[Federal Register Volume 74, Number 145 (Thursday, July 30, 2009)]
[Proposed Rules]
[Pages 37955-37963]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: E9-18118]


 ========================================================================
 Proposed Rules
                                                 Federal Register
 ________________________________________________________________________
 
 This section of the FEDERAL REGISTER contains notices to the public of 
 the proposed issuance of rules and regulations. The purpose of these 
 notices is to give interested persons an opportunity to participate in 
 the rule making prior to the adoption of the final rules.
 
 ========================================================================
 

  Federal Register / Vol. 74, No. 145 / Thursday, July 30, 2009 / 
Proposed Rules  

[[Page 37955]]



DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2008-0052; Directorate Identifier 2008-NE-01-AD]
RIN 2120-AA64


Airworthiness Directives; Engine Components, Inc. (ECi) 
Reciprocating Engine Cylinder Assemblies

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Notice of proposed rulemaking (NPRM).

-----------------------------------------------------------------------

SUMMARY: The FAA proposes to supersede an existing airworthiness 
directive (AD) for Lycoming Engines (formerly Textron Lycoming) models 
320, 360, and 540 series, ``Parallel Valve'' reciprocating engines, 
with certain Engine Components, Inc. (ECi) cylinder assemblies, part 
number (P/N) AEL65102 series ``Titan,'' installed. That AD currently 
requires initial and repetitive visual inspections and compression 
tests to detect cracks at the head-to-barrel interface, replacement of 
cylinder assemblies found cracked, and replacement of certain cylinder 
assemblies at new, reduced times-in-service. This proposed AD would 
require the same actions, but for an expanded population of cylinder 
assemblies. This proposed AD results from reports of 10 additional 
cylinder head separations since issuing AD 2008-19-05, on cylinder 
serial numbers not listed in that AD. We are proposing this AD to 
prevent loss of engine power due to cracks at the head-to-barrel 
interface and possible engine failure caused by separation of a 
cylinder head, which could result in loss of control of the aircraft.

DATES: We must receive any comments on this proposed AD by September 
28, 2009.

ADDRESSES: Use one of the following addresses to comment on this 
proposed AD:
     Federal eRulemaking Portal: Go to http://www.regulations.gov and follow the instructions for sending your 
comments electronically.
     Mail: Docket Management Facility, U.S. Department of 
Transportation, 1200 New Jersey Avenue, SE., West Building Ground 
Floor, Room W12-140, Washington, DC 20590-0001.
     Hand Delivery: Deliver to Mail address above between 9 
a.m. and 5 p.m., Monday through Friday, except Federal holidays.
     Fax: (202) 493-2251.

FOR FURTHER INFORMATION CONTACT: Peter W. Hakala, Aerospace Engineer, 
Special Certification Office, FAA, Rotorcraft Directorate, 2601 Meacham 
Blvd., Fort Worth, TX 76193; e-mail: [email protected]; telephone 
(817) 222-5145; fax (817) 222-5785.

SUPPLEMENTARY INFORMATION:

Comments Invited

    We invite you to send any written relevant data, views, or 
arguments regarding this proposal. Send your comments to an address 
listed under ADDRESSES. Include ``Docket No. FAA-2008-0052; Directorate 
Identifier 2008-NE-01-AD'' in the subject line of your comments. We 
specifically invite comments on the overall regulatory, economic, 
environmental, and energy aspects of the proposed AD. We will consider 
all comments received by the closing date and may amend the proposed AD 
in light of those comments.
    We will post all comments we receive, without change, to http://www.regulations.gov, including any personal information you provide. We 
will also post a report summarizing each substantive verbal contact 
with FAA personnel concerning this proposed AD. Using the search 
function of the Web site, anyone can find and read the comments in any 
of our dockets, including, if provided, the name of the individual who 
sent the comment (or signed the comment on behalf of an association, 
business, labor union, etc.). You may review the DOT's complete Privacy 
Act Statement in the Federal Register published on April 11, 2000 (65 
FR 19477-78).

Examining the AD Docket

    You may examine the AD docket on the Internet at http://www.regulations.gov; or in person at the Docket Operations office 
between 9 a.m. and 5 p.m., Monday through Friday, except Federal 
holidays. The AD docket contains this proposed AD, the regulatory 
evaluation, any comments received, and other information. The street 
address for the Docket Operations office (telephone (800) 647-5527) is 
the same as the Mail address provided in the ADDRESSES section. 
Comments will be available in the AD docket shortly after receipt.

Discussion

    The FAA proposes to amend 14 CFR part 39 by superseding AD 2008-19-
05, Amendment 39-15672 (73 FR 53105, September 15, 2008). That AD 
requires initial and repetitive visual inspections and compression 
tests to detect cracks at the head-to-barrel interface, replacement of 
cylinder assemblies found cracked, and replacement of certain cylinder 
assemblies, at new reduced times-in-service. That AD was the result of 
reports of 45 failures with head separations of ECi cylinder 
assemblies. That condition, if not corrected, could result in loss of 
engine power due to cracks at the head-to-barrel interface in the 
cylinder assemblies and possible engine failure caused by separation of 
a cylinder head, which could result in loss of control of the aircraft.

Actions Since AD 2008-19-05 Was Issued

    Since AD 2008-19-05 was issued, we received reports of 10 
additional cylinder head separations, on cylinder serial numbers not 
listed in that AD. To date, there have been a total of 55 head 
separations resulting in engine shutdowns and emergency landings in 
airplanes and helicopters.

