[Federal Register Volume 70, Number 178 (Thursday, September 15, 2005)]
[Rules and Regulations]
[Pages 54472-54474]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 05-18199]



[[Page 54472]]

=======================================================================
-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2005-21410; Directorate Identifier 2005-CE-31-AD; 
Amendment 39-14272; AD 2005-19-07]
RIN 2120-AA64


Airworthiness Directives; Raytheon Aircraft Company Model 390 
Airplanes

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Final rule.

-----------------------------------------------------------------------

SUMMARY: The FAA adopts a new airworthiness directive (AD) for certain 
Raytheon Aircraft Company (Raytheon) Model 390 airplanes. This AD 
requires you to replace the rudder pedal arm assemblies used in the 
rudder control system with parts of improved design. This AD results 
from reports of cracks found on the rudder pedal arm assemblies. We are 
issuing this AD to prevent failure of the rudder pedal arm assemblies 
caused by fatigue cracks. This failure could lead to loss of rudder 
control, loss of nose gear steering, and loss of toe brakes on the side 
on which the failure occurs.

DATES: This AD becomes effective on October 31, 2005.
    As of October 31, 2005, the Director of the Federal Register 
approved the incorporation by reference of certain publications listed 
in the regulation.

ADDRESSES: To get the service information identified in this AD, 
contact Raytheon Aircraft Company, 9709 E. Central, Wichita, Kansas 
67201-0085; telephone: (800) 429-5372 or (316) 676-3140.
    To view the AD docket, go to the Docket Management Facility; U.S. 
Department of Transportation, 400 Seventh Street, SW., Nassif Building, 
Room PL-401, Washington, DC 20590-001 or on the Internet at http://dms.dot.gov. The docket number is FAA-2005-21410; Directorate 
Identifier 2005-CE-31-AD.

FOR FURTHER INFORMATION CONTACT: David Ostrodka, Aerospace Engineer, 
Wichita Aircraft Certification Office (ACO), FAA, 1801 Airport Road, 
Wichita, Kansas 67209; telephone: (316) 946-4129; facsimile: (316) 946-
4107; e-mail: [email protected].

SUPPLEMENTARY INFORMATION: 

Discussion

    What events have caused this AD? Raytheon received a report that, 
during ground maintenance operations, the pilot's outboard rudder pedal 
arm assembly cracked at the upper end of the arm.
    While maneuvering the aircraft from a right turn to neutral with 
toe brake applied during an on-ground compass swing, the rudder pedal 
arm assembly cracked.
    Further investigation revealed another airplane with a crack on the 
copilot's outboard rudder pedal arm assembly.
    Raytheon has determined that loading of the rudder pedals off the 
centerline of the rudder pedal arm assembly results in overload, which 
causes fatigue cracking of the rudder pedal arm assembly.
    What is the potential impact if FAA took no action? If not 
prevented, cracks in the rudder pedal arm assembly could cause the 
rudder pedal arm assembly to fail. This failure could lead to loss of 
rudder control, loss of nose gear steering, and loss of toe brakes on 
the side on which the failure occurs.
    Has FAA taken any action to this point? We issued a proposal to 
amend part 39 of the Federal Aviation Regulations (14 CFR part 39) to 
include an AD that would apply to certain Raytheon Model 390 airplanes. 
This proposal was published in the Federal Register as a notice of 
proposed rulemaking (NPRM) on June 20, 2005 (70 FR 35385). The NPRM 
proposed to require you to replace the rudder pedal arm assemblies, 
part numbers (P/Ns) 390-524350-0001, 390-524350-0002, 390-524351-0001, 
and 390-524351-0002 with improved design parts, P/Ns 390-524400-0001, 
390-524400-0002, 390-524401-0003, and 390-524401-0004.

Comments

    Was the public invited to comment? We provided the public the 
opportunity to participate in developing this AD. We received no 
comments on the proposal or on the determination of the cost to the 
public.

Conclusion

    What is FAA's final determination on this issue? We have carefully 
reviewed the available data and determined that air safety and the 
public interest require adopting the AD as proposed except for minor 
editorial corrections. We have determined that these minor corrections:
--Are consistent with the intent that was proposed in the NPRM for 
correcting the unsafe condition; and
--Do not add any additional burden upon the public than was already 
proposed in the NPRM.

