Applicability of General Provisions to Subpart PPPPP

40 Protection of Environment 15 2015-07-01 2015-07-01 false Applicability of General Provisions to Subpart PPPPP 7 Table 7 to Subpart PPPPP of Part 63 Protection of Environment ENVIRONMENTAL PROTECTION AGENCY (CONTINUED) AIR PROGRAMS (CONTINUED) NATIONAL EMISSION STANDARDS FOR HAZARDOUS AIR POLLUTANTS FOR SOURCE CATEGORIES (CONTINUED) National Emission Standards for Hazardous Air Pollutants for Engine Test Cells/Stands Pt. 63, Subpt. PPPPP, Table 7 Table 7 to Subpart PPPPP of Part 63—Applicability of General Provisions to Subpart PPPPP

As stated in 63.9365, you must comply with the General Provisions in §§ 63.1 through 63.15 that apply to you according to the following table:

Citation Subject Brief description Applies to subpart PPPPP § 63.1(a)(1) Applicability General applicability of the General Provisions Yes. Additional terms defined in § 63.9375. § 63.1(a)(2)-(4) Applicability Applicability of source categories Yes. § 63.1(a)(5) [Reserved] § 63.1(a)(6)-(7) Applicability Contact for source category information; extension of compliance through early reduction Yes. § 63.1(a)(8) Applicability Establishment of State rules or programs No. Refers to State programs. § 63.1(a)(9) [Reserved] § 63.1(a)(10)-(14) Applicability Explanation of time periods, postmark deadlines Yes. § 63.1(b)(1) Applicability Initial applicability Yes. Subpart PPPPP clarifies applicability at § 63.9285. § 63.1(b)(2) Applicability Title V operating permit-reference to part 70 Yes. All major affected sources are required to obtain a Title V permit. § 63.1(b)(3) Applicability Record of applicability determination Yes. § 63.1(c)(1) Applicability Applicability after standards are set Yes. Subpart PPPPP clarifies the applicability of each paragraph of subpart A to sources subject to subpart PPPPP. § 63.1(c)(2) Applicability Title V permit requirement for area sources No. Area sources are not subject to subpart PPPPP. § 63.1(c)(3) [Reserved] § 63.1(c)(4) Applicability Extension of compliance for existing sources No. Existing sources are not covered by the substantive control requirements of subpart PPPPP. § 63.1(c)(5) Applicability Notification requirements for an area source becoming a major source Yes. § 63.1(d) [Reserved] § 63.1(e) Applicability Applicability of permit program before a relevant standard has been set Yes. § 63.2 Definitions Definitions for Part 63 standards Yes. Additional definitions are specified in § 63.9375. § 63.3 Units and Abbreviations Units and abbreviations for Part 63 standards Yes. § 63.4 Prohibited Activities Prohibited activities; compliance date; circumvention, severability Yes. § 63.5(a) Construction/Reconstruction Construction and reconstruction—applicability Yes. § 63.5(b)(1) Construction/Reconstruction Requirements upon construction or reconstruction Yes. § 63.5(b)(2) [Reserved]. § 63.5(b)(3) Construction/Reconstruction Approval of construction Yes. § 63.5(b)(4) Construction/Reconstruction Notification of construction Yes. § 63.5(b)(5) Construction/Reconstruction Compliance Yes. § 63.5(b)(6) Construction/Reconstruction Addition of equipment Yes. § 63.5(c) [Reserved] § 63.5(d) Construction/Reconstruction Application for construction reconstruction Yes. § 63.5(e) Construction/Reconstruction Approval of construction or reconstruction Yes. § 63.5(f) Construction/Reconstruction Approval of construction or reconstruction based on prior State review Yes. § 63.6(a) Applicability Applicability of standards and monitoring requirements Yes. § 63.6(b)(1)-(2) Compliance Dates for New and Reconstructed Sources Standards apply at effective date; 3 years after effective date; upon startup; 10 years after construction or reconstruction commences for 112(f) Yes. § 63.6(b)(3) Compliance Dates for New and Reconstructed Sources Compliance dates for sources constructed or reconstructed before effective date No. Compliance is required by startup or effective date. § 63.6(b)(4) Compliance Dates for New and Reconstructed Sources Compliance dates for sources also subject to § 112(f) standards Yes. § 63.6(b)(5) Compliance Dates for New and Reconstructed Sources Notification Yes. § 63.6(b)(6) [Reserved]. § 63.6(b)(7) Compliance Dates for New and Reconstructed Sources Compliance dates for new and reconstructed area sources that become major Yes. § 63.6(c)(1)-(2) Compliance Dates for Existing Sources Effective date establishes compliance date No. Existing sources are not covered by the substantive control requirements of subpart PPPPP. § 63.6(c)(3)-(4) [Reserved]. § 63.6(c)(5) Compliance Dates for Existing Sources Compliance dates for existing area sources that becomes major Yes. If the area source become a major source by addition or reconstruction, the added or reconstructed portion will be subject to subpart PPPPP. § 63.6(d) [Reserved]. § 63.6(e)(1)-(2) Operation and Maintenance Requirements Operation and maintenance Yes. Except that you are not required to have an SSMP for control devices and associated monitoring equipment. § 63.6(e)(3) SSMP 1. Requirement for SSM and SSMP