FAA's Determination and Requirements of the Proposed AD

    We have evaluated all pertinent information and identified an 
unsafe condition that is likely to exist or develop on other products 
of this same type design. For that reason, we are proposing this AD, 
which would require initial and repetitive visual inspections and 
compression tests to detect cracks at the head-to-barrel interface, 
replacement of cylinder assemblies found cracked, and replacement of 
certain cylinder assemblies, at new reduced times-in-service. The 
proposed AD would require:

[[Page 37956]]

     Determining if Group ``A'' or Group ``B'' ECi cylinder 
assemblies, P/N AEL65102 series ``Titan,'' with cylinder head P/N 
AEL85099, are installed on your engine.
     For any Group ``A'' cylinder assembly, performing initial 
and repetitive visual inspections and compression tests, and 
replacement not later than 2,000 operating hours time-in-service (TIS) 
or within 25 operating hours TIS if the cylinder assembly exceeds 2,000 
operating hours TIS on the effective date of the proposed AD.
     For any Group ``A'' cylinder assembly installed in a 
helicopter, performing the same initial and repetitive visual 
inspections and compression tests, but replacement not later than 1,500 
operating hours TIS or within 25 operating hours TIS if the cylinder 
assembly exceeds 1,500 operating hours TIS on the effective date of the 
proposed AD.
     Expanding the serial numbers affected of Group ``B'' 
cylinder assemblies, and performing the same initial visual inspection 
and compression test, and replacement not later than 350 operating 
hours TIS or within 25 operating hours TIS if the cylinder assembly 
exceeds 350 operating hours TIS on the effective date of the proposed 
AD.

Costs of Compliance

    We estimate that this proposed AD would affect 18,000 ECi cylinder 
assemblies installed in aircraft of U.S. registry. The visual 
inspection and compression tests would take about 4 work-hours for each 
engine. An individual cylinder replacement would require $1,100 for 
parts and 6 work-hours. Lycoming engines with a set of 4 ECi cylinders 
would require 12 work-hours for the cylinder replacement. Lycoming 
engines with a set of 6 ECi cylinders would require 16 work-hours for 
the cylinder replacement. We estimate 18 percent of the affected 
population of cylinders would be replaced. We estimate the total cost 
of the AD to U.S. operators to be $10,172,000. Our estimate is 
exclusive of any possible warranty coverage.

Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to 
issue rules on aviation safety. Subtitle I, Section 106, describes the 
authority of the FAA Administrator. Subtitle VII, Aviation Programs, 
describes in more detail the scope of the Agency's authority.
    We are issuing this rulemaking under the authority described in 
Subtitle VII, Part A, Subpart III, Section 44701, ``General 
requirements.'' Under that section, Congress charges the FAA with 
promoting safe flight of civil aircraft in air commerce by prescribing 
regulations for practices, methods, and procedures the Administrator 
finds necessary for safety in air commerce. This regulation is within 
the scope of that authority because it addresses an unsafe condition 
that is likely to exist or develop on products identified in this 
rulemaking action.

Regulatory Findings

    We have determined that this proposed AD would not have federalism 
implications under Executive Order 13132. This proposed AD would not 
have a substantial direct effect on the States, on the relationship 
between the national Government and the States, or on the distribution 
of power and responsibilities among the various levels of government.
    For the reasons discussed above, I certify that the proposed AD:
    1. Is not a ``significant regulatory action'' under Executive Order 
12866;
    2. Is not a ``significant rule'' under the DOT Regulatory Policies 
and Procedures (44 FR 11034, February 26, 1979); and
    3. Would not have a significant economic impact, positive or 
negative, on a substantial number of small entities under the criteria 
of the Regulatory Flexibility Act.
    We prepared a regulatory evaluation of the estimated costs to 
comply with this proposed AD. See the ADDRESSES section for a location 
to examine the regulatory evaluation.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Safety.

The Proposed Amendment

    Under the authority delegated to me by the Administrator, the 
Federal Aviation Administration proposes to amend 14 CFR part 39 as 
follows:

PART 39--AIRWORTHINESS DIRECTIVES

    1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13   [Amended]

    2. The FAA amends Sec.  39.13 by removing Amendment 39-15672 (73 FR 
53105, September 15, 2008) and by adding a new airworthiness directive 
to read as follows:

Engine Components, Inc. (ECi): Docket No. FAA-2008-0052; Directorate 
Identifier 2008-NE-01-AD.

Comments Due Date

    (a) The Federal Aviation Administration (FAA) must receive 
comments on this airworthiness directive (AD) action by September 
28, 2009.

Affected ADs

    (b) This AD supersedes AD 2008-19-05, Amendment 39-15672.

Applicability

    (c) If your engine has not been overhauled, or not had any 
cylinder assemblies replaced since new, no further action is 
required.
    (d) This AD applies to the Lycoming Engines (formerly Textron 
Lycoming) models 320, 360, and 540 series, ``Parallel Valve,'' 
reciprocating engines listed in Table 1 of this AD, with ECi 
cylinder assembly, part number (P/N) AEL65102 series ``Titan,'' and 
with cylinder head, P/N AEL85099, installed.
    (1) The applicable cylinder assembly serial numbers (SNs) are SN 
1138-02 through SN 35171-22, (referred to in this AD as Group ``A'' 
cylinder assemblies); and
    (2) SN 35239-01 through SN 42179-30 (referred to in this AD as 
Group ``B'' cylinder assemblies).
    (3) The cylinder assembly P/N is at the crankcase end of the 
cylinder assembly, and might be difficult to see. As a guide in 
determining if your cylinder assemblies are affected, all affected 
cylinder assemblies have cylinder head P/N AEL85099. The cylinder 
head P/N is at the top of the cylinder head, near the intake and 
exhaust valve springs, and is easier to locate than the cylinder 
assembly P/N.
    (4) The set of numbers appearing on the cylinder, above and to 
the left of the SN, in the form of ``123456'' is not used for 
determining applicability.

                         Table 1--Engine Models
------------------------------------------------------------------------
       Cylinder assembly part number          Installed on engine models
------------------------------------------------------------------------
AEL65102-NST04.............................  O-320-A1B, A2B, A2C, A2D,
                                              A3A, A3B, B2B, B2C, B2D,
                                              B2E, B3B, B3C, C2B, C2C,
                                              C3B, C3C, D1A, D1AD, D1B,
                                              D1C, D1D, D1F, D2A, D2B,
                                              D2C, D2F, D2G, D2H, D2J,
                                              D3G, E1A, E1B, E1C, E1F,
                                              E1J, E2A, E2B, E2C, E2D,
                                              E2E, E2F, E2G, E2H, E3D,
                                              E3H.
                                             IO-320-A1A, A2A, B1A, B1B,
                                              B1C, B1D, B1E, B2A, D1A,
                                              D1AD, D1B, D1C, E1A, E1B,
                                              E2A, E2B.
                                             AEIO-320-D1B, D2B, E1A,
                                              E1B, E2A, E2B.

