[Federal Register Volume 66, Number 42 (Friday, March 2, 2001)]
[Proposed Rules]
[Pages 13213-13216]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 01-4950]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 2000-NM-243-AD]
RIN 2120-AA64


Airworthiness Directives; Boeing Model 767-200 Series Airplanes 
Modified by Supplemental Type Certificate ST09022AC-D

AGENCY: Federal Aviation Administration, DOT.

ACTION: Notice of proposed rulemaking (NPRM).

-----------------------------------------------------------------------

SUMMARY: This document proposes the adoption of a new airworthiness 
directive (AD) that is applicable to all Boeing Model 767-200 series 
airplanes modified by supplemental type certificate ST09022AC-D. This 
proposal would require modifying the passenger entertainment system 
(PES) and revising the Airplane Operations Manual. This action is 
necessary to ensure that the flight crew is able to remove electrical 
power from the entire PES when necessary and is advised of appropriate 
procedures for such action. Inability to remove power from the PES 
during a non-normal or emergency situation could result in inability to 
control smoke or fumes in the airplane flight deck or cabin. This 
action is intended to address the identified unsafe condition.

DATES: Comments must be received by April 16, 2001.

ADDRESSES: Submit comments in triplicate to the Federal Aviation 
Administration (FAA), Transport Airplane Directorate, ANM-114, 
Attention: Rules Docket No. 2000-NM-243-AD, 1601 Lind Avenue, SW., 
Renton, Washington 98055-4056. Comments may be inspected at this 
location between 9:00 a.m. and 3:00 p.m., Monday through Friday, except 
Federal holidays. Comments may be submitted via fax to (425) 227-1232. 
Comments may also be sent via the Internet using the following address: 
[email protected]. Comments sent via fax or the Internet must 
contain ``Docket No. 2000-NM-243-AD'' in the subject line and need not 
be submitted in triplicate. Comments sent via the Internet as attached 
electronic files must be formatted in Microsoft Word 97 for Windows or 
ASCII text.
    The service information referenced in the proposed rule may be 
obtained from Raytheon Systems Company, Intelligence Information and 
Aircraft Integration Systems, 7500 Maehre Road, Waco, Texas 76705. This 
information may be examined at the FAA, Transport Airplane Directorate, 
1601 Lind Avenue, SW., Renton, Washington; or at the FAA, Fort Worth 
Airplane Certification Office, 2601 Meacham Blvd., Fort Worth, Texas.

FOR FURTHER INFORMATION CONTACT: Ingrid Knox, Aerospace Engineer, FAA, 
Fort Worth Airplane Certification Office, ASW-150, 2601 Meacham Blvd., 
Fort Worth, Texas 76137-4298; telephone (817) 222-5139; fax (817) 222-
5960.

SUPPLEMENTARY INFORMATION:

Comments Invited

    Interested persons are invited to participate in the making of the 
proposed rule by submitting such written data, views, or arguments as 
they may desire. Communications shall identify the Rules Docket number 
and be submitted in triplicate to the address specified above. All 
communications received on or before the closing date for comments, 
specified above, will be considered before taking action on the 
proposed rule. The proposals contained in this action may be changed in 
light of the comments received.
    Submit comments using the following format:
     Organize comments issue-by-issue. For example, discuss a 
request to change the compliance time and a request to change the 
service bulletin reference as two separate issues.
     For each issue, state what specific change to the proposed 
AD is being requested.
     Include justification (e.g., reasons or data) for each 
request.
    Comments are specifically invited on the overall regulatory, 
economic, environmental, and energy aspects of the proposed rule. All 
comments submitted will be available, both before and after the closing 
date for comments, in the Rules Docket for examination by interested 
persons. A report summarizing each FAA-public contact concerned with 
the substance of this

[[Page 13214]]

proposal will be filed in the Rules Docket.
    Commenters wishing the FAA to acknowledge receipt of their comments 
submitted in response to this action must submit a self-addressed, 
stamped postcard on which the following statement is made: ``Comments 
to Docket Number 2000-NM-243-AD.'' The postcard will be date-stamped 
and returned to the commenter.

Availability of NPRMs

    Any person may obtain a copy of this NPRM by submitting a request 
to the FAA, Transport Airplane Directorate, ANM-114, Attention: Rules 
Docket No. 2000-NM-243-AD, 1601 Lind Avenue, SW., Renton, Washington 
98055-4056.