2. Content of SSMP.

Yes. You must develop an SSMP for each control device and associated monitoring equipment. § 63.6(f)(1) Compliance Except During SSM You must comply with emission standards at all times except during SSM of control devices or associated monitoring equipment Yes, but you must comply with emission standards at all times except during SSM of control devices and associated monitoring equipment only. § 63.6(f)(2)-(3) Methods for Determining Compliance Compliance based on performance test, operation and maintenance plans, records, inspection Yes. § 63.6(g)(1)-(3) Alternative Standard Procedures for getting an alternative standard Yes. § 63.6(h) Opacity/Visible Emission (VE) Standards Requirements for opacity/VE standards No. Subpart PPPPP does not establish opacity/VE standards and does not require continuous opacity monitoring systems (COMS). § 63.6(i)(1)-(14) Compliance Extension Procedures and criteria for Administrator to grant compliance extension No. Compliance extension provisions apply to existing sources, which do not have emission limitations in subpart PPPPP. § 63.6(j) Presidential Compliance Exemption President may exempt source category from requirement to comply with rule Yes. § 63.7(a)(1)-(2) Performance Test Dates Dates for conducting initial performance testing and other compliance demonstrations: Must conduct within 180 days after first subject to rule Yes. § 63.7(a)(3) Section 114 Authority Administrator may require a performance test under CAA Section 114 at any time Yes. § 63.7(b)(1) Notification Performance Test Must notify Administrator 60 days before the test Yes. § 63.7(b)(2) Notification of Rescheduling If have to reschedule performance test, must notify Administrator 5 days before schedule date of rescheduled date Yes. § 63.7(c) Quality Assurance/Test Plan 1. Requirement to submit site-specific test plan 60 days before the test or on date Administrator agrees with Yes. 2. Test plan approval procedures Yes. 3. Performance audit requirements Yes. 4. Internal and external QA procedures for testing Yes. § 63.7(d) Testing Facilities Requirements for testing facilities Yes. § 63.7(e)(1) Conditions for Conducting Performance Tests Performance tests must be conducted under representative conditions; cannot conduct performance tests during SSM; not a violation to exceed standard during SSM Yes. § 63.7(e)(2) Conditions for Conducting Performance Tests Must conduct according to rule and EPA test methods unless Administrator approves alternative Yes. § 63.7(e)(3) Test Run Duration 1. Must have three test runs of at least 1 hour each Yes. 2. Compliance is based on arithmetic mean of three runs Yes. 3. Conditions when data from an additional test run can be used Yes. § 63.7(e)(4) Other Performance Testing Administrator may require other testing under section 114 of the CAA Yes. § 63.7(f) Alternative Test Method Procedures by which Administrator can grant approval to use an alternative test method Yes. § 63.7(g) Performance Test Data Analysis 1. Must include raw data in performance test report Yes. 2. Must submit performance test data 60 days after end of test with the Notification of Compliance Status Yes. 3. Keep data for 5 years Yes. § 63.7(h) Waiver of Tests Procedures for Administrator to waive performance test Yes. § 63.8(a)(1) Applicability of Monitoring Requirements Subject to all monitoring requirements in standard Yes. Subpart PPPPP contains specific requirements for monitoring at § 63.9325. § 63.8(a)(2) Performance Specifications Performance Specifications in appendix B of part 60 apply Yes. § 63.8(a)(3) [Reserved] § 63.8(a)(4) Monitoring with Flares Unless your rule says otherwise, the requirements for flares in 63.11 apply No. Subpart PPPPP does not have monitoring requirements for flares. § 63.8(b)(1) Monitoring Must conduct monitoring according to standard unless Administrator approves alternative Yes. § 63.8(b)(2)-(3) Multiple Effluents and Multiple Monitoring Systems 1. Specific requirements for installing monitoring systems Yes. 2. Must install on each effluent before it is combined and before it is released to the atmosphere unless Administrator approves otherwise Yes. 3. If more than one monitoring system on an emission point, must report all monitoring system results, unless one monitoring system is a backup Yes. § 63.8(c)(1) Monitoring System Operation and Maintenance Maintain monitoring system in a manner consistent with good air pollution control practices Yes. § 63.8(c)(1)(i) Routine and predictable CMS malfunctions 1. Keep parts for routine repairs of CMS readily available