[[Page 37957]]

 
                                             AIO-320-A1A, A1B, A2A, A2B,
                                              B1B, C1B.
                                             LIO-320-B1A.
AEL65102-NST05.............................  IO-320-C1A, C1B, C1F, F1A.
                                             LIO-320-C1A.
AEL65102-NST06.............................  O-320-A1A, A2A, A2B, A2C,
                                              A3A, A3B, A3C, E1A, E1B,
                                              E2A, E2C, (also, an O-320
                                              model with no suffix).
                                             IO-320-A1A, A2A.
AEL65102-NST07.............................  IO-320-B1A, B1B.
                                             LIO-320-B1A.
AEL65102-NST08.............................  O-320-B1A, B1B, B2A, B2B,
                                              B3A, B3B, B3C, C1A, C1B,
                                              C2A, C2B, C3A, C3B, C3C,
                                              D1A, D1B, D2A, D2B, D2C.
AEL65102-NST10.............................  O-360-A1A, A1C, A1D, A2A,
                                              A2E, A3A, A3D, A4A, B1A,
                                              B1B, B2A, B2B, C1A, C1C,
                                              C1G, C2A, C2B, C2C, C2D,
                                              D1A, D2A, D2B.
                                             IO-360-B1A, B1B, B1C.
                                             HO-360-A1A, B1A, B1B.
                                             HIO-360-B1A, B1B.
                                             AEIO-360-B1B.
                                             O-540-A1A, A1A5, A1B5,
                                              A1C5, A1D, A1D5, A2B,
                                              A3D5, A4A5, A4B5, A4C5,
                                              A4D5, B1A5, B1B5, B1D5,
                                              B2A5, B2B5, B2C5, B4A5,
                                              B4B5, D1A5, E1A, E4A5,
                                              E4B5, E4C5, F1A5, F1B5,
                                              G1A5, G2A5.
                                             IO-540-C1B5, C1C5, C2C,
                                              C4B5, C4B5D, C4C5, D4A5,
                                              D4B5, N1A5.
AEL65102-NST12.............................  O-360-A1A, A1AD, A1D, A1F,
                                              A1F6, A1F6D, A1G, A1G6,
                                              A1G6D, A1H, A1H6, A1J,
                                              A1LD, A1P, A2A, A2D, A2F,
                                              A2G, A2H, A3A, A3AD, A3D,
                                              A4A, A4AD, A4D, A4G, A4J,
                                              A4JD, A4K, A4M, A4N, A4P,
                                              A5AD, B1A, B2C, C1A, C1C,
                                              C1E, C1F, C1G, C2A, C2B,
                                              C2C, C2D, C2E, C4F, C4P,
                                              D2A, F1A6, G1A6.
                                             HO-360-C1A.
                                             LO-360-A1G6D, A1H6.
                                             HIO-360-B1A, B1B, G1A.
                                             LTO-360-A1A6D.
                                             TO-360-A1A6D.
                                             IO-360-B1B, B1BD, B1D, B1E,
                                              B1F, B1F6, B1G6, B2E, B2F,
                                              B2F6, B4A, E1A, L2A, M1A,
                                              M1B.
                                             AEIO-360-B1B, B1D, B1E,
                                              B1F, B1F6, B1G6, B1H, B2F,
                                              B2F6, B4A, H1A, H1B.
                                             O-540-A4D5, B2B5, B2C5,
                                              B2C5D, B4B5, B4B5D, E4A5,
                                              E4B5, E4C5, G1A5, G2A5,
                                              H1A5, H1A5D, H1B5, H1B5D,
                                              H2A5, H2A5D, H2B5D.
                                             IO-540-C4B5, C4B5D, C4D5,
                                              C4D5D, D4A5, D4B5, D4C5,
                                              N1A5, N1A5D, T4A5D, T4B5,
                                              T4B5D, T4C5D, V4A5, V4A5D.
                                             AEIO-540-D4A5, D4B5, D4C5,
                                              D4D5.
AEL65102-NST26.............................  IO-540-J4A5, R1A5.
                                             TIO-540-C1A, E1A, G1A, H1A.
AEL65102-NST38.............................  IO-360-F1A.
                                             TIO-540-AA1AD, AB1AD,
                                              AB1BD, AF1A, AG1A, AK1A,
                                              C1A, C1AD, K1AD.
                                             LTIO-540-K1AD.
AEL65102-NST43.............................  O-360-J2A.
                                             O-540-F1B5, J1A5D, J1B5D,
                                              J1C5D, J1D5D, J2A5D,
                                              J2B5D, J2C5D, J2D5D, J3A5,
                                              J3A5D, J3C5D.
                                             IO-540-AB1A5, W1A5, W1A5D,
                                              W3A5D.
AEL65102-NST44.............................  O-540-L3C5D.
------------------------------------------------------------------------

    The Lycoming Engines (formerly Textron Lycoming) models 320, 
360, and 540 series, ``Parallel Valve'', reciprocating engines are 
installed on, but not limited to, the aircraft listed in the 
following Table 2:

            Table 2--Engines Installed On, But Not Limited To
------------------------------------------------------------------------
                                                Installed on, but not
               Engine models                          limited to
------------------------------------------------------------------------
O-320-A1A..................................  Piper Aircraft: Tri-Pacer
                                              (PA-22 ``150'', PA-22S
                                              ``150''), Apache (PA-23),
                                              Pawnee (PA-25).
                                             Doyn Aircraft: Doyn-Cessna
                                              (170, 170A, 170B).
                                             Mooney Aircraft: Mark
                                              (20A).
                                             Dinfia: Ranquel (1A-46).
                                             Simmering-Graz Pauker:
                                              Flamingo (SGP-M-222).
                                             Aviamilano: Scricciolo (P-
                                              19).
                                             Vos Helicopter Co.: Spring
                                              Bok.
O-320-A1B..................................  Piper Aircraft: Tri-Pacer
                                              (PA-22 ``150'', PA-22S
                                              ``150''), Apache (PA-23).
                                             Doyn Aircraft: Doyn-Cessna
                                              (170, 170A, 170B).
                                             S.O.C.A.T.A.: Horizon
                                              (Gardan).
O-320-A2A..................................  Piper Aircraft: Tri-Pacer
                                              (PA-22 ``150'', PA-22S
                                              ``150''), Agriculture (PA-
                                              18A ``150''), Super Cub
                                              (PA-18 ``150''), Caribbean
                                              (PA-22 ``150''), Pawnee
                                              (PA-25).
                                             Intermountain Mfg. Co.:
                                              Call Air Texas (A-5, A-
                                              5T).
                                             Lake Aircraft: Colonial (C-
                                              1).
                                             Rawdon Bros.: Rawdon (T-1,
                                              T-15, T-15D).
                                             Shinn Engineering: Shinn
                                              (2150-A).

