[Federal Register Volume 62, Number 214 (Wednesday, November 5, 1997)]
[Proposed Rules]
[Pages 59826-59827]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 97-29231]


 ========================================================================
 Proposed Rules
                                                 Federal Register
 ________________________________________________________________________
 
 This section of the FEDERAL REGISTER contains notices to the public of 
 the proposed issuance of rules and regulations. The purpose of these 
 notices is to give interested persons an opportunity to participate in 
 the rule making prior to the adoption of the final rules.
 
 ========================================================================
 

  Federal Register / Vol. 62, No. 214 / Wednesday, November 5, 1997 / 
Proposed Rules  

[[Page 59826]]


=======================================================================
-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 97-CE-85-AD]
RIN 2120-AA64


Airworthiness Directives; EXTRA Flugzeugbau GmbH Models EA-300 
and EA-300/S Airplanes

AGENCY: Federal Aviation Administration, DOT.

ACTION: Notice of proposed rulemaking (NPRM).

-----------------------------------------------------------------------

SUMMARY: This document proposes to adopt a new airworthiness directive 
(AD) that would apply to certain EXTRA Flugzeugbau GmbH (EXTRA) Models 
EA-300 and EA-300/S airplanes. The proposed AD would require inspecting 
the upper longeron cutout bridge for cracks, repairing any cracks 
found, and modifying this area. The proposed AD is the result of 
mandatory continued airworthiness information (MCAI) issued by the 
airworthiness authority for Germany. The actions specified by the 
proposed AD are intended to prevent structural damage to the fuselage 
caused by cracks in the upper longeron cutout bridge, which, if not 
detected and corrected, could result in loss of control of the 
airplane.

DATES: Comments must be received on or before December 8, 1997.

ADDRESSES: Submit comments in triplicate to the Federal Aviation 
Administration (FAA), Central Region, Office of the Regional Counsel, 
Attention: Rules Docket No. 97-CE-85-AD, Room 1558, 601 E. 12th Street, 
Kansas City, Missouri 64106. Comments may be inspected at this location 
between 8 a.m. and 4 p.m., Monday through Friday, holidays excepted.
    Service information that applies to the proposed AD may be obtained 
from EXTRA Flugzeugbau GmbH, Flugplatz Dinslaken, 46569 Hunxe, Germany. 
This information also may be examined at the Rules Docket at the 
address above.

FOR FURTHER INFORMATION CONTACT: Mr. Karl Schletzbaum, Aerospace 
Engineer, FAA, Small Airplane Directorate, 1201 Walnut Street, suite 
900, Kansas City, Missouri 64106; telephone (816) 426-6934; facsimile 
(816) 426-2169.

SUPPLEMENTARY INFORMATION:

Comments Invited

    Interested persons are invited to participate in the making of the 
proposed rule by submitting such written data, views, or arguments as 
they may desire. Communications should identify the Rules Docket number 
and be submitted in triplicate to the address specified above. All 
communications received on or before the closing date for comments, 
specified above, will be considered before taking action on the 
proposed rule. The proposals contained in this notice may be changed in 
light of the comments received.
    Comments are specifically invited on the overall regulatory, 
economic, environmental, and energy aspects of the proposed rule. All 
comments submitted will be available, both before and after the closing 
date for comments, in the Rules Docket for examination by interested 
persons. A report that summarizes each FAA-public contact concerned 
with the substance of this proposal will be filed in the Rules Docket.
    Commenters wishing the FAA to acknowledge receipt of their comments 
submitted in response to this notice must submit a self-addressed, 
stamped postcard on which the following statement is made: ``Comments 
to Docket No. 97-CE-85-AD.'' The postcard will be date stamped and 
returned to the commenter.

Availability of NPRMs

    Any person may obtain a copy of this NPRM by submitting a request 
to the FAA, Central Region, Office of the Regional Counsel, Attention: 
Rules Docket No. 97-CE-85-AD, Room 1558, 601 E. 12th Street, Kansas 
City, Missouri 64106.

Discussion

    The Luftfahrt-Bundesamt (LBA), which is the airworthiness authority 
for Germany, recently notified the FAA that an unsafe condition may 
exist on certain EXTRA Models EA-300 and EA-300/S airplanes. The LBA 
reports that life-cycle testing of the referenced airplanes revealed a 
potential for cracking on the upper longeron cutout bridge. These 
conditions, if not detected and corrected, could result in structural 
damage to the fuselage and eventual loss of control of the airplane.

Relevant Service Information

    EXTRA has issued Service Bulletin No. 300-3-93, dated January 12, 
1994, which specifies procedures for inspecting the upper longeron 
cutout bridge for cracks, repairing any cracks found, and modifying 
this area.
    The LBA classified this service bulletin as mandatory and issued 
German AD No. 94-043, dated October 21, 1994, in order to assure the 
continued airworthiness of these airplanes in Germany.

The FAA's Determination

    This airplane model is manufactured in Germany and is type 
certificated for operation in the United States under the provisions of 
section 21.29 of the Federal Aviation Regulations (14 CFR 21.29) and 
the applicable bilateral airworthiness agreement. Pursuant to this 
bilateral airworthiness agreement, the LBA for Germany has kept the FAA 
informed of the situation described above.
    The FAA has examined the findings of the LBA for Germany; reviewed 
all available information, including the service information referenced 
above; and determined that AD action is necessary for products of this 
type design that are certificated for operation in the United States.