Discussion

    The Federal Aviation Administration (FAA) recently completed a 
review of in-flight entertainment (IFE) systems certified by 
supplemental type certificate (STC) and installed on transport category 
airplanes. The review focused on the interface between the IFE system 
and airplane electrical system, with the objective of determining if 
any unsafe conditions exist with regard to the interface. STC's issued 
between 1992 and 2000 were considered for the review.
    The type of IFE systems considered for review were those that 
contain video monitors (cathode ray tubes or liquid crystal displays; 
either hanging above the aisle or mounted on individual seat backs or 
seat trays), or complex circuitry (i.e., power supplies, electronic 
distribution boxes, extensive wire routing, relatively high power 
consumption, multiple layers of circuit protection, etc.). In addition, 
in-seat power supply systems that provide power to more than 20 percent 
of the total passenger seats were also considered for the review. The 
types of IFE systems not considered for review include systems that 
provide only audio signals to each passenger seat, ordinary in-flight 
telephone systems (e.g., one telephone handset per group of seats or 
bulkhead-mounted telephones), systems that only have a video monitor on 
the forward bulkhead(s) (or a projection system) to provide passengers 
with basic airplane and flight information, and in-seat power supply 
systems that provide power to less than 20 percent of the total 
passenger seats.
    Items considered during the review include the following:
     Can the electrical bus(es) supplying power to the IFE 
system be deenergized when necessary without removing power from 
systems that may be required for continued safe flight and landing?
     Can IFE system power be removed when required without 
pulling IFE system circuit breakers? [i.e., is there a switch 
(dedicated to the IFE system or a combination of loads) located in the 
flight deck or cabin that can be used to remove IFE power?]
     If the IFE system requires changes to flight crew 
procedures, has the airplane flight manual (AFM) been properly amended?
     If the IFE system requires changes to cabin crew 
procedures, have they been properly amended?
     Does the IFE system require periodic or special 
maintenance?
    In all, approximately 180 IFE systems approved by STC were reviewed 
by the FAA. The review results indicate that potential unsafe 
conditions exist on some IFE systems installed on various transport 
category airplanes. These conditions can be summarized as:
     Electrical bus(es) supplying power to the IFE system 
cannot be deenergized when necessary without removing power from 
systems that may be required for continued safe flight and landing.
     Power cannot be removed from the IFE system when required 
without pulling IFE system circuit breakers (i.e., there is no switch 
dedicated to the IFE system or combination of systems for the purpose 
of removing power).
     Installation of the IFE system has affected crew (flight 
crew and/or cabin crew) procedures, but the procedures have not been 
properly revised.

FAA's Determination

    As part of its review of IFE systems, the FAA has determined that 
an unsafe condition exists on Boeing Model 767-200 series airplanes 
modified by STC ST09022AC-D. Power to the Airshow System, a subsystem 
of the passenger entertainment system (PES) installed by that STC, is 
not currently controlled by the same power switch that controls power 
to the rest of the PES. Thus, there is no means available to the flight 
crew to remove power from the Airshow System without locating and 
pulling circuit breakers for the system. This condition, if not 
corrected, could result in failure to remove power from the entire PES 
during a non-normal or emergency situation, and consequent inability to 
control smoke or fumes in the airplane flight deck or cabin.

Explanation of Relevant Service Information

    The FAA has reviewed and approved Raytheon Service Bulletin 767VIP-
24-1, dated August 28, 2000, which describes procedures for modifying 
the PES to install a load shed relay and associated wiring for the 
Airshow System portion of the PES. This modification will allow power 
for the Airshow System to be controlled by the same switch as power to 
the remainder of the PES.
    The FAA also has reviewed and approved Raytheon Airplane Operations 
Manual Supplement 767-27G, dated October 18, 2000, which describes 
revisions to certain sections of the Airplane Operations Manual to 
advise the flight crew of the function of the utility bus switch 
located on the flight deck, including the use of this switch to remove 
power from the PES. Accomplishment of the actions specified in the 
service bulletin and the Airplane Operations Manual Supplement is 
intended to adequately address the identified unsafe condition.

Explanation of Requirements of Proposed Rule

    Since an unsafe condition has been identified that is likely to 
exist or develop on other products of this same type design, the 
proposed AD would require accomplishment of the actions specified in 
the service bulletin and Airplane Operations Manual Supplement 
described previously, except as discussed below.

