[Federal Register Volume 73, Number 34 (Wednesday, February 20, 2008)]
[Rules and Regulations]
[Pages 9181-9183]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: E8-2850]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2008-0165; Directorate Identifier 2007-SW-58-AD; 
Amendment 39-15377; AD 2008-04-05]
RIN 2120-AA64


Airworthiness Directives; Eurocopter Deutschland Model EC135 
Helicopters

AGENCY: Federal Aviation Administration (FAA), Department of 
Transportation (DOT).

ACTION: Final rule; request for comments.

-----------------------------------------------------------------------

SUMMARY: We are adopting a new airworthiness directive (AD) for 
Eurocopter Deutschland (Eurocopter) Model EC135 helicopters. This AD 
results from mandatory continuing airworthiness information (MCAI) 
originated by an aviation authority of another country to identify and 
correct an unsafe condition on an aviation product. The European 
Aviation Safety Agency (EASA), the Technical Agent for the Federal 
Republic of Germany, with which we have a bilateral agreement, states 
in the MCAI:

    During a flight a burning odour [sic] could be smelled in the 
cabin. Its reason was a short circuit in the LH cable channel, which 
was caused by a damaged wire harness. The wire harness was damaged 
by the side channel cover's attachment hardware.

The rubbing and chafing of the wiring harnesses in the tunnels 
underneath the channel cover, against the screws and rivets attaching 
the channel covers, could lead to a short circuit of the wiring 
harness.
    This AD requires actions that are intended to address this unsafe 
condition by preventing a short circuit resulting from a damaged wiring 
harness, which could subsequently lead to a fire in the helicopter.

DATES: This AD becomes effective on March 6, 2008.
    The Director of the Federal Register approved the incorporation by 
reference of Eurocopter Alert Service Bulletin EC135-53A-1017, Revision 
1, dated June 22, 2007, as of March 6, 2008.
    We must receive comments on this AD by April 21, 2008.

ADDRESSES: You may send comments by any of the following methods:
     Federal eRulemaking Portal: Go to http://www.regulations.gov. Follow the instructions for submitting comments.
     Fax: 202-493-2251.
     Mail: U.S. Department of Transportation, Docket 
Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New 
Jersey Avenue, SE., Washington, DC 20590.
     Hand Delivery: U.S. Department of Transportation, Docket 
Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New 
Jersey Avenue, SE., Washington, DC 20590, between 9 a.m. and 5 p.m., 
Monday through Friday, except Federal holidays.
    You may get the service information identified in this AD from 
American Eurocopter Corporation, 2701 Forum Drive, Grand Prairie, Texas 
75053-4005, telephone (972) 641-3460, fax (972) 641-3527.

Examining the AD Docket

    You may examine the AD docket on the Internet at http://www.regulations.gov or in person at the Docket Operations office 
between 9 a.m. and 5 p.m., Monday through Friday, except Federal 
holidays. The AD docket contains this AD, the economic evaluation, any 
comments received, and other information. The street address for the 
Docket Operations office (telephone (800) 647-5527) is in the ADDRESSES 
section. Comments will be available in the AD docket shortly after 
receipt.

FOR FURTHER INFORMATION CONTACT: Carroll Wright, Aviation Safety 
Engineer, FAA, Rotorcraft Directorate, Regulations and Policy Group, 
Fort Worth, Texas 76193-0111, telephone (817) 222-5120, fax (817) 222-
5961.

SUPPLEMENTARY INFORMATION:

Streamlined Issuance of AD

    The FAA is implementing a new process for streamlining the issuance 
of ADs related to MCAI. This streamlined process will allow us to adopt 
MCAI safety requirements in a more efficient manner and will reduce 
safety risks to the public. This process continues to follow all FAA AD 
issuance processes to meet legal, economic, Administrative Procedure 
Act, and Federal Register requirements. We also continue to meet our 
technical decision-making responsibilities to identify and correct 
unsafe conditions on U.S.-certificated products.
    This AD references the MCAI and related service information that we 
considered in forming the engineering basis to correct the unsafe 
condition. The AD contains text copied from the MCAI and for this 
reason might not follow our plain language principles.

Discussion

    The European Aviation Safety Agency (EASA), which is the technical 
agent for Member States of the European Community, has issued an MCAI 
in the form of EASA Emergency AD No. 2007-0021-E, dated January 19, 
2007, (referred to after this as ``the MCAI''), to correct an unsafe 
condition for this German-certificated helicopter. The MCAI states:

    During a flight a burning odour [sic] could be smelled in the 
cabin. Its reason was a short circuit in the LH cable channel, which 
was caused by a damaged wire harness. The wire harness was damaged 
by the side channel cover's attachment hardware.

The rubbing and chafing of the wiring harnesses in the tunnels 
underneath the channel cover, against the screws and rivets attaching 
the channel covers, could lead to a short circuit of the wiring harness 
and a subsequent fire in the helicopter.
    You may obtain further information by examining the MCAI and 
service information in the AD docket.