2. Reporting requirements for SSM when action is described in SSMP

Yes. 3. Reporting requirements for SSM when action is described in SSMP Yes. § 63.8(c)(1)(ii) SSM of CMS Not in SSMP Reporting requirements for SSM of CMS when action is not described in SSMP Yes. § 63.8(c)(1)(iii) Compliance with Operation and Maintenance Requirements 1. How Administrator determines if source complying with operation and maintenance requirements

2. Review of source O&M procedures, records, manufacturer's instructions and recommendations, and inspection

Yes. § 63.8(c)(2)-(3) Monitoring System Installation 1. Must install to get representative emission of parameter measurements Yes. 2. Must verify operational status before or at performance test Yes. § 63.8(c)(4) Continuous Monitoring System (CMS) Requirements 1. CMS must be operating except during breakdown, out of control, repair, maintenance, and high-level calibration drifts No. Follow specific requirements in § 63.9335(a) and (b) of subpart PPPPP. 2. COMS must have a minimum of one cycle of sampling and analysis for each successive 10-second period and one cycle of data recording for each successive 6-minute period No. Follow specific requirements in § 63.9335(a) and (b) of subpart PPPP. 3. CEMS must have a minimum of one cycle of operation for each successive 15-minute period No. Follow specific requirements in § 63.9335(a) and (b) of subpart PPPPP. § 63.8(c)(5) COMS Minimum Procedures COMS minimum procedures No. Subpart PPPPP does not have opacity/VE standards. § 63.8(c)(6)-(8) CMS Requirements Zero and high-level calibration check requirements, out-of-control periods Yes. Except that PPPP does not require COMS. § 63.8(d) CMS Quality Control 1. Requirements for CMS quality control, including calibration, etc Yes. 2. Must keep quality control plan on record for 5 years. Keep old versions for 5 years after revisions Yes. § 63.8(e) CMS Performance Evaluation Notification, performance evaluation test plan, reports Yes. Except for § 63.8(e)(5)(ii), which applies to COMS. § 63.8(f)(1)-(5) Alternative Monitoring Method Procedures for Administrator to approve alternative monitoring Yes. § 63.8(f)(6) Alternative to Relative Accuracy Test Procedures for Administrator to approve alternative relative accuracy tests for CEMS Yes. § 63.8(g) Data Reduction 1. COMS 6-minute averages calculated over at least 36 evenly spaced data points