[[Page 37958]]

 
                                             Dinfia: Ranquel (1A-46).
                                             Neiva: (1PD-5802).
                                             Sud: Gardan-Horizon (GY-
                                              80).
                                             LaVerda: Falco (F8L Series
                                              II, America).
                                             Malmo: Vipan (MF1-10).
                                             Kingsford Smith: Autocrat
                                              (SCRM-153).
                                             Aero Commander: 100.
O-320-A2B..................................  Piper Aircraft: Tri-Pacer
                                              (PA-22 ``150'', PA-22S
                                              ``150''), Cherokee (PA-28
                                              ``150''), Super Cub (PA-18
                                              ``150'').
                                             Champion Aircraft:
                                              Challenger (7GCA, 7GCB,
                                              7KC), Citabria (7GCAA,
                                              7GCRC), Agriculture
                                              (7GCBA).
                                             Beagle: Pup (150).
                                             Artic: Interstate S1B2.
                                             Robinson: R-22.
                                             Varga: Kachina 2150A.
O-320-A2C..................................  Robinson: R-22.
                                             Cicare: Cicare AG.
                                             Bellanca Aircraft: Citabria
                                              150 (7GCAA), Citabria 150S
                                              (7GCBC).
O-320-A2D..................................  Piper Aircraft: Apache (PA-
                                              23).
O-320-A3A..................................  Doyn Aircraft: Doyn-Cessna
                                              (170, 170A, 170B).
                                             Corben-Fettes: Globe
                                              Special (Globe GC-1B).
O-320-A3B..................................  Piper Aircraft: Apache (PA-
                                              23).
                                             Doyn Aircraft: Doyn-Cessna
                                              (170, 170A, 170B).
                                             Teal II: TSC (1A2).
O-320-B1A..................................  Piper Aircraft: Apache (PA-
                                              23 ``160'').
                                             Doyn Aircraft: Doyn-Cessna
                                              (170, 170A, 170B).
                                             Malmo: Vipan (MF1-10).
O-320-B1B..................................  Piper Aircraft: Apache (PA-
                                              23 ``160'').
                                             Doyn Aircraft: Doyn-Cessna
                                              (170, 170A, 170B).
O-320-B2A..................................  Piper Aircraft: Tri-Pacer
                                              (PA-22 ``160'', PA-22S
                                              ``160'').
O-320-B2B..................................  Piper Aircraft: Tri-Pacer
                                              (PA-22 ``160'', PA-22S
                                              ``160'').
                                             Beagle: Airedale (D5-160).
                                             Fuji-Heavy Industries: Fuji
                                              (F-200).
                                             Uirapuru: Aerotec 122.
O-320-B2C..................................  Robinson: R-22.
O-320-B2D..................................  Maule: MX-7-160.
O-320-B2E..................................  Lycon.
O-320-B3A..................................  Piper Aircraft: Apache (PA-
                                              23 ``160'').
                                             Doyn Aircraft: Doyn-Cessna
                                              (170, 170A, 170B).
O-320-B3B..................................  Piper Aircraft: Apache (PA-
                                              23 ``160'').
                                             Doyn Aircraft: Doyn-Cessna
                                              (170, 170A, 170B).
                                             Sud: Gardan (GY80-160).
O-320-C1A..................................  Piper Aircraft: Apache (PA-
                                              23 ``160'').
                                             Riley Aircraft: Rayjay
                                              (Apache).
O-320-C1B..................................  Piper Aircraft: Apache (PA-
                                              23 ``160'').
O-320-C3A..................................  Piper Aircraft: Apache (PA-
                                              23 ``160'').
O-320-C3B..................................  Piper Aircraft: Apache (PA-
                                              23 ``160'').
O-320-D1A..................................  Sud: Gardan (GY-80).
                                             Gyroflug: Speed Cancard.
                                             Grob: G115.
O-320-D1F..................................  Slingsby: T67 Firefly.
O-320-D2A..................................  Piper Aircraft: Cherokee
                                              (PA-28S ``160'').
                                             Robin: Major (DR400-140B),
                                              Chevalier (DR-360), (R-
                                              3140).
                                             S.O.C.A.T.A.: Tampico TB9.
                                             Slingsby: T67C Firefly.
                                             Daetwyler: MD-3-160.
                                             Nash Aircraft Ltd.: Petrel.
                                             Aviolight: P66D Delta.
                                             General Avia: Pinguino.
O-320-D2B..................................  Beech Aircraft: Musketeer
                                              (M-23).
                                             Piper Aircraft: Cherokee
                                              (PA-28 ``160'').
O-320-D2J..................................  Cessna Aircraft: Skyhawk
                                              172.
O-320-D3G..................................  Piper Aircraft: Warrior II,
                                              Cadet (PA-28-161).
O-320-E1A..................................  Grob: G115.
O-320-E1C..................................  M.B.B. (Messerschmitt-
                                              Boelkow-Blohm): Monsun (BO-
                                              209-B).
O-320-E1F..................................  M.B.B.: Monsun (BO-209-B).
O-320-E2A..................................  Piper Aircraft: Cherokee
                                              (PA-28 ``140'', PA-28
                                              ``150'').
                                             Robin: Major (DR-340),
                                              Sitar, Bagheera (GY-100-
                                              135).
                                             S.O.C.A.T.A.: Super Rallye
                                              (MS-886), Rallye Commodore
                                              (MS-892).
                                             Siai-Marchetti: (S-202).
                                             F.F.A.: Bravo (AS-202/15).
                                             Partenavia: Oscar (P66B),
                                              Bucker (131 APM).
                                             Aeromot: Paulistina P-56.

