[Federal Register Volume 64, Number 234 (Tuesday, December 7, 1999)]
[Proposed Rules]
[Pages 68300-68302]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 99-31678]
-----------------------------------------------------------------------
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
14 CFR Part 39
[Docket No. 99-NM-339-AD]
RIN 2120-AA64
Airworthiness Directives; Airbus Model A319, A320, and A321
Series Airplanes
AGENCY: Federal Aviation Administration, DOT.
ACTION: Notice of proposed rulemaking (NPRM).
-----------------------------------------------------------------------
SUMMARY: This document proposes the adoption of a new airworthiness
directive (AD) that is applicable to certain Airbus Model A319, A320,
and A321 series airplanes. This proposal would require modification of
the forward and aft evacuation slide systems by replacing the Velcro
restraints for the support logs with frangible link restraints. This
proposal is prompted by issuance of mandatory continuing airworthiness
information by a foreign civil airworthiness authority. The actions
specified by the proposed AD are intended to prevent the ingestion of
sill support-log material into the aspirator of the escape slide, which
could result in failure of the escape slide to inflate.
DATES: Comments must be received by January 6, 2000.
ADDRESSES: Submit comments in triplicate to the Federal Aviation
Administration (FAA), Transport Airplane Directorate, ANM-114,
Attention: Rules Docket No. 99-NM-339-AD, 1601 Lind Avenue, SW.,
Renton, Washington 98055-4056. Comments may be inspected at this
location between 9:00 a.m. and 3:00 p.m., Monday through Friday, except
Federal holidays.
The service information referenced in the proposed rule may be
obtained from Airbus Industrie, 1 Rond Point Maurice Bellonte, 31707
Blagnac Cedex, France. This information may be examined at the FAA,
Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton,
Washington.
FOR FURTHER INFORMATION CONTACT: Norman B. Martenson, Manager,
International Branch, ANM-116, FAA, Transport Airplane Directorate,
1601 Lind Avenue, SW., Renton, Washington 98055-4056; telephone (425)
227-2110; fax (425) 227-1149.
SUPPLEMENTARY INFORMATION:
Comments Invited
Interested persons are invited to participate in the making of the
proposed rule by submitting such written data, views, or arguments as
they may desire. Communications shall identify the Rules Docket number
and be submitted in triplicate to the address specified above. All
communications received on or before the closing date for comments,
specified above, will be considered before taking action on the
proposed rule. The proposals contained in this notice may be changed in
light of the comments received.
Comments are specifically invited on the overall regulatory,
economic, environmental, and energy aspects of the proposed rule. All
comments submitted will be available, both before and after the closing
date for comments, in the Rules Docket for examination by interested
persons. A report summarizing each FAA-public contact concerned with
the substance of this
[[Page 68301]]
proposal will be filed in the Rules Docket.
Commenters wishing the FAA to acknowledge receipt of their comments
submitted in response to this notice must submit a self-addressed,
stamped postcard on which the following statement is made: ``Comments
to Docket Number 99-NM-339-AD.'' The postcard will be date stamped and
returned to the commenter.
Availability of NPRMs
Any person may obtain a copy of this NPRM by submitting a request
to the FAA, Transport Airplane Directorate, ANM-114, Attention: Rules
Docket No. 99-NM-339-AD, 1601 Lind Avenue, SW., Renton, Washington
98055-4056.
Discussion
The Direction Generale de l'Aviation Civile (DGAC), which is the
airworthiness authority for France, notified the FAA that an unsafe
condition may exist on certain Airbus Model A319, A320, and A321 series
airplanes. The DGAC advises that one operator reported that, during a
deployment test of an escape slide, the escape slide did not inflate
completely due to ingestion of sill support-log material into the
aspirator caused by Velcro restraint separation during packing. This
condition, if not corrected, could result in failure of the escape
slide to inflate.
Explanation of Relevant Service Information
Airbus has issued Service Bulletin A320-25-1215, dated April 29,
1999, which describes procedures for modification of the forward and
aft evacuation slide systems to replace the Velcro restraints for the
support logs with a frangible link restraint. Accomplishment of the
actions specified in the service bulletin is intended to adequately
address the identified unsafe condition. The DGAC classified this
service bulletin as mandatory and issued French airworthiness directive
1999-356-136(B), dated September 8, 1999, in order to assure the
continued airworthiness of these airplanes in France.
The Airbus service bulletin refers to Air Cruisers Service Bulletin
S.B. 004-25-51, dated February 26, 1999, as an additional source of
service information for accomplishment of the modification.
FAA's Conclusions
These airplane models are manufactured in France and are type
certificated for operation in the United States under the provisions of
section 21.29 of the Federal Aviation Regulations (14 CFR 21.29) and
the applicable bilateral airworthiness agreement. Pursuant to this
bilateral airworthiness agreement, the DGAC has kept the FAA informed
of the situation described above. The FAA has examined the findings of
the DGAC, reviewed all available information, and determined that AD
action is necessary for products of this type design that are
certificated for operation in the United States.