Relevant Service Information

    Eurocopter has issued Alert Service Bulletin No. EC135-53A-017, 
Revision 1, dated June 22, 2007. The actions described in the MCAI are 
intended to correct the same unsafe condition as

[[Page 9182]]

that identified in the service information.

FAA's Determination and Requirements of This AD

    This product has been approved by the aviation authority of the 
Federal Republic of Germany and is approved for operation in the United 
States. Pursuant to our bilateral agreement with this State of Design, 
we have been notified of the unsafe condition described in the MCAI and 
service information. We are issuing this AD because we evaluated all 
pertinent information and determined the unsafe condition exists and is 
likely to exist or develop on other products of the same type design.

Differences Between This AD and the MCAI or Service Information

    We have reviewed the MCAI and related service information and, in 
general, agree with their substance. This AD differs from the MCAI as 
follows:
     We do not require contacting the manufacturer for further 
instructions if a wiring harness is damaged but require that you 
replace a damaged wiring harness with an airworthy wiring harness.
     We do not require a February 28, 2007, compliance time 
because that date has passed.
     We include in the applicability the helicopter serial 
number (S/N) 0005 up to and including S/N 0576 as stated in the service 
information rather than the helicopter S/N 0005 up to and including 
0654 as stated in the MCAI.
     We refer to the compliance time as ``hours time-in-
service'' rather than ``flight hours.''
    These differences are highlighted in the ``Differences Between the 
FAA AD and the MCAI'' section in the AD.

Costs of Compliance

    We estimate that this AD will affect 156 helicopters of U.S. 
registry. We also estimate that it will take 5 hours to inspect a 
helicopter with a copilot collective lever cover and 4 hours to inspect 
a helicopter without a copilot collective lever cover. The average 
labor rate is $80 per work-hour. Required parts will cost about $400 
for a helicopter with a copilot collective lever cover and $320 for a 
helicopter without a copilot collective lever cover. Based on these 
figures, we estimate the total cost to be $124,800, assuming all the 
helicopters have a copilot collective lever cover.

FAA's Determination of the Effective Date

    An unsafe condition exists that requires the immediate adoption of 
this AD. The FAA has found that the risk to the flying public justifies 
waiving notice and comment prior to adoption of this rule because a 
short circuit and fire could occur from a damaged wiring harness. Each 
wiring harness must be inspected within a short period of time, 25 
hours time-in-service, for chafing and wear and modified as necessary 
to prevent a fire from occurring in the helicopter. Therefore, we 
determined that notice and opportunity for public comment before 
issuing this AD are impracticable and that good cause exists for making 
this amendment effective in fewer than 30 days.

Comments Invited

    This AD is a final rule that involves requirements affecting flight 
safety, and we did not precede it by notice and opportunity for public 
comment. We invite you to send any written relevant data, views, or 
arguments about this AD. Send your comments to an address listed under 
the ADDRESSES section. Include ``Docket No. FAA-2008-0165; Directorate 
Identifier 2007-SW-58-AD'' at the beginning of your comments. We 
specifically invite comments on the overall regulatory, economic, 
environmental, and energy aspects of this AD. We will consider all 
comments received by the closing date and may amend this AD because of 
those comments.
    We will post all comments we receive, without change, to http://www.regulations.gov, including any personal information you provide. We 
will also post a report summarizing each substantive verbal contact we 
receive about this AD.

Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to 
issue rules on aviation safety. Subtitle I, section 106, describes the 
authority of the FAA Administrator. ``Subtitle VII: Aviation 
Programs,'' describes in more detail the scope of the Agency's 
authority.
    We are issuing this rulemaking under the authority described in 
``Subtitle VII, Part A, Subpart III, Section 44701: General 
requirements.'' Under that section, Congress charges the FAA with 
promoting safe flight of civil aircraft in air commerce by prescribing 
regulations for practices, methods, and procedures the Administrator 
finds necessary for safety in air commerce. This regulation is within 
the scope of that authority because it addresses an unsafe condition 
that is likely to exist or develop on products identified in this 
rulemaking action.

Regulatory Findings

    We determined that this AD will not have federalism implications 
under Executive Order 13132. This AD will not have a substantial direct 
effect on the States, on the relationship between the national 
government and the States, or on the distribution of power and 
responsibilities among the various levels of government.
    For the reasons discussed above, I certify this AD:
    1. Is not a ``significant regulatory action'' under Executive Order 
12866;
    2. Is not a ``significant rule'' under the DOT Regulatory Policies 
and Procedures (44 FR 11034, February 26, 1979); and
    3. Will not have a significant economic impact, positive or 
negative, on a substantial number of small entities under the criteria 
of the Regulatory Flexibility Act.
    We prepared an economic evaluation of the estimated costs to comply 
with this AD and placed it in the AD docket.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

0
Accordingly, under the authority delegated to me by the Administrator, 
the FAA amends 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0
1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

0
2. The FAA amends Sec.  39.13 by adding the following new AD:

2008-04-05 Eurocopter Deutschland: Amendment 39-15377. Docket No. 
FAA-2008-0165; Directorate Identifier 2007-SW-58-AD.

Effective Date

    (a) This airworthiness directive (AD) becomes effective on March 
6, 2008.