[[Page 37959]]

 
                                             Pezetel: Koliber 150.
O-320-E2C..................................  Beech Aircraft: Musketeer
                                              III (M-23III).
                                             M.B.B.: Monsun (BO-209-B).
O-320-E2D..................................  Cessna Aircraft: Cardinal
                                              (172-I, 177).
O-320-E2F..................................  M.B.B.: Monsun (BO-209-B),
                                              Wassmer Pacific (WA-51).
O-320-E2G..................................  American Aviation Corp.:
                                              Traveler.
O-320-E3D..................................  Piper Aircraft: Cherokee
                                              (140).
                                             Beech Aircraft: Sport.
IO-320-B2A.................................  Piper Aircraft: Twin
                                              Comanche (PA-30).
IO-320-B1C.................................  Hi. Shear: Wing.
IO-320-B1D.................................  Ted Smith Aircraft:
                                              Aerostar.
IO-320-C1A.................................  Piper Aircraft: Twin
                                              Comanche (PA-30 Turbo).
IO-320-D1A.................................  M.B.B.: Monsun (BO-209-C).
IO-320-D1B.................................  M.B.B.: Monsun (BO-209-C).
IO-320-E1A.................................  M.B.B.: Monsun (BO-209-C).
IO-320-E1B.................................  Bellanca Aircraft.
IO-320-E2A.................................  Champion Aircraft:
                                              Citabria.
IO-320-E2B.................................  Bellanca Aircraft.
IO-320-F1A.................................  CAAR Engineering: Carr
                                              Midget.
LIO-320-B1A................................  Piper Aircraft: Twin
                                              Comanche (PA-39).
LIO-320-C1A................................  Piper Aircraft: Twin
                                              Comanche (PA-39).
AIO-320-B1B................................  M.B.B.: Monsun (BO-209-C).
AEIO-320-D1B...............................  Slingsby: T67M Firefly.
AEIO-320-D2B...............................  Hundustan Aeronautics Ltd.:
                                              HT-2.
AEIO-320-E1A...............................  Bellanca Aircraft.
                                             Champion Aircraft.
AEIO-320-E1B...............................  Bellanca Aircraft.
                                             Champion Aircraft:
                                              Decathalon (8KCAB-CS).
AEIO-320-E2B...............................  Bellanca Aircraft.
                                             Champion Aircraft:
                                              Decathalon (8KCAB).
O-320-A1A..................................  Riley Aircraft: Riley Twin.
O-360-A1A..................................  Beech Aircraft: Travel Air
                                              (95, B-95).
                                             Piper Aircraft: Comanche
                                              (PA-24).
                                             Intermountain Mfg. Co.:
                                              Call Air (A-6).
                                             Lake Aircraft: Colonial (C-
                                              2, LA-4, 4A or 4P).
                                             Doyn Aircraft: Doyn-Cessna
                                              (170B, 172, 172A, 172B).
                                             Mooney Aircraft: Mark
                                              ``20B'' (M-20B).
                                             Earl Horton: Pawnee (Piper
                                              PA-25).
                                             Dinfia: Ranquel (1A-51).
                                             Neiva: (1PD-5901).
                                             Regente: (N-591).
                                             Wassmer: Super 4 (WA-50A),
                                              Sancy (WA-40), Baladou (WA-
                                              40), Pariou (WA-40).
                                             Sud: Gardan (GY-180).
                                             Boelkow: (207).
                                             Partenavia: Oscar (P-66).
                                             Siai-Marchetti: (S-205).
                                             Procaer: Picchio (F-15-A).
                                             S.A.A.B.: Safir (91-D).
                                             Malmo: Vipan (MF-10B).
                                             Aero Boero: AB-180.
                                             Beagle: Airedale (A-109).
                                             DeHavilland: Drover (DHA-
                                              3MK3).
                                             Kingsford-Smith: Bushmaster
                                              (J5-6).
                                             Aero Engine Service Ltd.:
                                              Victa (R-2).
O-360-A1AD.................................  S.O.C.A.T.A.: Tabago TB-10.
O-360-A1D..................................  Piper Aircraft: Comanche
                                              (PA-24).
                                             Lake Aircraft: Colonial (LA-
                                              4, 4A or 4P).
                                             Doyn Aircraft: Doyn-Beech
                                              (Beech 95).
                                             Mooney Aircraft: Master
                                              ``21'' (M-20E), Mark
                                              ``20B'', ``20D'', (M20B,
                                              M20C), Mooney Statesman (M-
                                              20G).
                                             Dinfia: Querandi (1A-45).
                                             Wassmer: (WA-50).
                                             Malmo: Vipan (MF1-10).
                                             Cessna Aircraft: Skyhawk.
                                             Doyn Aircraft: Doyn-Piper
                                              (PA-23 ``160'').
O-360-A1F6.................................  Cessna Aircraft: Cardinal.
O-360-A1F6D................................  Cessna Aircraft: Cardinal
                                              177.
                                             Teal III: TSC (1A3).
O-360-A1G6.................................  Aero Commander.
O-360-A1G6D................................  Beech Aircraft: Duchess 76.
O-360-A1H6.................................  Piper Aircraft: Seminole
                                              (PA-44).
O-360-A1LD.................................  Wassmer: Europa WA-52.
O-360-A1P..................................  Aviat: Husky.

[[Page 37960]]