Changes to 14 CFR Part 39--Effect on the AD

    How does the revision to 14 CFR part 39 affect this AD? On July 10, 
2002, the FAA published a new version of 14 CFR part 39 (67 FR 47997, 
July 22, 2002), which governs the FAA's AD system. This regulation now 
includes material that relates to altered products, special flight 
permits, and alternative methods of compliance. This material 
previously was included in each individual AD. Since this material is 
included in 14 CFR part 39, we will not include it in future AD 
actions.

Costs of Compliance

    How many airplanes does this AD impact? We estimate that this AD 
affects 98 airplanes in the U.S. registry.
    What is the cost impact of this AD on owners/operators of the 
affected airplanes? We estimate the following costs to accomplish the 
modification:

----------------------------------------------------------------------------------------------------------------
                                                        Total cost per
             Labor cost                  Parts cost        airplane           Total cost on  U.S. operators
----------------------------------------------------------------------------------------------------------------
8 work hours x $65 per hour = $520..          $1,165           $1,685   $1,685 x 98 = $165,130.
----------------------------------------------------------------------------------------------------------------

    Raytheon will provide warranty credit for parts and labor to the 
extent stated in the service information. Therefore, the required 
actions, if done following the service information, will have little or 
no cost to the owners/operators of the affected airplanes.

Authority for This Rulemaking

    What authority does FAA have for issuing this rulemaking action? 
Title 49 of the United States Code specifies the FAA's authority to 
issue rules on aviation safety. Subtitle I, section 106 describes the 
authority of the FAA Administrator. Subtitle VII, Aviation Programs, 
describes in more detail the scope of the agency's authority.
    We are issuing this rulemaking under the authority described in 
subtitle VII, part A, subpart III, section 44701, ``General 
requirements.'' Under that section, Congress charges the FAA with

[[Page 54473]]

promoting safe flight of civil aircraft in air commerce by prescribing 
regulations for practices, methods, and procedures the Administrator 
finds necessary for safety in air commerce. This regulation is within 
the scope of that authority because it addresses an unsafe condition 
that is likely to exist or develop on products identified in this AD.

Regulatory Findings

    Will this AD impact various entities? We have determined that this 
AD will not have federalism implications under Executive Order 13132. 
This AD will not have a substantial direct effect on the States, on the 
relationship between the national government and the States, or on the 
distribution of power and responsibilities among the various levels of 
government.
    Will this AD involve a significant rule or regulatory action? For 
the reasons discussed above, I certify that this AD:
    1. Is not a ``significant regulatory action'' under Executive Order 
12866;
    2. Is not a ``significant rule'' under the DOT Regulatory Policies 
and Procedures (44 FR 11034, February 26, 1979); and
    3. Will not have a significant economic impact, positive or 
negative, on a substantial number of small entities under the criteria 
of the Regulatory Flexibility Act.
    We prepared a summary of the costs to comply with this AD (and 
other information as included in the Regulatory Evaluation) and placed 
it in the AD Docket. You may get a copy of this summary by sending a 
request to us at the address listed under ADDRESSES. Include ``Docket 
No. FAA-2005-21410; Directorate Identifier 2005-CE-31-AD'' in your 
request.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

0
Accordingly, under the authority delegated to me by the Administrator, 
the Federal Aviation Administration amends part 39 of the Federal 
Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0
1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

0
2. FAA amends Sec.  39.13 by adding a new AD to read as follows:

2005-19-07 Raytheon Aircraft Company: Amendment 39-14272; Docket No. 
FAA-2005-21410; Directorate Identifier 2005-CE-31-AD.

When Does This AD Become Effective?

    (a) This AD becomes effective on October 31, 2005.

What Other ADs Are Affected by This Action?

    (b) None.

What Airplanes Are Affected by This AD?