Explanation of Requirements of Proposed Rule
Since an unsafe condition has been identified that is likely to
exist or develop on other airplanes of the same type design registered
in the United States, the proposed AD would require accomplishment of
the actions specified in the service bulletin described previously.
Cost Impact
The FAA estimates that 202 airplanes of U.S. registry would be
affected by this proposed AD, that it would take approximately 1 work
hour per airplane to accomplish the proposed modification, and that the
average labor rate is $60 per work hour. Required parts for the
modification of the evacuation slide are available from the evacuation
slide vendor without charge. Based on these figures, the cost impact of
the proposed AD on U.S. operators is estimated to be $12,120, or $60
per airplane.
The cost impact figure discussed above is based on assumptions that
no operator has yet accomplished any of the proposed requirements of
this AD action, and that no operator would accomplish those actions in
the future if this AD were not adopted.
Regulatory Impact
The regulations proposed herein would not have substantial direct
effects on the States, on the relationship between the national
government and the States, or on the distribution of power and
responsibilities among the various levels of government. Therefore, in
accordance with Executive Order 12612, it is determined that this
proposal would not have sufficient federalism implications to warrant
the preparation of a Federalism Assessment.
For the reasons discussed above, I certify that this proposed
regulation (1) is not a ``significant regulatory action'' under
Executive Order 12866; (2) is not a ``significant rule'' under the DOT
Regulatory Policies and Procedures (44 FR 11034, February 26, 1979);
and (3) if promulgated, will not have a significant economic impact,
positive or negative, on a substantial number of small entities under
the criteria of the Regulatory Flexibility Act. A copy of the draft
regulatory evaluation prepared for this action is contained in the
Rules Docket. A copy of it may be obtained by contacting the Rules
Docket at the location provided under the caption ADDRESSES.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
The Proposed Amendment
Accordingly, pursuant to the authority delegated to me by the
Administrator, the Federal Aviation Administration proposes to amend
part 39 of the Federal Aviation Regulations (14 CFR part 39) as
follows:
PART 39--AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
2. Section 39.13 is amended by adding the following new
airworthiness directive:
Airbus Industrie: Docket 99-NM-339-AD.
Applicability: Model A319, A320, and A321 series airplanes;
certificated in any category; equipped with any emergency evacuation
slide having a part number (P/N) listed as follows:
D31516-103
D31516-105
D31516-107
D31516-109
D31517-103
D31517-105
D31517-107
D31517-109
Note 1: This AD applies to each airplane identified in the
preceding applicability provision, regardless of whether it has been
modified, altered, or repaired in the area subject to the
requirements of this AD. For airplanes that have been modified,
altered, or repaired so that the performance of the requirements of
this AD is affected, the owner/operator must request approval for an
alternative method of compliance in accordance with paragraph (c) of
this AD. The request should include an assessment of the effect of
the modification, alteration, or repair on the unsafe condition
addressed by this AD; and, if the unsafe condition has not been
eliminated, the request should include specific proposed actions to
address it.
Compliance: Required as indicated, unless accomplished
previously.
To prevent the ingestion of sill support-log material into the
aspirator of the escape slide which could result in failure of the
escape slide to inflate, accomplish the following:
[[Page 68302]]
Modification
(a) Within three years after the effective date of this AD,
modify the forward and aft emergency evacuation slides by replacing
the Velcro restraints for the support logs with frangible link
restraints, in accordance with Airbus Service Bulletin A320-25-1215,
dated April 29, 1999.
Note 2: Airbus Service Bulletin A320-25-1215 refers to Air
Cruisers Service Bulletin S.B. 004-25-51, dated February 26, 1999,
as an additional source of service information for accomplishment of
the modification.
(b) As of the effective date of this AD, no person shall install
on any airplane an emergency evacuation slide, P/N D31516-103,
D31516-105, D31516-107, D31516-109, D31517-103, D31517-105, D31517-
107, or D31517-109.
Alternative Methods of Compliance
(c) An alternative method of compliance or adjustment of the
compliance time that provides an acceptable level of safety may be
used if approved by the Manager, International Branch, ANM-116, FAA,
Transport Airplane Directorate. Operators shall submit their
requests through an appropriate FAA Principal Maintenance Inspector,
who may add comments and then send it to the Manager, International
Branch, ANM-116.
Note 3: Information concerning the existence of approved
alternative methods of compliance with this AD, if any, may be
obtained from the International Branch, ANM-116.
Special Flight Permits
(d) Special flight permits may be issued in accordance with
sections 21.197 and 21.199 of the Federal Aviation Regulations (14
CFR 21.197 and 21.199) to operate the airplane to a location where
the requirements of this AD can be accomplished.
Note 4: The subject of this AD is addressed in French
airworthiness directive 1999-356-136(B), dated September 8, 1999.
Issued in Renton, Washington, on December 1, 1999.
D.L. Riggin,
Acting Manager, Transport Airplane Directorate, Aircraft Certification
Service.
[FR Doc. 99-31678 Filed 12-6-99; 8:45 am]
BILLING CODE 4910-13-P