 
O-360-A2A..................................  Center Est Aeronautique:
                                              Regente (DR-253).
                                             S.O.C.A.T.A.: Rallye
                                              Commodore (MS-893).
                                             Societe Aeronautique
                                              Normande: Mousquetaire (D-
                                              140).
                                             Boelkow: Klemm (K1-107C).
                                             Partenavia: Oscar (P-66).
                                             Beagle: Husky (D5-180) (J1-
                                              U).
O-360-A2D..................................  Piper Aircraft: Comanche
                                              (PA-24), Cherokee ``C''
                                              (PA-28 ``180'').
                                             Mooney Aircraft: Master
                                              ``21'' (M-20D), Mark
                                              ``21'' (M-20E).
O-360-A2E..................................  Std. Helicopter.
O-360-A2F..................................  Aero Commander: Lark (100).
                                             Cessna Aircraft: Cardinal.
O-360-A2G..................................  Beech Aircraft: Sport.
O-360-A3A..................................  C.A.A.R.P.S.A.N.: (M-
                                              23III).
                                             Societe Aeronautique
                                              Normande: Jodel (D-140C).
                                             Robin: Regent (DR400/180),
                                              Remorqueur (DR400/180R), R-
                                              3170.
                                             S.O.C.A.T.A.: Rallye 180GT,
                                              Sportavia Sportsman (RS-
                                              180).
                                             Norman Aeroplace Co.: NAC-1
                                              Freelance.
                                             Nash Aircraft Ltd.: Petrel.
O-360-A3AD.................................  S.O.C.A.T.A.: TB-10.
                                             Robin: Aiglon (R-1180T).
O-360-A4A..................................  Piper Aircraft: Cherokee
                                              ``D'' (PA-28 ``180'').
O-360-A4D..................................  Varga: Kachina.
O-360-A4G..................................  Beech Aircraft: Musketeer
                                              Custom III.
O-360-A4K..................................  Grumman American: Tiger.
                                             Beech Aircraft: Sundowner
                                              180.
O-360-A4M..................................  Piper Aircraft: Archer II
                                              (PA-28 ``18'').
                                             Valmet: PIK-23.
O-360-A4N..................................  Cessna Aircraft: 172
                                              (Optional).
O-360-A4P..................................  Penn Yan: Super Cub
                                              Conversion.
O-360-A5AD.................................  C. Itoh and Co.: Fuji FA-
                                              200.
O-360-B2C..................................  Seabird Aviation: SB7L.
O-360-C1A..................................  Intermountain Mfg. Co.:
                                              Call Air (A-6).
O-360-C1E..................................  Bellanca Aircraft: Scout
                                              (8GCBC-CS).
O-360-C1F..................................  Maule: Star Rocket MX-7-
                                              180.
O-360-C1G..................................  Christen: Husky (A-1).
O-360-C2B..................................  Hughes Tool Co.: (269A).
O-360-C2D..................................  Hughes Tool Co.: (269A).
O-360-C2E..................................  Hughes Tool Co.: (YHO-2HU)
                                              Military.
                                             Bellanca Aircraft: Scout
                                              (8GCBC FP).
O-360-C4F..................................  Maule: MX-7-180A.
O-360-C4P..................................  Penn Yan: Super Cub
                                              Conversion.
O-360-F1A6.................................  Cessna Aircraft: Cutlass
                                              RG.
O-360-J2A..................................  Robinson: R22.
IO-360-B1A.................................  Beech Aircraft: Travel-Air
                                              (B-95A).
                                             Doyn Aircraft: Doyn-Piper
                                              (PA-23 ``200'').
IO-360-B1B.................................  Beech Aircraft: Travel-Air
                                              (B-95B).
                                             Doyn Aircraft: Doyn-Piper
                                              (PA-23 ``200'').
                                             Fuji: (FA-200).
IO-360-B1D.................................  United Consultants: See-
                                              Bee.
IO-360-B1E.................................  Piper Aircraft: Arrow (PA-
                                              28 ``180R'').
IO-360-B1F.................................  Utva: 75.
IO-360-B2E.................................  C.A.A.R.P. C.A.P. (10).
IO-360-B1F6................................  Great Lakes: Trainer.
IO-360-B1G6................................  American Blimp: Spector 42.
IO-360-B2F6................................  Great Lakes: Trainer.
LO-360-A1G6D...............................  Beech Aircraft: Duchess.
LO-360-A1H6................................  Piper Aircraft: Seminole
                                              (PA-44).
IO-360-E1A.................................  T.R. Smith Aircraft:
                                              Aerostar.
IO-360-L2A.................................  Cessna Aircraft: Skyhawk C-
                                              172.
IO-360-M1A.................................  Diamond Aircraft: DA-40.
IO-360-M1B.................................  Vans Aircraft: RV6, RV7,
                                              RV8.
                                             Lancair: 360.
AEIO-360-B1F...............................  F.F.A.: Bravo (200).
                                             Grob: G115/Sport-Acro.
AEIO-360-B1G6..............................  Great Lakes.
AEIO-360-B2F...............................  Mundry: CAP-10.
AEIO-360-B4A...............................  Pitts: S-1S.
AEIO-360-H1A...............................  Bellanca Aircraft: Super
                                              Decathalon (8KCAB-180).
AEIO-360-H1B...............................  American Champion: Super
                                              Decathalon.
VO-360-A1A.................................  Brantly Hynes Helicopter:
                                              (B-2).
VO-360-A1B.................................  Brantly Hynes Helicopter:
                                              (B-2, B2-A). Military (YHO-
                                              3BR).
VO-360-B1A.................................  Brantly Hynes Helicopter:
                                              (B-2, B2-A).

[[Page 37961]]