2. CEMS 1-hour averages computed over at least 4 equally spaced data points

Yes. Except that provisions for COMS are not applicable. Averaging periods for demonstrating compliance are specified at § 63.9340. § 63.8(g)(5) Data Reduction Data that cannot be used in computing averages for CEMS and COMS No. Specific language is located at § 63.9335(a). § 63.9(a) Notification Requirements Applicability and State delegation Yes. § 63.9(b)(1)-(5) Initial Notifications 1. Submit notification subject 120 days after effective date Yes. 2. Notification of intent to construct/ reconstruct; notification of commencement of construct/ reconstruct; notification of startup Yes. 3. Contents of each Yes. § 63.9(c) Request for Compliance Extension Can request if cannot comply by date or if installed BACT/LAER No. Compliance extensions do not apply to new or reconstructed sources. § 63.9(d) Notification of Special Compliance Requirements for New Source For sources that commence construction between proposal and promulgation and want to comply 3 years after effective date Yes. § 63.9(e) Notification of Performance Test Notify Administrator 60 days prior No. Subpart PPPPP does not require performance testing. § 63.9(f) Notification of Opacity/VE Test Notify Administrator 30 days prior No. Subpart PPPPP does not have opacity/VE standards. § 63.9(g)(1) Additional Notifications when Using CMS Notification of performance evaluation Yes. § 63.9(g)(2) Additional Notifications when Using CMS Notification of use of COMS data No. Subpart PPPPP does not contain opacity or VE standards. § 63.9(g)(3) Additional Notifications when Using CMS Notification that exceeded criterion for relative accuracy Yes. If alternative is in use. § 63.9(h)(1)-(6) Notification of Compliance Status 1. Contents Yes. 2. Due 60 days after end of performance test or other compliance demonstration, except for opacity/VE, which are due 30 days after Yes. 3. When to submit to Federal vs. State authority Yes. § 63.9(i) Adjustment of Submittal Deadlines Procedures for Administrator to approve change in when notifications must be submitted Yes. § 63.9(j) Change in Previous Information Must submit within 15 days after the change Yes. § 63.10(a) Recordkeeping/Reporting 1. Applies to all, unless compliance extension Yes. 2. When to submit to Federal vs. State authority Yes. 3. Procedures for owners of more than one source Yes. § 63.10(b)(1) Recordkeeping/Reporting 1. General requirements Yes. 2. Keep all records readily available Yes. 3. Keep for 5 years Yes. § 63.10(b)(2)(i)-(v) Records Related to SSM 1. Occurrence of each of operation (process equipment) Yes. 2. Occurrence of each malfunction of air pollution equipment Yes. 3. Maintenance on air pollution control equipment Yes. 4. Actions during SSM Yes. 5. All information necessary to demonstrate conformance with the SSMP Yes. § 63.10(b)(2)(vi)-(xi) CMS Records Malfunctions, inoperative, out of control Yes. § 63.10(b)(2)(xii) Records Records when under waiver Yes. § 63.10(b)(2)(xiii) Records Records when using alternative to relative accuracy test Yes. § 63.10(b)(2)(xiv) Records All documentation supporting initial notification and notification of compliance status Yes. § 63.10(b)(3) Records Applicability determinations Yes. § 63.10(c)(1)-(6), (9)-(15) Records Additional records for CEMS Yes. § 63.10(c)(7)-(8) Records Records of excess emissions and parameter monitoring exceedances for CMS No. Specific language is located at § 63.9355 of subpart PPPPP. § 63.10(d)(1) General Reporting Requirements Requirement to report Yes. § 63.10(d)(2) Report of Performance Test Results When to submit to Federal or State authority Yes. § 63.10(d)(3) Reporting Opacity or VE Observations What to report and when No. Subpart PPPPP does not have opacity/VE standards. § 63.10(d)(4) Progress Reports Must submit progress reports on schedule if under compliance extension No. Compliance extensions do not apply to new or reconstructed sources. § 63.10(d)(5) SSM Reports Contents and submission Yes. § 63.10(e)(1) and (2)(i) Additional CMS Reports Additional CMS reports Yes. § 63.10(e)(2)(ii) Additional CMS Reports COMS-related report No. Subpart PPPPP does not require COMS. § 63.10(e)(3) Additional CMS Reports Excess emissions and parameter exceedances reports No. Specific language is located in § 63.9350 of subpart PPPPP. § 63.10(e)(4) Additional CMS Reports Reporting COMS data No. Subpart PPPPP does not require COMS. § 63.10(f) Waiver for Recordkeeping/Reporting Procedures for Administrator to waive Yes. § 63.11 Control Device Requirements Requirements for flares No. Subpart PPPPP does not specify use of flares for compliance. § 63.12 State Authority and Delegations State authority to enforce standards Yes. § 63.13 Addresses of State Air Pollution Control Offices and EPA Regional Offices Addresses where reports, notifications, and requests are sent Yes. § 63.14 Incorporations by Reference Test methods incorporated by reference Yes. ASTM D 6522-00 and ANSI/ASME PTC 19.10-1981 (incorporated by reference-See § 63.14). § 63.15 Availability of Information and Confidentiality Public and confidential information Yes. [68 FR 28785, May 27, 2003, as amended at 71 FR 20470, Apr. 20, 2006]