[Federal Register Volume 69, Number 63 (Thursday, April 1, 2004)]
[Rules and Regulations]
[Pages 17033-17034]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 04-7235]



 ========================================================================
 Rules and Regulations
                                                 Federal Register
 ________________________________________________________________________
 
 This section of the FEDERAL REGISTER contains regulatory documents 
 having general applicability and legal effect, most of which are keyed 
 to and codified in the Code of Federal Regulations, which is published 
 under 50 titles pursuant to 44 U.S.C. 1510.
 
 The Code of Federal Regulations is sold by the Superintendent of Documents. 
 Prices of new books are listed in the first FEDERAL REGISTER issue of each 
 week.
 
 ========================================================================
 

  Federal Register / Vol. 69, No. 63 / Thursday, April 1, 2004 / Rules 
and Regulations  

[[Page 17033]]



DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 2003-NE-46-AD; Amendment 39-13557; AD 2004-07-13]
RIN 2120-AA64


Airworthiness Directives; General Electric Company CF6-80C2 
Series Turbofan Engines

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Final rule.

-----------------------------------------------------------------------

SUMMARY: The FAA is adopting a new airworthiness directive (AD) for 
General Electric Company (GE) CF6-80C2 series turbofan engines. This AD 
requires replacing certain high pressure turbine (HPT) stage 1 disks at 
or before reaching a new reduced life cycle limit. This AD is prompted 
by an updated low-cycle-fatigue (LCF) analysis of the HPT stage 1 disk. 
We are issuing this AD to prevent LCF cracking and failure of the HPT 
stage 1 disk due to exceeding the life limit, which could result in an 
uncontained engine failure and damage to the airplane.

DATES: This AD becomes effective May 6, 2004.

ADDRESSES:
    You can get the service information identified in this AD from 
General Electric Company via Lockheed Martin Technology Services, 10525 
Chester Road, Suite C, Cincinnati, Ohio 45215; telephone (513) 672-
8400; fax (513) 672-8422.
    You may examine the AD docket, by appointment, at the FAA, New 
England Region, Office of the Regional Counsel, 12 New England 
Executive Park, Burlington, MA. You may examine the service 
information, by appointment, at the FAA, New England Region, Office of 
the Regional Counsel, 12 New England Executive Park, Burlington, MA.

FOR FURTHER INFORMATION CONTACT: Karen Curtis, Aerospace Engineer, 
Aircraft Certification Office, FAA, Engine and Propeller Directorate, 
12 New England Executive Office Park, Burlington, MA 01803; telephone 
(781) 238-7192; fax (781) 238-7199.

SUPPLEMENTARY INFORMATION: The FAA proposed to amend 14 CFR part 39 
with a proposed AD. The proposed AD applies to GE CF6-80C2 series 
turbofan engines. We published the proposed AD in the Federal Register 
on November 12, 2003 (68 FR 64001). That action proposed to require 
replacing certain HPT stage 1 disks at or before reaching a new reduced 
life cycle limit.

Comments

    We provided the public the opportunity to participate in the 
development of this AD. We have considered the comments received.
    One commenter states that the overall impact to him is minimal. The 
commenter does not request any changes to the proposal as written. The 
FAA agrees.
    One commenter requests that the proposal be withdrawn. The 
commenter believes that an AD is not necessary because the lower life 
limit has already been published by the manufacturer in Chapter 5, 
Airworthiness Limitations, of the engine manual.
    The FAA does not agree. Changes to life limits that appear only in 
a manual or type certificate data sheet, even if FAA-approved, are not 
enforceable for all operators. Life limit reductions from the original 
certified limits become enforceable for all operators only through the 
AD process (14 CFR part 39).

Conclusion

    We have carefully reviewed the available data, including the 
comments received, and determined that air safety and the public 
interest require adopting the AD as proposed.

Changes to 14 CFR Part 39--Effect on the AD

    On July 10, 2002, the FAA published a new version of 14 CFR part 39 
(67 FR 47997, July 22, 2002), which governs the FAA's AD system. That 
regulation now includes material that relates to altered products, 
special flight permits, and alternative methods of compliance. The 
material previously was included in each individual AD. Since the 
material is included in 14 CFR part 39, we will not include it in 
future AD actions.