 
IVO-360-A1A................................  Brantly Hynes Helicopter:
                                              (B2-B).
HO-360-B1A.................................  Hughes Tool Co.: (269A).
HO-360-B1B.................................  Hughes Tool Co.: (269A).
HO-360-C1A.................................  Schweizer: (300C).
HIO-360-B1A................................  Hughes Tool Co.: Military
                                              (269-A-1), (TH-55A).
HIO-360-B1B................................  Hughes Tool Co.: (269A).
HIO-360-G1A................................  Schweizer: (CB).
O-540-A1A..................................  Rhein-Flugzeugbau: (RF-1).
O-540-A1A5.................................  Piper Aircraft: Comanche
                                              (PA-24 ``180'').
                                             Helio: Military (H-250).
                                             Yoeman Aviation: (YA-1).
O-540-A1B5.................................  Piper Aircraft: Aztec (PA-
                                              23 ``250''), Comanche (PA-
                                              24 ``250'').
O-540-A1C5.................................  Piper Aircraft: Comanche
                                              (PA-24 ``250'').
O-540-A1D..................................  Found Bros.: (FBA-2C).
                                             Dornier: (DO-28-B1).
O-540-A1D5.................................  Piper Aircraft: Aztec (PA-
                                              23 ``250''), Comanche (PA-
                                              24 ``250''), Military
                                              Aztec (U-11A).
                                             Dornier: (DO-28).
O-540-A2B..................................  Aero Commander: (500).
                                             Mid-States Mfg. Co.: Twin
                                              Courier (H-500), (U-5).
O-540-A3D5.................................  Piper Aircraft: Navy Aztec
                                              (PA-23 ``250'').
O-540-B1A5.................................  Piper Aircraft: Apache (PA-
                                              23 ``235'').
O-540-B1B5.................................  Piper Aircraft: Comanche
                                              (PA-24 ``250'').
                                             Doyn Aircraft: Doyn-Piper
                                              (PA-24 ``250'').
O-540-B1D5.................................  Wassmer: (WA-421).
O-540-B2B5.................................  Piper Aircraft: Pawnee (PA-
                                              25 ``235''), Cherokee (PA-
                                              28 ``235''), Aztec (PA-23
                                              ``235'').
                                             Intermountain Mfg. Co.:
                                              Call Air (A-9).
                                             Rawdon Bros.: Rawdon (T-1).
                                             S.O.C.A.T.A.: Rallye 235CA.
O-540-B2C5.................................  Piper Aircraft: Pawnee (PA-
                                              25 ``235'').
O-540-B4B5.................................  Piper Aircraft: Cherokee
                                              (PA-28 ``235'').
                                             Embraer: Corioca (EMB-710).
                                             S.O.C.A.T.A.: Rallye 235GT,
                                              Rallye 235C.
                                             Maule: Star Rocket (MX-7-
                                              235), Super Rocket (M-6-
                                              235), Super Std. Rocket (M-
                                              7-235).
O-540-E4A5.................................  Piper Aircraft: Comanche
                                              (PA-24 ``260'').
                                             Aviamilano: Flamingo (F-
                                              250).
                                             Siai-Marchetti: (SF-260),
                                              (SF-208).
O-540-E4B5.................................  Britten-Norman: (BN-2).
                                             Piper Aircraft: Cherokee
                                              Six (PA-32 ``260'').
O-540-E4C5.................................  Pilatus Britten-Norman:
                                              Islander (BN-2A-26),
                                              Islander (BN-2A-27),
                                              Islander II (BN-2B-26),
                                              Islander (BN-2A-21),
                                              Trislander (BN-2A-Mark III-
                                              2).
O-540-F1B5.................................  Omega Aircraft: (BS-12D1).
                                             Robinson: (R-44).
O-540-G1A5.................................  Piper Aircraft: Pawnee (PA-
                                              25 ``260'').
O-540-H1B5D................................  Aero Boero: 260.
O-540-H2A5.................................  Embraer: Impanema ``AG''.
                                             Gippsland: GA-200.
O-540-H2B5D................................  Aero Boero: 260.
O-540-J1A5D................................  Maule: Star Rocket (MX-7-
                                              235), Super Rocket (M-6-
                                              235), Super Std. Rocket (M-
                                              7-235).
O-540-J3A5.................................  Robin: R-3000/235.
O-540-J3A5D................................  Piper Aircraft: Dakota (PA-
                                              28-236).
O-540-J3C5D................................  Cessna Aircraft: Skylane
                                              RG.
O-540-L3C5D................................  Cessna Aircraft: TR-182,
                                              Turbo Skylane RG.
IO-540-C1B5................................  Piper Aircraft: Aztec B (PA-
                                              23 ``250''), Comanche (PA-
                                              24 ``250'').
IO-540-C1C5................................  Riley Aircraft: Turbo-
                                              Rocket.
IO-540-C4B5................................  Piper Aircraft: Aztec C (PA-
                                              23 ``250''), Aztec F.
                                             Wassmer: (WA4-21).
                                             Avions Pierre Robin: (HR100/
                                              250).
                                             Bellanca Aircraft: Aries T-
                                              250.
                                             Aerofab: Renegade 250.
IO-540-C4D5................................  S.O.C.A.T.A.: TB-20.
IO-540-C4D5D...............................  S.O.C.A.T.A.: Trinidad TB-
                                              20.
IO-540-D4A5................................  Piper Aircraft: Comanche
                                              (PA-24 ``260'').
                                             Siai-Marchetti: (SF-260).
IO-540-D4B5................................  Cerva: (CE-43 Guepard).
IO-540-J4A5................................  Piper Aircraft: Aztec (PA-
                                              23 ``250'').
IO-540-R1A5................................  Piper Aircraft: Comanche
                                              (PA-24).
IO-540-T4A5D...............................  General Aviation: Model
                                              114.
IO-540-T4B5................................  Commander: 114B.
IO-540-T4B5D...............................  Rockwell: 114.
IO-540-T4C5D...............................  Lake Aircraft: Seawolf.
IO-540-V4A5................................  Maule: MT-7-260, M-7-260.
                                             Aircraft Manufacturing
                                              Factory.

[[Page 37962]]

 
IO-540-V4A5D...............................  Brooklands: Scoutmaster.
IO-540-W1A5................................  Maule: MX-7-235, MT-7-235,
                                              M7-235.
IO-540-W1A5D...............................  Maule: Star Rocket (MX-7-
                                              235), Super Rocket (M-6-
                                              235), Super Std. Rocket (M-
                                              7-235).
IO-540-W3A5D...............................  Schweizer: Power Glider.
AEIO-540-D4A5..............................  Christen: Pitts (S-2S), (S-
                                              2B).
                                             Siai-Marchetti: SF-260.
                                             H.A.L.: HPT-32.
                                             Slingsby: Firefly T3A.
AEIO-540-D4B5..............................  Moravan: Zlin-50L.
                                             H.A.L.: HPT-32.
AEIO-540-D4D5..............................  Burkhart Grob: Grob G, 115T
                                              Aero.
TIO-540-C1A................................  Piper Aircraft: Turbo Aztec
                                              (PA-23-250).
TIO-540-K1AD...............................  Piper Aircraft.
TIO-540-AA1AD..............................  Aerofab Inc.: Turbo
                                              Renegade (270).
TIO-540-AB1AD..............................  S.O.C.A.T.A.: Trinidad TC
                                              TB-21.
TIO-540-AB1BD..............................  Schweizer.
TIO-540-AF1A...............................  Mooney Aircraft: ``TLS''
                                              M20M.
TIO-540-AG1A...............................  Commander Aircraft: 114TC.
TIO-540-AK1A...............................  Cessna Aircraft: Turbo
                                              Skylane T182T.
LTIO-540-K1AD..............................  Piper Aircraft.
------------------------------------------------------------------------

Unsafe Condition

    (e) This AD results from reports of 10 additional cylinder head 
separations since issuing AD 2008-19-05, on cylinder serial numbers 
not listed in that AD. We are issuing this AD to prevent loss of 
engine power due to cracks at the head-to-barrel interface in the 
cylinder assemblies and possible engine failure caused by separation 
of a cylinder head, which could result in loss of control of the 
aircraft.