Explanation of the Provisions of the Proposed AD

    Since an unsafe condition has been identified that is likely to 
exist or develop in other EXTRA Models EA-300 and EA-300/S airplanes of 
the same type design registered in the United States, the FAA is 
proposing AD action. The proposed AD would require inspecting the upper 
longeron cutout bridge for cracks, repairing any cracks found, and 
modifying this area. Accomplishment of the proposed actions would be in 
accordance with EXTRA Service Bulletin No. 300-3-93, dated January 12, 
1994.

Cost Impact

    The FAA estimates that 68 airplanes in the U.S. registry would be 
affected by

[[Page 59827]]

the proposed AD, that it would take approximately 13 workhours 
(Inspection: 3 workhours; Modification: 10 workhours) per airplane to 
accomplish the proposed action, and that the average labor rate is 
approximately $60 an hour. Parts cost approximately $200 per airplane. 
Based on these figures, the total cost impact of the proposed AD on 
U.S. operators is estimated to be $66,640, or $980 per airplane.

Regulatory Impact

    The regulations proposed herein would not have substantial direct 
effects on the States, on the relationship between the national 
government and the States, or on the distribution of power and 
responsibilities among the various levels of government. Therefore, in 
accordance with Executive Order 12612, it is determined that this 
proposal would not have sufficient federalism implications to warrant 
the preparation of a Federalism Assessment.
    For the reasons discussed above, I certify that this action (1) is 
not a ``significant regulatory action'' under Executive Order 12866; 
(2) is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979); and (3) if promulgated, 
will not have a significant economic impact, positive or negative, on a 
substantial number of small entities under the criteria of the 
Regulatory Flexibility Act. A copy of the draft regulatory evaluation 
prepared for this action has been placed in the Rules Docket. A copy of 
it may be obtained by contacting the Rules Docket at the location 
provided under the caption ADDRESSES.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Safety.

The Proposed Amendment

    Accordingly, pursuant to the authority delegated to me by the 
Administrator, the Federal Aviation Administration proposes to amend 
part 39 of the Federal Aviation Regulations (14 CFR part 39) as 
follows:

PART 39--AIRWORTHINESS DIRECTIVES

    1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec. 39.13  [Amended]

    2. Section 39.13 is amended by adding a new airworthiness directive 
(AD) to read as follows:

Extra Flugzeugbau GMBH: Docket No. 97-CE-85-AD.

    Applicability: The following models and serial number airplanes, 
certificated in any category:

------------------------------------------------------------------------
                   Model                           Serial numbers       
------------------------------------------------------------------------
EA-300....................................  V1 and 01 through 50.       
EA-300/S..................................  01 through 17.              
------------------------------------------------------------------------


    Note 1: This AD applies to each airplane identified in the 
preceding applicability provision, regardless of whether it has been 
modified, altered, or repaired in the area subject to the 
requirements of this AD. For airplanes that have been modified, 
altered, or repaired so that the performance of the requirements of 
this AD is affected, the owner/operator must request approval for an 
alternative method of compliance in accordance with paragraph (d) of 
this AD. The request should include an assessment of the effect of 
the modification, alteration, or repair on the unsafe condition 
addressed by this AD; and, if the unsafe condition has not been 
eliminated, the request should include specific proposed actions to 
address it.

    Compliance: Required as indicated in the body of this AD, unless 
already accomplished.
    To prevent structural damage to the fuselage caused by cracks in 
the upper longeron cutout bridge, which, if not detected and 
corrected, could result in loss of control of the airplane, 
accomplish the following:
    (a) Upon accumulating 1,000 hours time-in-service (TIS) on the 
upper longeron or within the next 100 hours TIS after the effective 
date of this AD, whichever occurs later, inspect the upper longeron 
cutout bridge for cracks in accordance with the Instructions section 
of EXTRA Service Bulletin No. 300-3-93, dated January 12, 1994.
    (b) Prior to further flight after the inspection required by 
paragraph (a) of this AD, accomplish the following in accordance 
with the Instructions section of EXTRA Service Bulletin No. 300-3-
93, dated January 12, 1994:
    (1) Repair any cracks found in the upper longeron cut-out 
bridge; and
    (2) Modify the upper longeron cut-out bridge.
    (c) Special flight permits may be issued in accordance with 
sections 21.197 and 21.199 of the Federal Aviation Regulations (14 
CFR 21.197 and 21.199) to operate the airplane to a location where 
the requirements of this AD can be accomplished.
    (d) An alternative method of compliance or adjustment of the 
compliance time that provides an equivalent level of safety may be 
approved by the Manager, Small Airplane Directorate, FAA, 1201 
Walnut, suite 900, Kansas City, Missouri 64106. The request shall be 
forwarded through an appropriate FAA Maintenance Inspector, who may 
add comments and then send it to the Manager, Small Airplane 
Directorate.

    Note 2: Information concerning the existence of approved 
alternative methods of compliance with this AD, if any, may be 
obtained from the Small Airplane Directorate.

    (e) All persons affected by this directive may obtain copies of 
the document referred to herein upon request to EXTRA Flugzeugbau 
GmbH, Flugplatz Dinslaken, 46569 Hunxe, Germany; or may examine this 
document at the FAA, Central Region, Office of the Regional Counsel, 
Room 1558, 601 E. 12th Street, Kansas City, Missouri 64106.

    Note 3: The subject of this AD is addressed in German AD No. 94-
043, dated October 21, 1994.

    Issued in Kansas City, Missouri, on October 29, 1997.
Mary Ellen A. Schutt,
Acting Manager, Small Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 97-29231 Filed 11-4-97; 8:45 am]
BILLING CODE 4910-13-P