[Federal Register Volume 64, Number 223 (Friday, November 19, 1999)]
[Rules and Regulations]
[Pages 63176-63178]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 99-29738]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 99-NM-316-AD; Amendment 39-11421; AD 99-23-25]
RIN 2120-AA64


Airworthiness Directives; Fokker Model F27 Mark 050 Series 
Airplanes

AGENCY: Federal Aviation Administration, DOT.

ACTION: Final rule; request for comments.

-----------------------------------------------------------------------

SUMMARY: This amendment adopts a new airworthiness directive (AD), 
applicable to certain Fokker Model F27 Mark 050 series airplanes. This 
action requires replacement of the lighting plates of the fuel control 
panel and the electrical power control panel with new, improved 
lighting plates. This amendment is prompted by issuance of mandatory 
continuing airworthiness information by a foreign civil airworthiness 
authority. The actions specified in this AD are intended to prevent 
internal short circuits in the fuel control and electrical power 
control panels, which could result in burning of the panels and 
consequent smoke in the flight deck area.

DATES: Effective December 6, 1999.
    The incorporation by reference of certain publications listed in 
the regulations is approved by the Director of the Federal Register as 
of December 6, 1999.
    Comments for inclusion in the Rules Docket must be received on or 
before December 20, 1999.

ADDRESSES: Submit comments in triplicate to the Federal Aviation 
Administration (FAA), Transport Airplane Directorate, ANM-114, 
Attention: Rules Docket No. 99-NM-316-AD, 1601 Lind Avenue, SW., 
Renton, Washington 98055-4056.
    The service information referenced in this AD may be obtained from 
Fokker Services B.V., P.O. Box 231, 2150 AE Nieuw-Vennep, the 
Netherlands. This information may be examined at the FAA, Transport 
Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington; or at 
the Office of the Federal Register, 800 North Capitol Street, NW., 
suite 700, Washington, DC.

FOR FURTHER INFORMATION CONTACT: Norman B. Martenson, Manager, 
International Branch, ANM-116, FAA, Transport Airplane Directorate, 
1601 Lind Avenue, SW., Renton, Washington 98055-4056; telephone (425) 
227-2110; fax (425) 227-1149.

SUPPLEMENTARY INFORMATION: The Rijksluchtvaartdienst (RLD), which is 
the airworthiness authority for the Netherlands, notified the FAA that 
an unsafe condition may exist on certain Fokker Model F27 Mark 050 
series airplanes. The RLD advises that some operators of Fokker Model 
F27 Mark 050 series airplanes have experienced material stress on the 
lighting plates of certain electrical power control panels and fuel 
control panels. These stresses have caused internal short circuits, 
which in turn resulted in burned spots on the lighting plates. During 
these incidents, some smoke and odor was evident. This condition, if 
not corrected, could result in burning of the panels and consequent 
smoke in the flight deck area.

Explanation of Relevant Service Information

    Fokker has issued Component Service Bulletin F7941-005-28-03, dated 
September 15, 1993, which describes procedures for replacement of the 
lighting plate of the fuel control panel with an improved lighting 
plate. Fokker has also issued Component Service Bulletin F7941-011-24-
11, dated September 15, 1993, which describes procedures for 
replacement of the lighting plate of the electrical power control panel 
with an improved lighting plate. Accomplishment of the actions 
specified in the service bulletins is intended to adequately address 
the identified unsafe condition. The RLD classified these service 
bulletins as mandatory and issued Dutch airworthiness directive 93-141 
(A), dated November 1, 1993, in order to assure the continued 
airworthiness of these airplanes in the Netherlands.

FAA's Conclusions

    This airplane model is manufactured in the Netherlands and is type

[[Page 63177]]

certificated for operation in the United States under the provisions of 
section 21.29 of the Federal Aviation Regulations (14 CFR 21.19) and 
the applicable bilateral airworthiness agreement. Pursuant to this 
bilateral airworthiness agreement, the RLD has kept the FAA informed of 
the situation described above. The FAA has examined the findings of the 
RLD, reviewed all available information, and determined that AD action 
is necessary for products of this type design that are certificated for 
operation in the United States.