    (c) This AD affects the following serial-numbered Model 390 
airplanes that are certificated in any category:

Serial Numbers

(1) RB-1
(2) RB-4 through RB-36
(3) RB-38 through RB-41
(4) RB-43 through RB-67
(5) RB-69 through RB-80
(6) RB-82 through RB-84
(7) RB-87 through RB-94
(8) RB-96 through RB-101
(9) RB-103 through RB-115
(10) RB-117 through RB-119
(11) RB-121

What Is the Unsafe Condition Presented in This AD?

    (d) This AD is the result of reports of cracks found on the 
rudder pedal arm assemblies used in the rudder control system. The 
actions specified in this AD are intended to prevent failure of the 
rudder pedal arm assemblies caused by fatigue cracks. This failure 
could lead to loss of rudder control, loss of nose gear steering, 
and loss of toe brakes on the side on which the failure occurs.

What Must I Do To Address This Problem?

    (e) To address this problem, you must do the following:

------------------------------------------------------------------------
           Actions                 Compliance            Procedures
------------------------------------------------------------------------
(1) Replace rudder pedal arm  Upon accumulating     Follow Raytheon
 assemblies, part numbers (P/  300 hours time-in-    Aircraft Company
 Ns) 390-524350-0001, 390-     service (TIS) or      Mandatory Service
 524350-0002, 390-524351-      within 100 hours      Bulletin, SB 27-
 0001, and 390-524351-0002     TIS after October     3691, Rev. 1,
 with improved design parts,   31, 2005 (the         Revised: February,
 P/Ns 390-524400-0001, 390-    effective date of     2005, and the
 524400-0002, 390-524401-      this AD), whichever   applicable
 0003, and 390-524401-0004.    occurs later,         maintenance manual.
                               unless already done.
(2) Do not install rudder     As of October 31,     Not applicable.
 pedal arm assemblies, P/Ns    2005 (the effective
 390-524350-0001, 390-524350-  date of this AD).
 0002, 390-524351-0001, and
 390-524351-0002.
------------------------------------------------------------------------


    Note: Replacing the rudder pedal arm assemblies following 
Raytheon Aircraft Company Mandatory Service Bulletin, SB 27-3691, 
Issued: October 2004, does not comply with this AD.

May I Request an Alternative Method of Compliance?

    (f) You may request a different method of compliance or a 
different compliance time for this AD by following the procedures in 
14 CFR 39.19. Unless FAA authorizes otherwise, send your request to 
your principal inspector. The principal inspector may add comments 
and will send your request to the Manager, Wichita Aircraft 
Certification Office (ACO), FAA. For information on any already 
approved alternative methods of compliance, contact David Ostrodka, 
Aerospace Engineer, Wichita ACO, FAA, 1801 Airport Road, Wichita, 
Kansas 67209; telephone: (316) 946-4129; facsimile: (316) 946-4107; 
e-mail: [email protected].

Does This AD Incorporate Any Material by Reference?

    (g) You must do the actions required by this AD following the 
instructions in Raytheon Aircraft Company Mandatory Service 
Bulletin, SB 27-3691, Rev. 1, Revised: February, 2005. The Director 
of the Federal Register approved the incorporation by reference of 
this service bulletin in accordance with 5 U.S.C. 552(a) and 1 CFR 
part 51. To get a copy of this service information, contact Raytheon 
Aircraft Company, 9709 E. Central, Wichita, Kansas 67201-0085; 
telephone: (800) 429-5372 or (316) 676-3140. To review copies of 
this service information, go to the National Archives and Records 
Administration (NARA). For information on the availability of this 
material at NARA, go to: http://www.archives.gov/federal_register/code_of_federal_regulations/ibr_locations.html or call (202) 
741-6030. To view the AD docket, go to the Docket Management 
Facility; U.S. Department of Transportation, 400 Seventh Street, 
SW., Nassif Building, Room PL-401, Washington, DC 20590-001 or on 
the Internet at http://dms.dot.gov. The docket number is FAA-2005-
21410; Directorate Identifier 2005-CE-31-AD.


[[Page 54474]]


    Issued in Kansas City, Missouri, on September 8, 2005.
David R. Showers,
Acting Manager, Small Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 05-18199 Filed 9-14-05; 8:45 am]
BILLING CODE 4910-13-P