the 
requirements of this amendment.

(b) Affected ADs

    None.

(c) Applicability

    This AD applies to Gulfstream Aerospace LP (Type Certificate 
previously held by Israel Aircraft Industries, Ltd.) Model 
Gulfstream G150 airplanes, certificated in any category, serial 
numbers 201 through 290 inclusive.

(d) Subject

    Joint Aircraft System Component (JASC)[sol]Air Transport 
Association (ATA) of America Code 28: Fuel.

(e) Unsafe Condition

    This AD was prompted by a report indicating that an inboard vent 
tube hole was completely covered with sealant, which blocked airflow 
through the vent. Under these conditions, the rise of internal 
pressure during pressure fueling or due to thermal expansion is 
sufficient to damage the wing. We are issuing this AD to detect and 
correct compromised integrity of the wing structure.

(f) Compliance

    Comply with this AD within the compliance times specified, 
unless already done.

(g) Inspection and Repair

    Before further flight: Do a one-time detailed or borescope 
inspection of the left- and right-hand inboard vent holes for debris 
and obstructions, in accordance with the Accomplishment Instructions 
of Gulfstream G150 Alert Service Bulletin 150-28A-146, dated June 
22, 2012. If any debris or obstruction is found, before further 
flight, repair in accordance with a method approved by either the 
Manager, International Branch, ANM-116, Transport Airplane 
Directorate, FAA; or the Civil Aviation Authority of Israel (CAAI) 
(or its delegated agent).

(h) Reporting Requirement

    (1) Submit a report of positive findings of the inspection 
required by paragraph (g) of this AD to Gulfstream Aerospace CMP, 
fax 800-944-1775 or 912-963-0265, at the applicable time specified 
in paragraph (h)(1)(i) or (h)(1)(ii) of this AD. The report must 
include the inspection date and results, a description of any 
finding, the airplane serial number, and the number of flight hours 
and landings on the airplane.
    (i) If the inspection was done on or after the effective date of 
this AD: Submit the report within 10 days after the inspection.
    (ii) If the inspection was done before the effective date of 
this AD: Submit the report within 10 days after the effective date 
of this AD.
    (2) A federal agency may not conduct or sponsor, and a person is 
not required to respond to, nor shall a person be subject to a 
penalty for failure to comply with a collection of information 
subject to the requirements of the Paperwork Reduction Act unless 
that collection of information displays a current valid OMB Control 
Number. The OMB Control Number for this information collection is 
2120-0056. Public reporting for this collection of information is 
estimated to be approximately 5 minutes per response, including the 
time for reviewing instructions, completing and reviewing the 
collection of information. All responses to this collection of 
information are mandatory. Comments concerning the accuracy of this 
burden and suggestions for reducing the burden should be directed to 
the FAA at: 800 Independence Ave. SW., Washington, DC 20591, Attn: 
Information Collection Clearance Officer, AES-200.

(i) Alternative Methods of Compliance (AMOCs)

    (1) The Manager, International Branch, ANM-116, Transport 
Airplane Directorate, FAA, has the authority to approve AMOCs for 
this AD, if requested using the procedures found in 14 CFR 39.19. In 
accordance with 14 CFR 39.19, send your request to your principal 
inspector or local Flight Standards District Office, as appropriate. 
If sending information directly to the manager of the International 
Branch, send it to the attention of the person identified in the 
Related Information section of this AD. Information may be emailed 
to: [email protected].
    (2) Before using any approved AMOC, notify your appropriate 
principal inspector, or lacking a principal inspector, the manager 
of the local flight standards district office/certificate holding 
district office. The AMOC approval letter must specifically 
reference this AD.

(j) Special Flight Permit

    Special flight permits, as described in Section 21.197 and 
Section 21.199 of the Federal Aviation Regulations (14 CFR 21.197 
and 21.199), are allowed provided the criteria in this paragraph are 
met. A general visual inspection must be done to detect fuel leaks, 
skin distortion, protruding fasteners, and loose fasteners of the 
left- and right-hand lower wing skins. A special flight permit is 
not allowed if there is any finding from the inspection. If there 
are no findings from the inspection, a special flight permit is 
allowed, provided the total wing tank fuel quantity of

[[Page 44116]]

the airplane (i.e., total of both wing tanks) is limited to 3,500 
pounds or less.

(k) Related Information

    (1) For further information about this AD, contact Tom Groves, 
Aerospace Engineer, International Branch, ANM-116, Transport 
Airplane Directorate, FAA, 1601 Lind Avenue SW., Renton, Washington 
98057-3356; phone: 425-227-1503; fax: 425 227-1149; email: 
[email protected].
    (2) Refer to MCAI Israeli Emergency Airworthiness Directive 28-
12-06-18, dated June 24, 2012; and Gulfstream G150 Alert Service 
Bulletin 150-28A-146, dated June 22, 2012; for related information.

(l) Material Incorporated by Reference

    (1) The Director of the Federal Register approved the 
incorporation by reference (IBR) of the service information listed 
in this paragraph under 5 U.S.C. 552(a) and 1 CFR part 51.
    (2) You must use this service information as applicable to do 
the actions required by this AD, unless the AD specifies otherwise.
    (i) Gulfstream G150 Alert Service Bulletin 150-28A-146, dated 
June 22, 2012.
    (ii) Reserved.
    (3) For service information identified in this AD, contact 
Gulfstream Aerospace Corporation, P.O. Box 2206, Mail Station D-25, 
Savannah, Georgia 31402-2206; telephone 800-810-4853; fax 912-965-
3520; email [email protected]; Internet http://www.gulfstream.com/product_support/technical_pubs/pubs/index.htm.
    (4) You may review copies of the service information at the FAA, 
Transport Airplane Directorate, 1601 Lind Avenue SW., Renton, WA. 
For information on the availability of this material at the FAA, 
call 425-227-1221.
    (5) You may also review copies of the service information that 
is incorporated by reference at the National Archives and Records 
Administration (NARA). For information on the availability of this 
material at an NARA facility, call 202-741-6030, or go to http://www.archives.gov/federal_register/code_of_federal_regulations/ibr_locations.html.

    Issued in Renton, Washington, on July 13, 2012.
Michael Kaszycki,
Acting Manager, Transport Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 2012-17955 Filed 7-26-12; 8:45 am]
BILLING CODE 4910-13-P