Differences Between Proposed Rule and Service Bulletin

    Operators should note that the service bulletin specifies that the 
actions therein should be accomplished at the next maintenance 
opportunity, but not later than 12 months after receipt of the service 
bulletin. In developing an appropriate compliance time for this action, 
the FAA considered not only the degree of urgency associated with 
addressing the subject unsafe condition, but the amount of time 
necessary to accomplish the proposed actions, the availability of 
necessary parts, and the practical aspect of accomplishing the proposed 
actions within an interval of time that parallels normal scheduled 
maintenance for the affected operators. In consideration of all of 
these factors, the FAA has determined that 18 months after the 
effective date of this AD represents an appropriate interval of time 
allowable wherein an acceptable level of safety can be maintained.

Other Relevant Proposed Rulemaking

    This proposed action is one of a number of proposed AD's on 
airplanes modified by STC's that have been determined to be subject to 
similar unsafe conditions. Other currently proposed AD's include the 
following airplanes and STC's:

[[Page 13215]]



----------------------------------------------------------------------------------------------------------------
             Model/Series                            STC number                         Docket number
----------------------------------------------------------------------------------------------------------------
Boeing 757-200........................  SA1727GL                             2000-NM-228-AD
----------------------------------------------------------------------------------------------------------------
McDonnell Douglas DC-9-51 and DC-9-83.  SA8026NM                             2000-NM-229-AD
----------------------------------------------------------------------------------------------------------------
McDonnell Douglas DC-10-30............  ST00054SE                            2000-NM-231-AD
----------------------------------------------------------------------------------------------------------------
Boeing 767-300 and 767-300ER..........  SA5765NM                             2000-NM-232-AD
                                        SA5978NM
----------------------------------------------------------------------------------------------------------------
Boeing 767-300........................  ST00157SE                            2000-NM-233-AD
----------------------------------------------------------------------------------------------------------------
Boeing 747-100 and -200...............  ST00196SE                            2000-NM-234-AD
----------------------------------------------------------------------------------------------------------------
Boeing 767-200........................  SA5134NM                             2000-NM-235-AD
----------------------------------------------------------------------------------------------------------------
Boeing 767-300........................  ST00118SE                            2000-NM-236-AD
----------------------------------------------------------------------------------------------------------------
Boeing 737-300........................  ST00171SE                            2000-NM-237-AD
----------------------------------------------------------------------------------------------------------------
Boeing 767-200........................  SA4998NM                             2000-NM-238-AD
----------------------------------------------------------------------------------------------------------------
Boeing 767-300........................  SA7019NM-D                           2000-NM-239-AD
----------------------------------------------------------------------------------------------------------------
Boeing 747-100 and -200...............  SA8622SW                             2000-NM-240-AD
----------------------------------------------------------------------------------------------------------------
McDonnell Douglas DC-10-30............  SA8452SW                             2000-NM-241-AD
----------------------------------------------------------------------------------------------------------------
Boeing 737-700........................  ST09100AC-D                          2000-NM-242-AD
                                        ST09104AC-D
                                        ST09105AC-D
                                        ST09106AC-D
----------------------------------------------------------------------------------------------------------------
Boeing 747SP..........................  ST09097AC-D                          2000-NM-244-AD
----------------------------------------------------------------------------------------------------------------
Boeing 747-400........................  SA8843SW                             2000-NM-245-AD
----------------------------------------------------------------------------------------------------------------
Airbus A340-211.......................  ST0902AC-D                           2000-NM-246-AD
----------------------------------------------------------------------------------------------------------------

Cost Impact

    None of the airplanes affected by this action are on the U.S. 
Register. The single airplane included in the applicability of this 
proposed rule currently is operated by a non-U.S. operator under 
foreign registry; therefore, it is not directly affected by this AD 
action. However, the FAA considers that this proposed rule is necessary 
to ensure that the unsafe condition is addressed in the event that the 
subject airplane is imported and placed on the U.S. Register in the 
future.
    Should the affected airplane be imported and placed on the U.S. 
Register in the future, it would take approximately 80 work hours to 
accomplish the proposed modification, at an average labor rate of $60 
per work hour. Required parts would cost approximately $165,673 per 
airplane. Based on these figures, the cost impact of the proposed 
modification would be $170,473.
    Should the affected airplane be imported and placed on the U.S. 
Register in the future, it would take approximately 1 work hour to 
accomplish the proposed manual revision, at an average labor rate of 
$60 per work hour. Based on these figures, the cost impact of the 
proposed manual revision would be $60.
    The cost impact figures discussed above are based on assumptions 
that no operator has yet accomplished any of the proposed requirements 
of this AD action, and that no operator would accomplish those actions 
in the future if this proposed AD were not adopted. The cost impact 
figures discussed in AD rulemaking actions represent only the time 
necessary to perform the specific actions actually required by the AD. 
These figures typically do not include incidental costs, such as the 
time required to gain access and close up, planning time, or time 
necessitated by other administrative actions.

