[Federal Register Volume 69, Number 111 (Wednesday, June 9, 2004)]
[Rules and Regulations]
[Pages 32251-32252]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 04-12818]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 2003-NM-94-AD; Amendment 39-13664; AD 2004-12-05]
RIN 2120-AA64


Airworthiness Directives; BAE Systems (Operations) Limited Model 
BAe 146 Series Airplanes

AGENCY: Federal Aviation Administration, DOT.

ACTION: Final rule.

-----------------------------------------------------------------------

SUMMARY: This amendment adopts a new airworthiness directive (AD), 
applicable to all BAE Systems (Operations) Limited Model BAe 146 series 
airplanes, that requires repetitive detailed inspections of the inside 
of each air conditioning sound-attenuating duct, and corrective actions 
as necessary. This action is necessary to prevent impairment of the 
operational skills and abilities of the flightcrew caused by the 
inhalation of agents released from oil or oil breakdown products, which 
could result in reduced controllability of the airplane. This action is 
intended to address the identified unsafe condition.

DATES: Effective July 14, 2004.
    The incorporation by reference of certain publications listed in 
the regulations is approved by the Director of the Federal Register as 
of July 14, 2004.

ADDRESSES: The service information referenced in this AD may be 
obtained from British Aerospace Regional Aircraft American Support, 
13850 Mclearen Road, Herndon, Virginia 20171. This information may be 
examined at the Federal Aviation Administration (FAA), Transport 
Airplane Directorate, Rules Docket, 1601 Lind Avenue, SW., Renton, 
Washington; or at the National Archives and Records Administration 
(NARA). For information on the availability of this material at NARA, 
call (202) 741-6030, or go to: http://www.archives.gov/federal_register/code_of_federal_regulations/ibr_locations.html.

FOR FURTHER INFORMATION CONTACT: Todd Thompson, Aerospace Engineer, 
International Branch, ANM-116, FAA, Transport Airplane Directorate, 
1601 Lind Avenue, SW., Renton, Washington 98055-4056; telephone (425) 
227-1175; fax (425) 227-1149.

SUPPLEMENTARY INFORMATION: A proposal to amend part 39 of the Federal 
Aviation Regulations (14 CFR part 39) to include an airworthiness 
directive (AD) that is applicable to all BAE Systems (Operations) 
Limited Model BAe 146 series airplanes published in the Federal 
Register on April 15, 2004 (69 FR 19954). That action proposed to 
require repetitive detailed inspections of the inside of each air 
conditioning sound-attenuating duct, and corrective actions as 
necessary.

Comments

    Interested persons have been afforded an opportunity to participate 
in the making of this amendment. No comments were submitted in response 
to the proposal or the FAA's determination of the cost to the public.

Conclusion

    We have determined that air safety and the public interest require 
the adoption of the rule as proposed.

Interim Action

    This is considered to be interim action until final action is 
identified, at which time the FAA may consider further rulemaking.

[[Page 32252]]

Cost Impact

    We estimate that 20 airplanes of U.S. registry will be affected by 
this AD, that it will take approximately 5 work hours per airplane to 
accomplish the required actions, and that the average labor rate is $65 
per work hour. Based on these figures, the cost impact of the AD on 
U.S. operators is estimated to be $6,500, or $325 per airplane, per 
inspection cycle.
    The cost impact figure discussed above is based on assumptions that 
no operator has yet accomplished any of the requirements of this AD 
action, and that no operator would accomplish those actions in the 
future if this AD were not adopted. The cost impact figures discussed 
in AD rulemaking actions represent only the time necessary to perform 
the specific actions actually required by the AD. These figures 
typically do not include incidental costs, such as the time required to 
gain access and close up, planning time, or time necessitated by other 
administrative actions.

Regulatory Impact

    The regulations adopted herein will not have a substantial direct 
effect on the States, on the relationship between the national 
Government and the States, or on the distribution of power and 
responsibilities among the various levels of government. Therefore, it 
is determined that this final rule does not have federalism 
implications under Executive Order 13132.
    For the reasons discussed above, I certify that this action (1) is 
not a ``significant regulatory action'' under Executive Order 12866; 
(2) is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979); and (3) will not have a 
significant economic impact, positive or negative, on a substantial 
number of small entities under the criteria of the Regulatory 
Flexibility Act. A final evaluation has been prepared for this action 
and it is contained in the Rules Docket. A copy of it may be obtained 
from the Rules Docket at the location provided under the caption 
ADDRESSES.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

0
Accordingly, pursuant to the authority delegated to me by the 
Administrator, the Federal Aviation Administration amends part 39 of 
the Federal Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0
1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

0
2. Section 39.13 is amended by adding the following new airworthiness 
directive:

2004-12-05 BAE Systems (Operations) Limited (Formerly British 
Aerospace Regional Aircraft): Amendment 39-13664. Docket 2003-NM-94-
AD.

    Applicability: All Model BAe 146 series airplanes, certificated 
in any category.
    Compliance: Required as indicated, unless accomplished 
previously.
    To prevent impairment of the operational skills and abilities of 
the flightcrew caused by the inhalation of agents released from oil 
or oil breakdown products, which could result in reduced 
controllability of the airplane, accomplish the following:

Repetitive Inspections and Corrective Action

    (a) Within 120 days or 500 flight cycles after the effective 
date of this AD, whichever is first: Do a detailed inspection of the 
inside of each of the four air conditioning sound-attenuating ducts 
for the presence of oil contamination, and corrective actions as 
applicable. Do all of the applicable actions per BAE Systems 
(Operations) Limited Inspection Service Bulletin ISB.21-156, dated 
October 31, 2002. Any corrective action must be done before further 
flight. Repeat the inspection thereafter at intervals not to exceed 
4,000 flight cycles.

    Note 1: For the purposes of this AD, a detailed inspection is 
defined as: ``An intensive visual examination of a specific 
structural area, system, installation, or assembly to detect damage, 
failure, or irregularity. Available lighting is normally 
supplemented with a direct source of good lighting at intensity 
deemed appropriate by the inspector. Inspection aids such as mirror, 
magnifying lenses, etc., may be used. Surface cleaning and elaborate 
access procedures may be required.''

Submission of Information Not Required

    (b) Although the service bulletin specifies to report inspection 
results to the manufacturer, this AD does not include such a 
requirement.

Alternative Methods of Compliance

    (c) In accordance with 14 CFR 39.19, the Manager, International 
Branch, ANM-116, FAA, Transport Airplane Directorate, is authorized 
to approve alternative methods of compliance for this AD.

Incorporation by Reference

    (d) The actions shall be done in accordance with BAE Systems 
(Operations) Limited Inspection Service Bulletin ISB.21-156, dated 
October 31, 2002. This incorporation by reference was approved by 
the Director of the Federal Register in accordance with 5 U.S.C. 
552(a) and 1 CFR part 51. Copies may be obtained from British 
Aerospace Regional Aircraft American Support, 13850 Mclearen Road, 
Herndon, Virginia 20171. Copies may be inspected at the FAA, 
Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, 
Washington; or at the National Archives and Records Administration 
(NARA). For information on the availability of this material at 
NARA, call (202) 741-6030, or go to: http://www.archives.gov/federal_register/code_of_federal_regulations/ibr_locations.html.

    Note 2: The subject of this AD is addressed in British 
airworthiness directive 003-10-2002.

Effective Date

    (e) This amendment becomes effective on July 14, 2004.

    Issued in Renton, Washington, on May 28, 2004.
Kevin M. Mullin,
Acting Manager, Transport Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 04-12818 Filed 6-8-04; 8:45 am]
BILLING CODE 4910-13-P