Costs of Compliance

    There are about 526 CF6-80C2A5F, CF6-80C2B5F, CF6-80C2B7F, and CF6-
80C2D1F turbofan engines of the affected design in the worldwide fleet. 
We estimate that 208 engines installed on airplanes of U.S. registry 
would be affected by this AD. The action does not impose any additional 
labor costs. The prorated cost of a new HPT stage 1 disk is about 
$43,306 per engine. Based on these figures, and on the prorating for 
the usage of the HPT stage 1 disks, the cost of the AD on U.S. 
operators is estimated to be $9,007,648.

Regulatory Findings

    We have determined that this AD will not have federalism 
implications under Executive Order 13132. This AD will not have a 
substantial direct effect on the States, on the relationship between 
the national government and the States, or on the distribution of power 
and responsibilities among the various levels of government.
    For the reasons discussed above, I certify that this AD:
    (1) Is not a ``significant regulatory action'' under Executive 
Order 12866;
    (2) Is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979); and
    (3) Will not have a significant economic impact, positive or 
negative, on a substantial number of small entities under the criteria 
of the Regulatory Flexibility Act.
    We prepared a summary of the costs to comply with this AD and 
placed it in the AD Docket. You may get a copy of this summary by 
sending a request to us at the address listed under ADDRESSES. Include 
``AD Docket No. 2003-NE-46-AD'' in your request.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Safety.

Adoption of the Amendment

0
Accordingly, under the authority delegated to me by the Administrator, 
the Federal Aviation Administration amends 14 CFR part 39 as follows:

[[Page 17034]]

PART 39--AIRWORTHINESS DIRECTIVES

0
1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

0
2. The FAA amends Sec.  39.13 by adding the following new airworthiness 
directive (AD):

2004-07-13 General Electric Company: Amendment 39-13557. Docket No. 
2003-NE-46-AD.

Effective Date

    (a) This AD becomes effective May 6, 2004.

Affected ADs

    (b) None.

Applicability

    (c) This AD applies to General Electric Company (GE) CF6-
80C2A5F, CF6-80C2B5F, CF6-80C2B7F, and CF6-80C2D1F turbofan engines 
with high pressure turbine (HPT) stage 1 disks, part numbers (P/Ns) 
1531M84G10 or 1531M84G12 installed. These engines are installed on, 
but not limited to, Airbus Industrie A300 and A330 series, Boeing 
747 and 767 series, and McDonnell Douglas MD-11 airplanes.

Unsafe Condition

    (d) This AD is prompted by an updated low-cycle-fatigue (LCF) 
analysis of the HPT stage 1 disk. The actions specified in this AD 
are intended to prevent LCF cracking and failure of the HPT stage 1 
disk due to exceeding the life limit, which could result in an 
uncontained engine failure and damage to the airplane.

Compliance

    (e) You are responsible for having the actions required by this 
AD performed within the compliance times specified unless the 
actions have already been done.
    (f) Replace HPT stage 1 disks, P/Ns 1531M84G10 and 1531M84G12, 
at or before the disk accumulates 10,720 cycles-since-new (CSN).
    (g) After the effective date of this AD, do not install any HPT 
stage 1 disk, P/N 1531M84G10 or 1531M84G12, that exceeds 10,720 CSN.

Alternative Methods of Compliance

    (h) The Manager, Engine Certification Office, has the authority 
to approve alternative methods of compliance for this AD if 
requested using the procedures found in 14 CFR 39.19.

Material Incorporated by Reference

    (i) None.

Related Information

    (j) None.

    Issued in Burlington, Massachusetts, on March 24, 2004.
Francis A. Favara,
Acting Manager, Engine and Propeller Directorate, Aircraft 
Certification Service.
[FR Doc. 04-7235 Filed 3-31-04; 8:45 am]
BILLING CODE 4910-13-P