Regulatory Impact

    The regulations proposed herein would not have a substantial direct 
effect on the States, on the relationship between the national 
Government and the States, or on the distribution of power and 
responsibilities among the various levels of government. Therefore, it 
is determined that this proposal would not have federalism implications 
under Executive Order 13132.
    For the reasons discussed above, I certify that this proposed 
regulation (1) is not a ``significant regulatory action'' under 
Executive Order 12866; (2) is not a ``significant rule'' under the DOT 
Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); 
and (3) if promulgated, will not have a significant economic impact, 
positive or negative, on a substantial number of small entities under 
the criteria of the Regulatory Flexibility Act. A copy of the draft 
regulatory evaluation prepared for this action is contained in the 
Rules Docket. A copy of it may be obtained by contacting the Rules 
Docket at the location provided under the caption ADDRESSES.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Safety.

The Proposed Amendment

    Accordingly, pursuant to the authority delegated to me by the 
Administrator, the Federal Aviation Administration proposes to amend 
part 39 of the Federal Aviation Regulations (14 CFR part 39) as 
follows:

[[Page 13216]]

PART 39--AIRWORTHINESS DIRECTIVES

    1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec. 39.13  [Amended]

    2. Section 39.13 is amended by adding the following new 
airworthiness directive:

Boeing: Docket 2000-NM-243-AD.

    Applicability: Model 767-200 series airplanes modified by 
supplemental type certificate (STC) ST09022AC-D, certificated in any 
category.

    Note 1: This AD applies to each airplane identified in the 
preceding applicability provision, regardless of whether it has been 
otherwise modified, altered, or repaired in the area subject to the 
requirements of this AD. For airplanes that have been modified, 
altered, or repaired so that the performance of the requirements of 
this AD is affected, the owner/operator must request approval for an 
alternative method of compliance in accordance with paragraph (c) of 
this AD. The request should include an assessment of the effect of 
the modification, alteration, or repair on the unsafe condition 
addressed by this AD; and, if the unsafe condition has not been 
eliminated, the request should include specific proposed actions to 
address it.

    Compliance: Required as indicated, unless accomplished 
previously.
    To ensure that the flight crew is able to remove electrical 
power from the entire passenger entertainment system (PES) when 
necessary and is advised of appropriate procedures for such action, 
accomplish the following:

Modification and Airplane Operations Manual Revision

    (a) Within 18 months after the effective date of this AD, do 
paragraphs (a)(1) and (a)(2) of this AD.
    (1) Modify the PES to install a load shed relay and associated 
wiring for the Airshow System portion of the PES, in accordance with 
Raytheon Service Bulletin 767VIP-24-1, dated August 28, 2000.
    (2) Revise the Airplane Operations Manual to describe the 
function of the utility bus power switch located on the flight deck, 
including the use of this switch to remove power to the PES, in 
accordance with Raytheon Airplane Operations Manual Supplement 767-
27G, dated October 18, 2000.

Spares

    (b) As of the effective date of this AD, no person shall install 
a PES in accordance with STC ST09022AC-D on any airplane, unless it 
is modified and the Airplane Operations Manual is revised in 
accordance with this AD.

Alternative Methods of Compliance

    (c) An alternative method of compliance or adjustment of the 
compliance time that provides an acceptable level of safety may be 
used if approved by the Manager, Fort Worth Airplane Certification 
Office (ACO), FAA. Operators shall submit their requests through an 
appropriate FAA Principal Maintenance Inspector, who may add 
comments and then send it to the Manager, Fort Worth ACO.

    Note 2: Information concerning the existence of approved 
alternative methods of compliance with this AD, if any, may be 
obtained from the Fort Worth ACO.

Special Flight Permits

    (d) Special flight permits may be issued in accordance with 
Secs. 21.197 and 21.199 of the Federal Aviation Regulations (14 CFR 
21.197 and 21.199) to operate the airplane to a location where the 
requirements of this AD can be accomplished.

    Issued in Renton, Washington, on February 23, 2001.
Donald L. Riggin,
Acting Manager, Transport Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 01-4950 Filed 3-1-01; 8:45 am]
BILLING CODE 4910-13-U