Explanation of Requirements of the Rule

    Since an unsafe condition has been identified that is likely to 
exist or develop on other airplanes of the same type design registered 
in the United States, this AD is being issued to prevent internal short 
circuits in the fuel control and electrical power control panels, which 
could result in burning of the panels and consequent smoke in the 
flight deck area. This AD requires accomplishment of the actions 
specified in the service bulletins described previously.

Cost Impact

    None of the airplanes affected by this action are on the U.S. 
Register. All airplanes included in the applicability of this rule 
currently are operated by non-U.S. operators under foreign registry; 
therefore, they are not directly affected by this AD action. However, 
the FAA considers that this rule is necessary to ensure that the unsafe 
condition is addressed in the event that any of these subject airplanes 
are imported and placed on the U.S. Register in the future.
    Should an affected airplane be imported and placed on the U.S. 
Register in the future, it would require approximately 2 work hours to 
accomplish the required replacements, at an average labor rate of $60 
per work hour. Required parts would cost approximately $1,480 per 
airplane. Based on these figures, the cost impact of this AD would be 
$1,600 per airplane.

Determination of Rule's Effective Date

    Since this AD action does not affect any airplane that is currently 
on the U.S. register, it has no adverse economic impact and imposes no 
additional burden on any person. Therefore, prior notice and public 
procedures hereon are unnecessary and the amendment may be made 
effective in less than 30 days after publication in the Federal 
Register.

Comments Invited

    Although this action is in the form of a final rule and was not 
preceded by notice and opportunity for public comment, comments are 
invited on this rule. Interested persons are invited to comment on this 
rule by submitting such written data, views, or arguments as they may 
desire. Communications shall identify the Rules Docket number and be 
submitted in triplicate to the address specified under the caption 
ADDRESSES. All communications received on or before the closing date 
for comments will be considered, and this rule may be amended in light 
of the comments received. Factual information that supports the 
commenter's ideas and suggestions is extremely helpful in evaluating 
the effectiveness of the AD action and determining whether additional 
rulemaking action would be needed.
    Comments are specifically invited on the overall regulatory, 
economic, environmental, and energy aspects of the rule that might 
suggest a need to modify the rule. All comments submitted will be 
available, both before and after the closing date for comments, in the 
Rules Docket for examination by interested persons. A report that 
summarizes each FAA-public contact concerned with the substance of this 
AD will be filed in the Rules Docket.
    Commenters wishing the FAA to acknowledge receipt of their comments 
submitted in response to this rule must submit a self-addressed, 
stamped postcard on which the following statement is made: ``Comments 
to Docket Number 99-NM-316-AD.'' The postcard will be date stamped and 
returned to the commenter.

Regulatory Impact

    The regulations adopted herein will not have substantial direct 
effects on the States, on the relationship between the national 
government and the States, or on the distribution of power and 
responsibilities among the various levels of government. Therefore, in 
accordance with Executive Order 12612, it is determined that this final 
rule does not have sufficient federalism implications to warrant the 
preparation of a Federalism Assessment.
    For the reasons discussed above, I certify that this action (1) is 
not a ``significant regulatory action'' under Executive Order 12866; 
(2) is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979); and (3) will not have a 
significant economic impact, positive or negative, on a substantial 
number of small entities under the criteria of the Regulatory 
Flexibility Act. A final evaluation has been prepared for this action 
and it is contained in the Rules Docket. A copy of it may be obtained 
from the Rules Docket at the location provided under the caption 
ADDRESSES.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

    Accordingly, pursuant to the authority delegated to me by the 
Administrator, the Federal Aviation Administration amends part 39 of 
the Federal Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

    1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec. 39.13  [Amended]

    2. Section 39.13 is amended by adding the following new 
airworthiness directive:

99-23-25 Fokker Services B.V.: Amendment 39-11421. Docket 99-NM-316-
AD.