Other Affected ADs

    (b) None.

Applicability

    (c) This AD applies to Model EC135 helicopters, serial number 
0005 up to and including 0576, certificated in any category.

[[Page 9183]]

Subject

    (d) Air Transport Association of America (ATA) Code: 5321, 
Frame; and 1497, Miscellaneous wiring.

Reason

    (e) The mandatory continued airworthiness information (MCAI) 
states:

    During a flight a burning odour [sic] could be smelled in the 
cabin. Its reason was a short circuit in the LH cable channel, which 
was caused by a damaged wire harness. The wire harness was damaged 
by the side channel cover's attachment hardware.

The rubbing and chafing of the wiring harnesses in the tunnels 
underneath the channel cover, against the screws and rivets 
attaching the channel covers, could lead to a short circuit of the 
wiring harness and a subsequent fire in the helicopter.

Actions and Compliance

    (f) Within 25 hours time-in-service (TIS), unless already done, 
do the following:
    (1) Inspect the wiring harnesses for chafing and wear in the 
areas shown in Figure 1 of Eurocopter Alert Service Bulletin EC135-
53A-017, Revision 1, dated June 22, 2007 (ASB).
    (i) If chafing or wear is found on the wiring harness, before 
further flight, replace the wiring harness with an airworthy wiring 
harness.
    (ii) If no chafing or wear is found, modify the side channel 
covers by affixing double-sided adhesive tape in the area depicted 
in Figure 2 of the ASB by following the Accomplishment Instructions, 
paragraph C, of the ASB.
    (2) Modify the attachment of the copilot collective lever cover 
as depicted in Figure 3 of the ASB by following the Accomplishment 
Instructions, paragraph D, of the ASB.
    (3) Attach chafing protection to the wiring harnesses and 
replace affected screws as depicted in and in accordance with Figure 
4 of the ASB and by following the Accomplishment Instructions, 
paragraphs E and F, of the ASB. Paragraph F(2) of the ASB applies 
only to helicopters with a copilot collective lever cover.

Differences Between the FAA AD and the MCAI

    (g) This AD differs from the MCAI as follows:
    (1) We do not require contacting the manufacturer for further 
instructions if a wiring harness is damaged but require that you 
replace a damaged wiring harness with an airworthy wiring harness.
    (2) We do not require a February 28, 2007, compliance time 
because that date has passed.
    (3) We have used the helicopter S/N 0005 up to and including S/N 
0576 as stated in the service information rather than the helicopter 
S/N 0005 up to and including 0654 as stated in the MCAI.
    (4) We refer to the compliance time as ``hours TIS'' rather than 
``flight hours.''

Other FAA AD Provisions

    (h) The following provisions also apply to this AD:
    (1) Alternative Methods of Compliance (AMOCs): The Manager, 
Safety Management Group, FAA, has the authority to approve AMOCs for 
this AD, if requested using the procedures found in 14 CFR 39.19. 
Send information to ATTN: Carroll Wright, Aviation Safety Engineer, 
Rotorcraft Directorate, Regulations and Policy Group, Fort Worth, 
Texas 76193-0111, telephone (817) 222-5120, fax (817) 222-5961.
    (2) Airworthy Product: Use only FAA-approved corrective actions. 
Corrective actions are considered FAA-approved if they are approved 
by the State of Design Authority (or their delegated agent) if the 
State of Design has an appropriate bilateral agreement with the 
United States. You are required to assure the product is airworthy 
before it is returned to service.
    (3) Reporting Requirements: For any reporting requirement in 
this AD, under the provisions of the Paperwork Reduction Act, the 
Office of Management and Budget (OMB) has approved the information 
collection requirements and has assigned OMB Control Number 2120-
0056.

Related Information

    (i) Mandatory Continuing Airworthiness Information (MCAI) 
Emergency Airworthiness Directive No. 2007-0021-E, dated January 19, 
2007, contains related information.

Material Incorporated by Reference

    (j) The Director of the Federal Register approved the 
incorporation by reference of Eurocopter Alert Service Bulletin 
EC135-53A-017, Revision 1, dated June 22, 2007, under 5 U.S.C. 
552(a) and 1 CFR part 51.
    (k) For the Eurocopter service information identified in this 
AD, contact American Eurocopter Corporation, 2701 Forum Drive, Grand 
Prairie, Texas 75053-4005, telephone (972) 641-3460, fax (972) 641-
3527.
    (l) You may review copies of the Eurocopter service information 
at the FAA, Office of the Regional Counsel, Southwest Region, 2601 
Meacham Blvd., Room 663, Fort Worth, Texas, or at the National 
Archives and Records Administration (NARA). For information on the 
availability of this material at NARA, call (202) 741-6030, or go 
to: http://www.archives.gov/federal-register/cfr/ibr-locations.html.

    Issued in Fort Worth, Texas, on February 6, 2008.
Scott A. Horn,
Acting Manager, Rotorcraft Directorate, Aircraft Certification Service.
[FR Doc. E8-2850 Filed 2-19-08; 8:45 am]
BILLING CODE 4910-13-P