Compliance

    (f) You are responsible for having the actions required by this 
AD performed within the compliance times specified unless the 
actions have already been done.

Engines Overhauled or Cylinder Assemblies Replaced Since New

    (g) If your engine was overhauled or had a cylinder assembly 
replaced since new, do the following:
    (1) Before further flight, inspect the maintenance records and 
engine logbook to determine if the overhaul or repair facility used 
ECi cylinder assemblies, P/N AEL65102, with cylinder head, PN 
AEL85099, with a SN 1138-02 through SN 35171-22, or a SN 35239-01 
through SN 42179-30, installed.
    (2) If the cylinder assemblies are not ECi, P/N AEL65102, no 
further action is required.
    (3) If the cylinder assemblies are ECi, P/N AEL65102, and if the 
SN is not listed in this AD, no further action is required.
    (4) If the cylinder assemblies are ECi, P/N AEL65102, and if the 
SN is listed in this AD, do the following:

Group ``A'' Cylinder Assemblies

    (i) For Group ``A'' cylinder assemblies:
    (A) Perform an initial visual inspection as specified in 
paragraphs (h) through (i) of this AD, and an initial compression 
test as specified in paragraphs (j) through (n) of this AD, within 
the next 10 operating hours time-in-service (TIS), if the cylinder 
assembly has 350 or more operating hours TIS on the effective date 
of this AD, but fewer than 2,000 operating hours TIS.
    (B) Perform an initial visual inspection as specified in 
paragraphs (h) through (i) of this AD, and an initial compression 
test as specified in paragraphs (j) through (n) of this AD, within 
the next 10 operating hours TIS, or before exceeding 350 operating 
hours TIS, whichever occurs later, if the cylinder assembly has 
fewer than 350 operating hours TIS on the effective date of this AD.
    (C) Replace cylinder assemblies installed in helicopter engines 
within the next 25 operating hours TIS after the effective date of 
this AD if the cylinder assembly has 1,500 operating hours TIS or 
more on the effective date of this AD.
    (D) Replace cylinder assemblies installed in airplane engines 
within the next 25 operating hours TIS after the effective date of 
this AD if the cylinder assembly has 2,000 operating hours TIS or 
more on the effective date of this AD.
    (E) Perform repetitive visual inspections as specified in 
paragraphs (h) through (i) of this AD, and repetitive compression 
tests as specified in paragraphs (j) through (n) of this AD, within 
every 50 operating hours TIS.
    (F) Replace cylinder assemblies installed in helicopter engines 
that pass the visual inspections and compression tests, no later 
than 1,500 operating hours TIS after the effective date of this AD.
    (G) Replace cylinder assemblies installed in airplane engines 
that pass the visual inspections and compression tests, no later 
than 2,000 operating hours TIS after the effective date of this AD.

Group ``B'' Cylinder Assemblies

    (ii) For Group ``B'' cylinder assemblies:
    (A) Perform an initial visual inspection as specified in 
paragraphs (h) through (i) of this AD, and initial compression test 
as specified in paragraphs (j) through (n) of this AD, within the 
next 10 operating hours TIS.
    (B) Replace the cylinder assembly within the next 25 operating 
hours TIS after the effective date of this AD if the cylinder 
assembly has 350 or more operating hours TIS on the effective date 
of this AD.
    (C) Replace cylinder assemblies that pass the initial visual 
inspections and compression tests, before exceeding 350 operating 
hours TIS after the effective date of this AD.

Visual Inspection

    (h) Visually inspect each cylinder head around the exhaust valve 
side for cracks or any signs of black or white residue of combustion 
leakage from cracks.
    (i) Replace cracked cylinder assemblies before further flight.

Cylinder Assembly Compression Test

    (j) Perform a standard cylinder differential compression test.
    (k) During the compression test, if the cylinder pressure gauge 
reads below 70 pounds-per-square-inch, apply a water and soap 
solution to the side of the leaking cylinder, near the head-to-
barrel interface.
    (l) Replace the cylinder assembly before further flight if air 
leakage and bubbles are observed on the side of the cylinder 
assembly, near the head-to-barrel interface.
    (m) Repair or replace the engine cylinder assembly before 
further flight if the cause of the low gauge reading in paragraph 
(l) of this AD is from leaking intake or exhaust valves, or from 
leaking piston rings.

Prohibition of ECi Cylinder Assemblies Affected by This AD

    (n) After the effective date of this AD, do not install any ECi 
cylinder assembly, P/N AEL65102, with cylinder head, P/N AEL85099, 
and with SN 1138-02 through SN 35171-22, or SN 35239-01 through SN 
42179-30, onto any engine, and do not attempt to repair or reuse 
these ECi cylinder assemblies.

Alternative Methods of Compliance

    (o) The Manager, Special Certification Office, has the authority 
to approve alternative methods of compliance for this

[[Page 37963]]

AD if requested using the procedures found in 14 CFR 39.19.

Special Flight Permits

    (p) Under 14 CFR part 39.23, we will not approve special flight 
permits for this AD for engines that have failed the visual 
inspection or the cylinder assembly compression test required by 
this AD.

Related Information

    (q) Contact Peter W. Hakala, Aerospace Engineer, Special 
Certification Office, FAA, Rotorcraft Directorate, 2601 Meacham 
Blvd., Fort Worth, TX 76193; e-mail: [email protected]; 
telephone (817) 222-5145; fax (817) 222-5785, for more information 
about this AD.

    Issued in Burlington, Massachusetts, on July 21, 2009.
Peter A. White,
Assistant Manager, Engine and Propeller Directorate, Aircraft 
Certification Service.
[FR Doc. E9-18118 Filed 7-29-09; 8:45 am]
BILLING CODE 4910-13-P