    Applicability: Model F27 Mark 050 series airplanes, serial 
numbers 20103 through 20231 inclusive, certificated in any category, 
and equipped with any control panel having a part number (P/N) 
listed below:

Electrical power control panel P/N:
    F7941-011-407
    F7941-011-413
    F7941-011-425
    F7941-011-435
    W7981-011-401
    W7981-011-403

Fuel control panel P/N:
    F7941-005-403
    F7941-005-407
    F7941-005-409
    F7941-005-411
    F7941-005-413
    F7941-005-415
    W7981-005-401

    Note 1: This AD applies to each airplane identified in the 
preceding applicability provision, regardless of whether it has been 
modified, altered, or repaired in the area subject to the 
requirements of this AD. For airplanes that have been modified, 
altered, or repaired so that the performance of the requirements of 
this AD is affected, the owner/operator must request approval for an 
alternative method of compliance in accordance with paragraph (d) of 
this AD. The request should include an assessment of the effect of 
the modification, alteration, or repair on the unsafe condition 
addressed by this AD; and, if the unsafe condition has not been 
eliminated, the request should include specific proposed actions to 
address it.
    Compliance: Required as indicated, unless accomplished 
previously.

[[Page 63178]]

    To prevent internal short circuits in the fuel control and 
electrical power control panels, which could result in burning of 
the panels and consequent smoke in the flight deck area, accomplish 
the following:

Replacement

    (a) Within one year after the effective date of this AD: Replace 
the lighting plate of the fuel control panel with a new, improved 
plate, in accordance with Fokker Component Service Bulletin F7941-
005-28-03, dated September 15, 1993.
    (b) Within one year after the effective date of this AD: Replace 
the lighting plate of the electrical power control panel with a new, 
improved plate, in accordance with Fokker Component Service Bulletin 
F7941-011-24-11, dated September 15, 1993.

Spare Parts

    (c) As of the effective date of this AD, no person shall install 
a lighting plate, P/N 95-1847-1, 95-1838-1, or 95-1838-3, on any 
airplane.

Alternative Methods of Compliance

    (d) An alternative method of compliance or adjustment of the 
compliance time that provides an acceptable level of safety may be 
used if approved by the Manager, International Branch, ANM-116, FAA, 
Transport Airplane Directorate. Operators shall submit their 
requests through an appropriate FAA Principal Maintenance Inspector, 
who may add comments and then send it to the Manager, International 
Branch, ANM-116.

    Note 2: Information concerning the existence of approved 
alternative methods of compliance with this AD, if any, may be 
obtained from the International Branch, ANM-116.

Special Flight Permits

    (e) Special flight permits may be issued in accordance with 
sections 21.197 and 21.199 of the Federal Aviation Regulations (14 
CFR 21.197 and 21.199) to operate the airplane to a location where 
the requirements of this AD can be accomplished.

Incorporation by Reference

    (f) The actions shall be done in accordance with Fokker 
Component Service Bulletin F7941-005-28-03, dated September 15, 
1993, and Fokker Component Service Bulletin F7941-011-24-11, dated 
September 15, 1993. This incorporation by reference was approved by 
the Director of the Federal Register in accordance with 5 U.S.C. 
552(a) and 1 CFR part 51. Copies may be obtained from Fokker 
Services B.V., P.O. Box 231, 2150 AE Nieuw-Vennep, the Netherlands. 
Copies may be inspected at the FAA, Transport Airplane Directorate, 
1601 Lind Avenue, SW., Renton, Washington; or at the Office of the 
Federal Register, 800 North Capitol Street, NW., suite 700, 
Washington, DC.

    Note 3: The subject of this AD is addressed in Dutch 
airworthiness directive 93-141 (A), dated November 1, 1993.

    (g) This amendment becomes effective on December 6, 1999.

    Issued in Renton, Washington, on November 5, 1999.
D.L. Riggin,
Acting Manager, Transport Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 99-29738 Filed 11-18-99; 8:45 am]
BILLING CODE 4910-13-P